Craftsmanメーカー917.27066の使用説明書/サービス説明書
ページ先へ移動 of 60
Owner's Manual CRAFTSMAN 15.5 HP ELECTRIC START 42" MOWER AUTOMATIC LAWN TRACTOR Model No. 917.270660 • Safety • Assembly • Operation • Maintenance • Repair Parts CAUTION: Read and follow all Safety Rules and Instructions before operating this equip- ment.
Warranty ............................................... 2 Safety Rules ......................................... 2 Product Specifications .......................... 5 Assembly .............................................. 8 Operation ...............
• Turn off blades when not mowing. • Stop engine before removing grass catcher or unclogging chute. • Mow only in daylight or good artificial light. • Do not operate the machine while under the influence of alcohol or drugs. • Watch for traffic when operating near or crossing roadways.
• Stop and inspect the equipment if you strike an object. Repair, if necessary, before restarting. • Never make adjustments or repairs with the engine running. • Grass catcher components are subject to wear, damage, and deterioration, which could expose moving parts or al- low objects to be thrown.
PRODUCT SPECIFICATIONS GASOUNE 1.25 GALLONS CAPACITY UNLEADED AND TYPE: REGULAR OILTYPE SAE30 API-SF/SG/SH): (above 32°1=) SAE 5W-30 (below 32°F) OIL CAPACITY: 3.0 PINTS SPARK PLUG: Champion RC12YC GAP: .O3O") VALVE INTAKE: .003"-.005" CLEARANCE: EXHAUST: .
PARTS BAG CONTENTS SHOWN FULL SIZE (1) Large (1) Large Flat Washer (1) Hex Bolt 5/16-18 x 1-1/4 (1) Hex Bolt 3/8-16 x 1 (1) Lockwasher 3/8 @ (1) Locknut 5/16-18 (1) Shoulder Bolt 5/16-18 © m m (1) Kn.
PARTS BAG CONTENTS SHOWN FULL SIZE (2) Screws #10 x 5/8 (2) Lock Washers #10 i #10 (2) Weld Nuts | (2) Washers 3/16 x 3/4 x 16 Gauge Parts packet separately in carton ---' Video Cassette Steering.
Your new tractor has been assembled at the factory with exception of those parts left unassembled for shipping purposes. To ensure safe and proper operation of your tractor all parts and hardware you assemble must be tightened securely. Use the correct tools as necessary to insure proper tightness.
HOW TO SET UPYOUR TRACTOR CHECK BAI-rERY • Lift seat pan to raised postion and open battery box door. • If this battery is put into service after month and year indicated on label (label located between terminals) charge battery for minimum of one hour at 6-10 amps.
CHECK BRAKE SYSTEM After you learn how to operate your tractor, check to see that the brake is properly adjusted. See 'qO ADJUST BRAKE" in the Service and Adjustments section of this manual. INSTALL MULCHER PLATE • Install two latch hooks to mulcher plate using screw, washer, lock washer, and weld nut as shown.
These symbols may appear on your tractor or in literature supplied with the product. Learn and understand their meaning, BATrERY CAUTION OR REVERSE FORWARD FAST SLOW WARNING ENGINE ON ENGINE OFF OIL P.
KNOW YOUR TRACTOR READ THIS OWNER'S MANUAL AND SAFETY RULES BEFORE OPERATING YOUR TRACTOR Compare the illustrations with your tractor to familiarize yourself with the locations of various controls and adjustments, Save this manual for future reference.
The operation of any tractor can result in foreign objects thrown into the eyes, which can result in severe eye damage. Always wear safety glass- es or eye shields while operating your tractor or performing any adjust- ments or repairs. We recommend a wide vision safety mask over spec- tacles, or standard safety glasses.
ing hot months. For healthier and better looking lawns, mow often and after moderate growth. • For best cutting performance, grass over 6 inches in height should be mowed twice. Make the first cut rela- tively high; the second to desired height. TO OPERATE MOWER Your tractor is equipped with an operator presence sensing switch.
• For cold weather operation you should change oil for easier starting (See "OIL VISCOSITY CHART" in the Mainte- nance section of this manual). • To change engine oil, see the Mainte- nance section in this manual. ADD GASOUNE • Fill fuel tank.
PURGE TRANSMISSION _ILCAUTION: Never engage or disen- gage freewheel lever while the engine is running. To ensure proper operation and perfor- mance, it is recommended that the trans- mission be purged before operating trac- tor for the first time.
MULCHING MOWING TIPS IMPORTANT: For best performance, keep mower housing free of built-up grass and trash. Clean after each use. • The special mulching blade will recut the grass clippings many times and re- duce them in size so that as they fall onto the lawn they will disperse into the grass and not be noticed.
CUSTOMER RESPONSIBILITIES FILL iN DATES ._'_'_/.. _ _/.. I}_ _ "/_ ._.. " "_..._"_ -i _. ,5"_ '' AS YOU COMPLETE /__,_'_O_,_ _ _._'_ _'_ _ R _d'_/_ REGULAR SERVICE _'_,f,_//'_.
"rRACTOR Always observe safety rules when performing any maintenance. BRAKE OPERATION If tractor requires more than six (6) feet stopping distance at high speed in highest gear, then brake must be ad- justed. (See 'q-O ADJUST BRAKE" in the Service and Adjustments section of this manual).
BAI-rERY Your tractor has a battery charging system which is sufficient for normal use. How- ever, periodic charging of the battery with an automotive charger will extend its life. • Keep battery and terminals clean. • Keep battery bolts tight. • Keep small vent holes open.
Oil Fill Cap/ €'_ Dipstick 0il _j. Drain Plug CLEAN AIR SCREEN Air screen must be kept free of dirt and chaff to prevent engine damage from overheating.
Clamp _Clamp Fuel Filter _ CLEANING • Clean engine, battery, seat, finish, etc. of all foreign matter. • Keep finished surfaces and wheels free of all gasoline, oil, etc, • Protect painted surfaces with automo- tive type wax.
TO LEVEL MOWER HOUSING Adjust the mowerwhile tractor is parked on level ground or driveway. Make sure tires are properly inflated (See "PROD- UCT SPECIFICATIONS'_. If tires are over or underinflated, you will not properly ad- just your mower.
• Pull belt away from mower. BELT INSTALLATION • Install new belt in reverse order of re- moval. • Make sure belt is in all pulley grooves and inside all belt guides.
TRANSMISSION REMOVAL/REPLACE- MENT Should your transmission require removal for service or replacement, it should be purged after reinstallation and before operating the tractor. See "PURGE TRANSMISSION" in the Operation section of this manual.
TO A'I-FACH JUMPER CABLES - • Connect each end of the RED cable to the POSITIVE (+) terminal of each bat- tery, taking care not to short against chassis. • Connect one end of the BLACK cable to the NEGATIVE (-) terminal of fully charged battery.
TO REMOVE HOODAND GRILLAS- SEMBLY • Raise hood. • Unsnap headlight wire connector. • Stand in front of tractor. Grasp hood at sides, tilt toward engine and lift off of tractor.
ACCELERATION TEST • Move throttle control lever from slow to fast position. If engine hesitates or dies, turn idle mixture valve out (counter- clockwise) 1/8 turn. Repeat test and continue to adjust, if necessary, until en- gine accelerates smoothly.
Immediately prepare your tractor for stor- age at the end of the season or if the trac- tor will not be used for 30 days or more. _CAUTION: Never store the tractor with gasoline in the tank inside a building where fumes may reach an open flame or spark.
TROUBLESHOOTING PROBLEM Will net start Hard to start Engine will not turn over Engine clicks but will not start Loss of power :HART CORRECTION CAUSE • Out of fuel, • Engine not "CHOKED" prop- . e[ly. • Engine flooded. • Bad spark plug.
PROBLEM Loss of power (cont'd) TROUBLESHOOTING CHART CAUSE • Faulty spark plug. • Dirty fuel filter. • Stale or dirty fuel. • Water in fuel. Excessive vibration Engine continues to run when operator leaves seat with at tachment clutch engaged Poor cut uneven Mower blades will not rotate Poor grass discharge Spark plug wire loose.
TROUBLESHOOTING CHART PROBLEM Poor grass discharge (cont'd) Headlight(s) not working (if so equipped) Battery will not charge Loss of drive Engine "backfires" when turning engine "OFF" CAUSE • Buildup of grass, leaves and trash under mower.
SCHEMATIC TRACTOR"" MODEL NUMBER 917.270660 BATTERY i ..... / I n D I I BLACK RED STARTER L ...... -J CLUTCH / BRAKE L ( (PEDAL UP) w_-_ SEAT SWITCH (NOT OCCUPIED) IGNITION - i I SWITCH _ J I J, GROUNDING GONNECTOR __ I PLUG IGNITION GAP UNIT (2 PLUGS ON TWIN CYL ENGIN_S_ OUR TRAC _K _'TOR IS _QUIPPED wITH A S_PE.
ELECTRICAL TRACTOR - - MODEL NUMBER 917.270660 i 43 24 41 21 22 I i I i I i 70 33 25 34.
ELECTRICAL TRACTOR -- MODEL NUMBER 917.270660 KEY PART NO. NO. 1 144925 2 74760412 4 ST[To51125 8 156417 16 153664 19 S'rD551125 20 73350400 21 166182 22 41523 24 4799J 25 146147 26 166180 27 735.
TRACTOR - - MODEL NUMBER 917.270660 CHASSIS AND ENCLOSURES 28 58 12 _3 74 54 36.
TRACTOR - - MODEL NUMBER 917.270660 CHASSIS AND ENCLOSURES KEY PART NO. NO. DESCRIPTION 1 165583 2 14(_56 3 17490612 4 19131216 5 155272 9 161917X013 10 S'T'[To33710 11 155927 12 145660 13 1.
TRACTOR - - MODEL NUMBER 917.270660 GROUND DRIVE 57 51 61 52 16 95 72 70 116 151 51 53 77 75 105 27 157 55 38.
TRACTOR - - MODEL NUMBER 917.270660 GROUND DRIVE KEY PART KEY PART NO. NO. DESCRIPTION NO. NO. 1 Transmission (See Breakdown) 71 141417 HydroGear Model 319-0500 72 19132012 2 142431 Spring, Return, Br.
TRACTOR -- MODEL NUMBER 917.270660 STEERING ASSEMBLY • . o::- , -. : / ..... l ....... _41 I ll 44 4O.
TRACTOR -- MODEL NUMBER 917.270660 STEERING ASSEMBLY KEY PART NO. NO. DESCRIPTION 1 139768 2 154427 3 156483 4 157473 5 62t56H 6 121748X 7 19272016 8 12000029 9 3366R 10 156438 11 _1137 13 154779 15 7.
ENGINE TRACTOR -- MODEL NUMBER 917.270660 2 33 33 3 81 38 78 4 2g OPTIONAL EQUIPMENT . Spark Arrester 23 / 42.
ENGINE TRACTOR -- MODEL NUMBER 917.270660 KEY PART NO. NO. DESCRIPTION 1 2 3 162157 17720410 4 137352 13 165291 14 1328(_24 15 13200300 16 STD551237 23 15988O 29 137180 31 10920P_X 32 158_90 33 123487.
TRACTOR -- MODEL NUMBER 917.270660 SEAT ASSEMBLY KEY NO. 1 2 3 4 6 6 7 8 9 10 11 PART NO. 140122 140551 STD5237t0 19131610 145006 STD541437 124181X 17490616 19131614 155925 166369 DESCRIPTION Seat 335.
DECALS TRACTOR -- MODEL NUMBER 917.270660 9 13 6 13 10 2O 21 14 12 16 21 KEY NO. PART NO, 1 156811 2 167179 3 1632oo 4 163202 6 133644 8 166887 9 163204 10 156439 12 146046 13 163250 14 1603_6 DESCRIPTION Decal, Oper. Instr. Decal, Replacement Decal, Hood, R.
TRACTOR -- MODEL NUMBER 917.270660 LIFT ASSEMBLY 7 11 13 6 3 2 8 / /' / / ./ I' / / 6 5 19 13 31 32 19 13 20 15 20 46.
TRACTOR -- MODEL NUMBER 917.270660 LIFT ASSEMBLY KEY PART NO. NO. DESCRIPTION 1 159460 Washer Asm Inner Spring W/Plunger 2 159471 Shaft Asm. Lift 3 105767X Pin Groove 4 1200(3002 E Ring #5133_o2 5 19211621 Washer 21/32 x 1 x21 Ga. 6 120183X Bearing Nylong 7 125631X Gdp Handle Fluted 8 122365X Button Plunger Read 11 139865 Unk Asm Lift LH.
MOWER DECK TRACTOR -- MODEL NUMBER 917.270660 4 36 58 31 106 "_ 102 103 105 lo3- /i_,/ # / | 101/_.p,_" 104 106 17 4 21 16 14_ ,18 18 21 22 _/3 24 28 29 27 48.
MOWER DECK TRACTOR -- MODEL NUMBER 917.270660 KEY PART NO. NO, 1 164961 2 STD533107 3 138017 4 138440 5 S'TD624008 6 130832 8 850857 9 _1137 10 14(_g6 11 134149 12 129895 13 137645 14 128774 15 1.
TRACTOR -- MODEL NUMBER 917.270660 HYDRO TRANSAXLE - - MODEL NUMBER 319-0500 1 58 23 19 99 37 139 43 18 , 28 99 / 900 53 52 4 35 113" 98 5O.
TRACTOR - - MODEL NUMBER 917.270660 HYDRO TRANSAXLE - - MODEL NUMBER 319-0500 KEY PART KEY PART NO. NO. DESCRIPTION NO. NO. DESCRIPTION 1 142986 Housing, Lower 40 150778 Locknut, He)( 6/16-24 UNJC 2 142987 Assembly, Upaer Housing 41 142958 Brake Rotor/Stator Kit 3 142932 Seal, Lip 43 142884 Washer 7/16 x 7/8 x .
TRACTOR -- MODEL NUMBER 917.270660 BRIGGS & STRATTON ENGINE-MODEL NUMBER 28U707, TYPE NUMBER 1174-E1 230 230 614 718 307 63_ 337 2 6® 6@ "A" REQUIRES SPECIAL TOOLS TO INSTALL.
TRACTOR -- MODEL NUMBER 917.270660 BRIGGS & STRA'I-I'ON ENGINE-MODEL NUMBER 28U707, TYPE NUMBER 1174-E 127 138 106 987 95 117 634 634A O _51 142 137 121 CARBURETOR OVERHAUL KIT 123_ ,Jr REQUIRES SPECIALTOOLS TO INSTALL SEE REPAIR INSTRUCTION MANUAL.
TRACTOR - - MODEL NUMBER 917.270660 BRIGGS & STRATTON ENGINE-MODEL NUMBER 28U707, TYPE NUMBER 1174-E1 523 423 _524 3 @ 20 634A 842 524 868 868A 1022 "_, _=_ 358 GASKET SET 51 977 137 CARBURET.
TRACTOR - - MODEL NUMBER 917.270660 BRIGGS & STRATTON ENGINE-MODEL NUMBER 28U707, TYPE NUMBER 1174-E 1019 LABEL KITJ 11036 LABEL KIT- EMISSIONS I [1058 OWNER'S MANUALI 783 728 615 544 201 474.
TRACTOR -- MODEL NUMBER 917.270660 BRIGGS & STRATTON ENGINE-MODEL NUMBER 28U707, TYPE NUMBER 1174-E1 KEY PART NO. NO. 1 496412 2 399265 3 391086 4 494238 5 495858 7 273280 8 495735 9 27803 10 94621 11 281246 12 271916 271997 271996 13 94728 15 94239 16 4.
TRACTOR - - MODEL NUMBER 917.270660 BRIGGS & STRATrON ENGINE-MODEL NUMBER 28U707, TYPE NUMBER 1174 KEY PART DESCRIPTION NO. NO. DESCRIPTION KEY PART NO, NO.
58.
SUGGESTED GUIDE FOR SIGHTING SLOPES FOR SAFE OPERATION ONLY RIDE UP AND DOWN HILL, NOT ACROSS HILL O1 (o _ Operate your Tractor up and dowp the face of slopes (not J _U_ greater than 15°), never across the face. Make turns gradu- I !_ _ ally to prevent tipping or loss of control.
For in-home major brand repair service: Call 24 hours a day, 7 days a week 1-800-4-MY-HOME sM (1-800-469-4663) Para pedir servicio de reparacibn a domicilio 1-800-676-5811 In Canada for all your servi.
デバイスCraftsman 917.27066の購入後に（又は購入する前であっても）重要なポイントは、説明書をよく読むことです。その単純な理由はいくつかあります：
Craftsman 917.27066をまだ購入していないなら、この製品の基本情報を理解する良い機会です。まずは上にある説明書の最初のページをご覧ください。そこにはCraftsman 917.27066の技術情報の概要が記載されているはずです。デバイスがあなたのニーズを満たすかどうかは、ここで確認しましょう。Craftsman 917.27066の取扱説明書の次のページをよく読むことにより、製品の全機能やその取り扱いに関する情報を知ることができます。Craftsman 917.27066で得られた情報は、きっとあなたの購入の決断を手助けしてくれることでしょう。
Craftsman 917.27066を既にお持ちだが、まだ読んでいない場合は、上記の理由によりそれを行うべきです。そうすることにより機能を適切に使用しているか、又はCraftsman 917.27066の不適切な取り扱いによりその寿命を短くする危険を犯していないかどうかを知ることができます。
ですが、ユーザガイドが果たす重要な役割の一つは、Craftsman 917.27066に関する問題の解決を支援することです。そこにはほとんどの場合、トラブルシューティング、すなわちCraftsman 917.27066デバイスで最もよく起こりうる故障・不良とそれらの対処法についてのアドバイスを見つけることができるはずです。たとえ問題を解決できなかった場合でも、説明書にはカスタマー・サービスセンター又は最寄りのサービスセンターへの問い合わせ先等、次の対処法についての指示があるはずです。
