CarrierメーカーT--298の使用説明書/サービス説明書
ページ先へ移動 of 49
R T ransport Air Conditioning T - - 298 Rev D SER VICE MANUAL for MODEL AirV Rooftop Air Conditioning Systems R T ransport Air Conditioning 2P C F H 1 2 BLK BLU WHT WHT EV AP .
SER VICE MANUAL For MODELS 68R V1 1302A 68R V14102A 68R V14103A 68R V141 12A 68R V15102A 68R V15103A AirV AIR CONDITIONING AND HEA TING EQUIPMENT.
T -298 Safe ty- - i SA FETY S UMMAR Y GENE RAL SAFE TY NOT ICES The f ollowing general safet y notic es supplement the spec ific warnings and caut ions appearing elsewher e in this m anual. They are recomm ended precautions t hat mus t be understood and applied during oper ation and maint enance of the equipment cov ered herein.
T - - 298 Safe ty- - ii SPECIF IC W ARNING AND CAUTI ON ST A TEMENTS The st atement s list ed below are applicable to t he refriger ation unit and appear elsewhere in this manual. Thes e recommended prec autions mus t be underst ood and applied during operat ion and maintenance of the equipment covered her ein.
T -298 Safe ty- - i ii CAUTI ON Coi l fi ns are sharp . Use care w hen remo ving the co ver form th e base p an to avo id perso nal injury . CAUTI ON The cha nge fr om Fahre nheit to Cels ius will be per mane nt. It ca nnot be cha nged back to Fahr- enhe it.
i T - - 298 T ABLE OF CONTENTS P ARAG RAPH NUMBER Page DESCRI PTI ON 1- 1 ............................................................................... 1.1 I NTRODUCT ION 1-1 ..................................................................... 1.2 SERIAL NUMBER IDENTIFICA T ION 1-1 .
ii T - - 298 T A BLE OF CONTE NTS - Conti nued 3.4 CEILI NG UNIT - DUCT ED SYSTEMS 3-4 ................................................... 3.4. 1 Filt er Removal 3-4 .................................................................... 3.4. 2 Ceiling Grill Rem oval 3-4 .
iii T - - 298 T ABLE OF C ONTE NTS - Continue d 3.1 1 CHECK THERMOST A T O PERA T ION 3-16 ................................................... 3.1 1.1 T emper ature Display 3-16 ............................................................... 3.1 1.2 T imeguar d T imer 3-17 .
iv T - - 298 LIST OF FIGURES Figur e 3-26 Cover Ass embly - Low Pr ofile 3-10 ....................................................... Figur e 3-27 Upper Scr oll Assembly Loc king T abs (b. ) & Sc rew Locations (c. ) 3-10 ......................... Figur e 3-28 Upper Scr oll Assembly K eeper T ab Release 3-10 .
T - - 298 1-1 SECTI ON 1 DESCRIPTION 1.1 I NTRODUCT ION This m anual cont ains servic e instruct ions and electrical data f or the Air V , Carr ier T ranspor t Air Conditioning’s Recreat ional V ehicle air condit ioning unit. The Ai rV uni ts are two piece systems, con sisting of the Upper Unit and the C eiling unit .
T - - 298 1-2 T able 1- 1. M odel Cha rt UPPER UNIT (ROOF) Model N umbe r Part Numb er Vo l t a g e Amps Co lo r 11 5 V Standar d S y stem 99- - 00468 - - 00 1 15/ 1/60 12.8 White 1 1 5 V S t a n d a r d S y s t e m 68RV14102A 99- - 00468 - - 01 1 15/1/ 60 12.
T - - 298 1-3 T able 1- 2 Additiona l Suppor t Manua ls MANUAL - - F ORM NO. EQUIPMENT COVERED TYP E OF MANUAL (For) P ART NO . 71LC6A54310 AirV 1 15 V olts - - F ree Blow (Cool O nly) Own er ’ s Gu.
T - - 298 1-4 1 2 3 4 1. Ceiling Panel As sembly 2. Contr ol Box Cover 3. Contr ol Assembly 4. Ceiling Gr ill Assembly Figure 1- 3 Ce iling U nit Compone nt Identific ation (Fre e - -Blow).
T - - 298 1-5 1 2 3 4 5 6 8 7 9 10 11 1. Co ver Assembly 2. Scr oll Assembly - - Upper 3. Condenser F an 4. Condenser Mot or 5. Evapor ator Mot or 6. Evapor ator Blower W heel 7. Condenser Coil 8. Scr oll Assembly - - Lower 9. Evapor ator Coil 10. C ompressor 1 1.
T - - 298 1-6 1 2 3 4 5 6 7 8 9 10 11 12 1. T elesc oping Divider (3 differ ent sizes available) 2. Divider As sembly 3. Fr ame Panel, I nsulation As sembly 4. Contr ol Box Ass embly 5. Contr ol Box Cover 6. Suctio n Packing Assemb ly 7. Re mote Control Assemb ly 8.
T - - 298 1-7 1 2 3 4 5 SCHEMA TIC VIEW INST ALLED VIEW 3 2 1 1 4 5 SUPPL Y AIR RETURN AI R SUPPL Y AIR 1. V ehicle Duct Sy stem ( Connection) 2. T elesc oping Divider (3 differ ent sizes available) 3. Retur n Air Suct ion Area 4. Contr ol Box Ass embly 5.
T - - 298 1-8 Serial Num ber of Ceiling Unit Serial num ber of Upper Unit Upper Unit Ceiling Uni t (Cov er Remov ed) Free Blow T ype Botto m V iew After In stal lati on (W ith Grille Rem oved) Ceiling.
T - - 298 1-9 1.4 AirV SYSTEM COMPONENT SPECIFI - CA TIONS 1.4. 1 Refri gerant Ch arge Standar d - - High Capacity - - Heat Pump R- - 22 - - 15.9 Ounces Low Prof ile (All) R- - 22 - - 16.9 Ounces 1.4. 2 Comp ressor - - 1 15 V o lts, 60 Cycl es, 1 Phase a.
T - - 298 1-10 1.7 REF RIGERANT CY CLE - - HEA T PUMP STRAINER OUTDOOR COIL INDOOR COIL REVERSING V AL VE ACCUMUL A T OR COMPRESSOR CAPILLAR Y TUBE DISCHARGE SUCTION LIQU ID Fi gure 1 -9 Refrig erant F low Sch ematic - - Heat P ump - - ( Cool Mo de) 1.
T - - 298 1-1 1 COMPRESSOR ACCUMUL A T OR REVERSING V AL VE INDOOR COIL OUTDOOR COIL STRAINER CAPILLAR Y TUBE DISCHARGE SUCTION LIQU ID Figure 1-1 0 Re frige rant Flow Sc hem atic - - He at Pum p - - (Hea t Mode) 1.
T - - 298 2-1 SECTI ON 2 TROUBLESHOOTING For duc ted units , the gr ee n opera tion indica tor LE D (Se eFigur e 3 - 9) will flash if the re is a proble m. Re fer to T able 2- - 1 for dia gnostic infor mat ion. SYMP TOM AND PRO BABLE CAUSE PROBABL E REMEDY 2.
T - - 298 2-2 SYSTEM AND PRO BABLE CAUSE PRO BABLE REME DY 2.6 CYCLES ON COMPRESSOR O VER LO AD 1. Def ective r un capacitor 2. Defec tive compr essor bearings or valv es 3. G reatly r estric ted evaporat or air , ic ed evaporator coil. 4. Low refriger ant charge 5.
T - - 298 2-3 SYSTEM AND PRO BABLE CAUSE PRO BABLE REME DY 2.14 INADE QUA T E HEA T (FRE E - - BLO W HEA T O NL Y ) 1. No heat from heat st rip. 1. V eri fy AMP draw . ( 13 .8 AMP) V erif y resist ance through heat ing element. (9 O HM) Check bi- - met al swit ch.
T - - 298 2-4 T able 2 - - 1 Sys tem Se lf - -diagnostic s Function (D ucte d R emote ) Fl ashes Erro r Codes (Priority) Error Co nten ts (Malfunction) Disp lay Pat tern Allowed Mode s 2 1 ROO M AIR T HERM- ISTO R F AILURE 3sec . 3sec . 0.5 sec. (Twice ) F AN Mode 3 2 IND OOR COIL THERMISTOR F AIL- URE 3sec .
T - - 298 3-1 SECTI ON 3 SERVICE AND MAINTENANCE 3.1 P REVENT A T IVE MAINTE NANCE Clean ing - - Clean ev aporator c oil and c ondenser coil. Hold flas hlight behind coil to s ee if all spaces are c lear . Dust acc umulation obst ructs or r educes airflow and result s in loss of cooling capacity .
T - - 298 3-2 d. T o replace t he grill, place the grill up against the ceil- ing panel and align t he scr ew holes in t he grill wit h t he ceiling panel. e. Replac e 4 screws. Mount ing Screws Figure 3- 2 Ce iling Gr ill - - Fre e Blow 3.3 .3 Ce iling Pane l Rem ova l T o rem ove the ceiling panel (F igure 3- 3) do t he following: a.
T - - 298 3-3 3.3 .6 Indoor Ther most at Re mova l T o rem ove the indoor t hermost at (Figure 3-6) do the following: a. Rem ove ceiling grille. ( Refer t o paragraph 3.3. 2.) b. Rem ove 5 screws s ecuring the c ontrol assembly (it em 3, Figur e 1-3) to t he contr ol box cover .
T - - 298 3-4 3.4 CEI LING UNIT - - DUCT ED SYSTEMS 3.4. 1 Fi lter Remo val The f ilters ( Figure 3-9) are locat ed in the ceiling grill. T o remove t he filt ers, do t he following: a. G rasp the edge of t he filter at reces s in the end of the ceiling grill.
T - - 298 3-5 1 15V AC 12V DC Fus e Upper Unit Connector s Furnace Wir es (blue) #1 #2 Fi gure 3 -12 Cont rol Bo x Assembly - - Du cted 3.4. 4 Main P CB Bo ard Removal T o r emove the Main PCB boar d (Figure 3-13) do t he following: a. Rem ove ceiling grill.
T - - 298 3-6 3.5. 2 Comp ressor Rep lacement Obs erve the sam e procedures f or rot ary compr essors as for recipro cating compre ssors. a. F ollow all safet y codes. Rem inder: use protec tive goggles, wor k glov es, and water soaked quenching clot h.
T - - 298 3-7 3.5. 4 Upp er Scrol l Assembl y Removal a. Remove ex terior cover ass embly . Ref er to paragraph 3.5. 1. b. Remove 4 sc rews securing upper scroll ass embly to the lower scroll assembly . ( See Figure 3- 18) c. G ently pr y 4 snap clips open and lif t the upper scroll assemb ly off o f the lo wer scroll assembly .
T - - 298 3-8 Condenser F an Figure 3- 22 C ondense r Fan Re mova l 3.5. 6 Evap orator Bl ow er Wheel Ad ju stment o r Removal a. Rem ove exterior cover ass embly . Refer t o Ext erior Cover As sembly Removal inst ructions 3. 5.1 b. Remove c ontrol box assem bly .
T - - 298 3-9 3.5.8 Capa citor T r oubleshoot ing W ARNI NG Dis connec t powe r to the A irV unit before checki ng t he capaci tor . T o t est capacit or to det ermine if good, open or short ed, an ohm met er can be used. T o determ ine a capacitor ’s capacit ance, a capacit or meter is requir ed.
T - - 298 3-10 3.6 SER VICE - - UPPER UNIT - - LOW PROFILE 3.6. 1 Exteri or Cover Remo val CAUTI ON Coi l fi ns are sharp . Use care w hen removi ng th e cover form t he base p an to avo id p er- sona l injury . T o rem ove the ext erior cover, do the f ollowing: a.
T - - 298 3-1 1 Evapor ator Coil Condenser Coil Figure 3- 29 U pper Sc roll & Contr ol B ox Cover Remo ved 3.6 .3 Conde nser Fa n A ssembl y Removal T o rem ove condenser f an assembly , do the f ollowing: a. P erform s teps out lined in Section 3.
T - - 298 3-12 3.6 .4 Conde nser M otor Re mova l T o rem ove condenser f an motor, do the following: a. P erform s teps out lined in Section 3. 6.2. b. Rem ove (3) 13MM bolts ( See Figure 3- 31). c. Remov e (3) Gr ommets . Inspect , replace or reuse.
T - - 298 3-13 NOT E Wh en reassemb lin g the b lo wer wheel o n to the mot or shaf t ensur e that the blower whee l is flush with the end of the motor shaf t (SeeFigure 3- 36) .
T - - 298 3-14 a. Rem ove the batt eries f rom the r emote cont rol. b. Caref ully r emove t he r emote c over by ins erting a nar- row f lat object bet ween the cover and r emote body and prying apar t. c. Rem ove the bras s screw holding t he PCB in place.
T - - 298 3-15 3.7 THE RMOST A T INS T AL LA T ION AND ST ART - - UP INST RUCTI ONS (WALL MO UNTED) 3.7 .1 Introduc tion The t hermost at is a wall mount ed, low- - volt age ther mostat which maint ains room temper ature by contr olling the operat ion of a heating and air conditioning syst em.
T - - 298 3-16 NOT E If t he F AN butt on is pr essed again or if no butt on is pressed f or t wo minutes, t he thermos tat will exit t he configur ation mode and ret urn to nor - mal operation. T o re - - ent er t he configurat ion mode, t he F AN butt on must be press ed and held for 10 seconds again.
T - - 298 3-17 3.1 1. 2 Timeg uard Timer A 3 - - m inute tim eguard is built into t he t hermost at immediat ely upon power up, and any t ime the compr essor (output “Y ”) turns off . The compres sor will not t urn on unt il the t imeguard has expir ed.
T - - 298 3-18 POW ERBOX ASSEMBL Y UPPER UNIT 12 34 2 1 12 3 4 1 2 3 4 5 1 2 L N2 N1 W Y GH GL C TB Y GH GL R C COOL ( Compressor ) F AN (Hi gh) F AN (Low) 12V DC LowVoltage Power Supply CEILING UNI T FURNACE + 12VDC 12 VDC (Gnd) Motor C omp.
T - - 298 4-1 SECTI ON 4 WIRING SCHEMA TICS 4.1 I NTRODUCT ION This S ection cont ains wiring sc hematics f or the A irV units . Figur e 4- - 1 is t he schemat ic for t he standar d upper unit ass embly and it is applic able to all st andard units. Figur e 4- - 2 is t he schemat ic for the Low P rofile upper unit assem bly .
T - - 298 4-2 2P GRN/YEL ORN WHT WHT ASM PLUG CONNECTS T O UPPER UNIT . SEE DIAGR AM SUPPLIED WITH UPPER UN IT FOR ADDITION AL WIRING. 4P 2P 1 1 2 3 4 2 { ASW O (OFF) I( O N ) 2 2- -1 SWITCH POSITION CONT ACTS MADE HIGH FAN LOW F AN OFF LOW COOL 1- -4 .
T - - 298 4-3 CONTROL BOX EV AP . RVC 2P 4P 2P 2P 4P C F H BLK BLU BLK BLU WHT WHT BRN BLK BLK BLK(BL U) GRN/YEL GRN/YEL GRN/YEL WHT WHT WHT BRN BRN 1 (3) 2 CAP ACI TOR YEL RED RED OLP (IF U SED) BLU .
T - - 298 4-4 LEGE ND RVC PLUG CONNECT S T O CEIL ING UNIT . SEE DIAGR AM SUPPLIED WITH CEIL ING UNIT FOR A DDITIONAL WIRI NG. CN CN C F H OLP :O VERLO AD PROT ECTO R PTC :ST ART TH ERMISTO R RVC :REV.
T - - 298 4-5 Figure 4 - - 1 0 Ce iling U nit - - W a ll The rmos tat - - Ducte d & Fr ee Blow 4.2 W ALL MOUNTED THERMOST A T S For proper wiring of W all Mounted T hermost ats as an ac cessory , .
Index - 1 T - - 298 INDEX A Air Handling Sys tem , 3-8 Air S weep Removal, 3-3 Air S weep Switch , 3-2 C Capacitor T est ing, 3-9 Capacitor T es ting and Replacement , 3-9 Ceiling Grill - - Duc ted, 3.
© 2006 Carrier Corporatio n D Printed in U. S. A. 0606 Carrier Transport A ir Conditi oning 50 Grumbac her Road Y ork P A 17402 USA T el : 1 - - 800 - -673 - -2431 Fax : 1 - - 717 - -764 - - 0401 A mem ber of the Uni ted T ec hnologies Corporati on famil y .
デバイスCarrier T--298の購入後に（又は購入する前であっても）重要なポイントは、説明書をよく読むことです。その単純な理由はいくつかあります：
Carrier T--298をまだ購入していないなら、この製品の基本情報を理解する良い機会です。まずは上にある説明書の最初のページをご覧ください。そこにはCarrier T--298の技術情報の概要が記載されているはずです。デバイスがあなたのニーズを満たすかどうかは、ここで確認しましょう。Carrier T--298の取扱説明書の次のページをよく読むことにより、製品の全機能やその取り扱いに関する情報を知ることができます。Carrier T--298で得られた情報は、きっとあなたの購入の決断を手助けしてくれることでしょう。
Carrier T--298を既にお持ちだが、まだ読んでいない場合は、上記の理由によりそれを行うべきです。そうすることにより機能を適切に使用しているか、又はCarrier T--298の不適切な取り扱いによりその寿命を短くする危険を犯していないかどうかを知ることができます。
ですが、ユーザガイドが果たす重要な役割の一つは、Carrier T--298に関する問題の解決を支援することです。そこにはほとんどの場合、トラブルシューティング、すなわちCarrier T--298デバイスで最もよく起こりうる故障・不良とそれらの対処法についてのアドバイスを見つけることができるはずです。たとえ問題を解決できなかった場合でも、説明書にはカスタマー・サービスセンター又は最寄りのサービスセンターへの問い合わせ先等、次の対処法についての指示があるはずです。
