Greenheck FanメーカーMSCF-BIの使用説明書/サービス説明書
ページ先へ移動 of 20
Only qualified personnel should install this unit. Personnel should have a clear understanding of these instructions and should be aware of general safety precautions. Impr oper installation can result in electric shock, possible injury due to coming in contact with moving parts, as well as other potential hazards.
2 Model MSCF Modular Small Cabinet Fan ® The unit should be stored at least 3½ in. (89 mm) of f the floor on wooden blocks covered with moistur e proof paper or polyethylene sheathing. Aisles between parts and along all walls should be provided to permit air circulation and space for inspection.
3 Model MSCF Modular Small Cabinet Fan ® T able of Contents Installation U n i t L a y o u t .............................. . 3 Mounting / Hanging Instructions . . . . . . . . . . . . . 4 Mounting Dimensions ...................... 5 Dimensions / Weights .
4 Model MSCF Modular Small Cabinet Fan ® Hanging Bracket Part No. 710774 Drawing No. 85537 Hanging Bracket Part No. 710774 Drawing No. 85537 Bridge Bracket Part No. 711779 Drawing No. 89814 One required per assembly Bridge Bracket Part No. 711779 Drawing No.
5 Model MSCF Modular Small Cabinet Fan ® 24 PLENUM 12 PLENUM CHILLED WA TER COIL HEA TING COIL VERTICAL FIL TER FA N MIXING BOX w/DAMPER MSCF Mounting Dimensions A B C D E F G H M Modular Constructio.
6 Model MSCF Modular Small Cabinet Fan ® Dimensional Data Filter Sizes and Quantity Unit Size A B C D E F G Unit Width Inlet Outlet w/o Filter w/ Filter 12 in. 24 in. Vertical Sloped Hot Water 1 & 2 Row 4 Row HW & Steam Height Width Height Width 15 11 24.
7 Model MSCF Modular Small Cabinet Fan ® Coil Dimensions NOTE Fluid enters the coil from the bottom connection (Inlet) and exits from the top (Outlet). Hot W ater • 1 and 2 Row Unit Size Face Area A B C D E F 15 1.6 38 12.75 11.0 3.0 0.75 .5 20 2.2 38 12.
8 Model MSCF Modular Small Cabinet Fan ® NOTE With airflow from left to right, the fluid enters the coil from the bottom connection (Inlet) and exits from the top (Outlet).
9 Model MSCF Modular Small Cabinet Fan ® Direct Expansion (DXI) • 4, 6 or 8 Row Dual Circuit with 50/50 Face Interlaced Construction NOTE The first suction header on the entering air side of the coil is circuited to the top distributor .
10 Model MSCF Modular Small Cabinet Fan ® any two supply power connections will reverse the direction of r otation. T o reverse the r otation, turn the power off and use the following procedur e: • Forsinglephaseunits,rewir ethemotorperthe instructions on the motor .
11 Model MSCF Modular Small Cabinet Fan ® Symptom Possible Cause Corrective Action Blower fails to operate Blown fuse or open circuit br eaker Replace fuse or r eset circuit br eaker and check amps B.
12 Model MSCF Modular Small Cabinet Fan ® Hot W ater and Chilled W ater 1. Piping should be in accordance with accepted industry standards. Pipework should be supported independently of the coils. Water pipes are copper with sweat connections. USE WET TOWEL TO AVOID BURNING COIL CONNECTION GROMMETS.
13 Model MSCF Modular Small Cabinet Fan ® 2P = minimum 2P = minimum Drain Pan / Drain T rap Drain Pan / Drain T rap Drain lines and traps should be run full size from the drain pan connection. Drain pans should have drain lines and traps to permit the condensate from the coils to drain freely .
14 Model MSCF Modular Small Cabinet Fan ® Installation of Electric Heater (optional) W ARNING Electrical Shock Hazard! Disconnect all power sources befor e doing any work on the unit.
15 Model MSCF Modular Small Cabinet Fan ® Sequence of Operation - Electric Heater 1. Electric heaters are divided in to equally sized steps. For example, a 60 kW heater with 3 steps will have 20 kW per step. The thermostat and step controller will contr ol these steps.
16 Model MSCF Modular Small Cabinet Fan ® Every Three (3) Months Filters - The filter in the unit should be inspected at least every three (3) months. Depending on the environment, filters could r equire changing or cleaning more or less often. The filters can be slid out of the coil connection side of the unit.
17 Model MSCF Modular Small Cabinet Fan ® Coil Maintenance Start-Up Documentation CAUTION Fin edges are sharp. Coils must be clean to obtain maximum performance. Check once a year under normal operating conditions and, if dirty , brush or vacuum clean.
18 Model MSCF Modular Small Cabinet Fan ® Maintenance Log Date __________________ Time _____________ AM/PM Notes:___________________________________________ __________________________________________.
19 Model MSCF Modular Small Cabinet Fan ® Maintenance Log Date __________________ Time _____________ AM/PM Notes:___________________________________________ __________________________________________.
Greenheck warrants this equipment to be fr ee from defects in material and workmanship for a period of one year fr om the purchase date. Any units or parts which pr ove defective during the warranty period will be replaced at our option when returned to our factory , transportation pr epaid.
デバイスGreenheck Fan MSCF-BIの購入後に（又は購入する前であっても）重要なポイントは、説明書をよく読むことです。その単純な理由はいくつかあります：
Greenheck Fan MSCF-BIをまだ購入していないなら、この製品の基本情報を理解する良い機会です。まずは上にある説明書の最初のページをご覧ください。そこにはGreenheck Fan MSCF-BIの技術情報の概要が記載されているはずです。デバイスがあなたのニーズを満たすかどうかは、ここで確認しましょう。Greenheck Fan MSCF-BIの取扱説明書の次のページをよく読むことにより、製品の全機能やその取り扱いに関する情報を知ることができます。Greenheck Fan MSCF-BIで得られた情報は、きっとあなたの購入の決断を手助けしてくれることでしょう。
Greenheck Fan MSCF-BIを既にお持ちだが、まだ読んでいない場合は、上記の理由によりそれを行うべきです。そうすることにより機能を適切に使用しているか、又はGreenheck Fan MSCF-BIの不適切な取り扱いによりその寿命を短くする危険を犯していないかどうかを知ることができます。
ですが、ユーザガイドが果たす重要な役割の一つは、Greenheck Fan MSCF-BIに関する問題の解決を支援することです。そこにはほとんどの場合、トラブルシューティング、すなわちGreenheck Fan MSCF-BIデバイスで最もよく起こりうる故障・不良とそれらの対処法についてのアドバイスを見つけることができるはずです。たとえ問題を解決できなかった場合でも、説明書にはカスタマー・サービスセンター又は最寄りのサービスセンターへの問い合わせ先等、次の対処法についての指示があるはずです。
