Craftsmanメーカー917.273638の使用説明書/サービス説明書
ページ先へ移動 of 56
Owner's Manual CRAFTSMIIN ° 18.5 HE 42" Mower Electric Start 6 Speed Transaxle Model No. 917.273638 i_] his product has a mow emission engine which operates differently from previously built engines. Before you start the engine, read and understand this Owner's Manual.
Warranty ................................................. 2 Safety Rules ........................................... 3 Product Specifications ............................ 6 Assembly/Pre-Operation ........................ 7 Operation .................
mMPORTANT: This cutting machine is capable of amputating hands and feet and throw- ing objects. Failure to observe the following safety instructions could result in serious injury or death.
DO: Mow up and down slopes, not across. Remove obstacles such as rocks, tree limbs, etc. Watch for holes, ruts, or bumps. Un- even terrain could overturn the machine. Taft grass can hide obstacles. Use slow speed. Choose a low gear so that you will not have to stop or shift while on the slope.
Be sure the area is clear of other people before mowing. Stop machine if anyone enters the area. Never carry passengers or children even with the blades off. Do not mow in reverse unless abso- lutely necessary. Always look down and behind before and while backing.
PRODUCT SPECIFICATmONS Gasoline 4.0 Capacity and Unleaded Type: Regular Oil Type SAE 30 (above 32°F) IAPFSG-SL): SAE 5W-30(below 32°F Oil Capacity: W/Filter: 3.5 Pints W/O Filter: 3.0 Pints Spark Plug: Champion RC12YC (Gap: .030") Ground Speed (MPH): Forward: 1 st 1.
Mower Leveling Wrench Keys (2) Keys Bubble Level (1) Oil Drain Tube For Future Use Slope Sheet Video Cassette Your, new tractor has been assembled at the factory. Review the video cassette before you begin. When right or left hand is mentioned in this manual, it means when you are in the oper- ating position (seated behind the steering wheel).
Knob NOTE: You may now roll or drive your tractor off the skid. Follow the appropriate instruction below to remove the tractor from the skid. TO ROLLTRACTOR OFF SKmD (See Operation section for mocation and function of controms) 1. Press lift lever plunger and raise attachment lift lever to its highest po- sition.
CHECK TIRE PRESSURE The tires on your tractor were overin- fiated at the factory for shipping purposes. Correct tire pressure is importantfor best cutting performance. Reduce tire pressure to PSI shown in "PRODUCT SPECIFICATIONS" section of this manual.
These symbols may appear on your tractor or in literature supplied with the product. Learn and understand their meaning. R N H L I'-,I REVERSE NEUTRAL HIGH LOW CHOKE FAST G G ENGINE OFF LIGHTS ON.
KNOW YOUR TRACTOR READ THINS OWNER'S MANUAL AND SAFETY RULES BEFORE OPERATmNG YOUR TRACTOR Compare the illustrations with your tractor to familiarize yourself with the locations of various controls and adjustments. Save this manual for future reference.
The operation of any tractor can result in foreign objects thrown into the eyes, which can result in severe eye damage. Always wear safety glasses or eye shields while operating your tractor or performing any adjustments or repairs. We recommend a wide vision safety mask over spectacles or standard safety glasses.
For best cutting performance, grass over 6 inches in height should be mowed twice. Make the first cut relatively high; the second to desired height. TO ADJUST GAUGE WHEELS Gauge wheels are properly adjusted when they are slightly off the ground when mower is at the desired cutting height in operating position.
TOWING CARTS AND OTHER ATTACH- rvIENTS Tow only the attachments that are recom- mended by and comply with specifications of the manufacturer of your tractor. Use common sense when towing. Too heaw of a load, while on a slope, is dangerous. Tires can lose traction with the ground and cause you to lose control of your tractor.
COLD WEATHER STARTING ( 50 ° F and below) 6. When engine starts, leave throttle control in choke position until engine warms up and begins to run roughly.
F,LL ,, DATES AS COMPLETE ...... REGULAR SERV,OE f y4 yA TS ERV'C E DATES Check Brake Operation _1_ t_ Check Tire Pressure Check Operator Presence and T Interlock Systems If R Check for Loose Fas.
TRACTOR Always observe safety rubs when per- forming any maintenance. BRAKE OPERATmON If tractor requires more than six (6) feet stopping distance at high speed in highest gear, then brake must be adjusted. (See "TO ADJUST BRAKE" in the Service and Adjustments section of this manual).
NOTE: The original equipment battery on your tractor is maintenance free. Do not attempt to open or removecaps or covers. Adding or checking level of electrolyte is not necessary. TO CLEAN BATTERY AND TERMINALS Corrosionand dirt on the battery and terminals can cause the battery to "leak" power.
Service air cleaner more often under dusty conditions. 1. Pull up on air filter cover handle and rotate towardsengine. 2. Remove cover. 3. Carefully remove air filter cartridge and pre-cleaner from base. 4. Clean base carefully to preventdebris from falling into carburetor.
WARNmNG: TO AVOmD SERmOUS mNJURY, BEFORE PERFORMmNG ANY SERVmCE OR ADJUSTMENTS: 1. Depress clutch/brake pedal fully and set parking brake. 2. Place gearshift lever in neutral (N) position. 3. Place attachment clutch in "DISENGAGED" position.
TO LEVEL MOWER HOUSmNG Adjust the mower while tractor is parked on level ground or driveway. Make sure tires are properly inflated (See "PROD- UCT SPECIFICATIONS" section of this manual). If tires are over or undednflated, you will not properly adjust your mower.
To raise front of mower, loosen nut "F" from trunnion on both front links. Tighten nut "E" on both front links an equal num- ber of turns.
TO REPLACE MOTmON DRmVE BELT Park the tractor on level surface. Engage parking brake. For assistance, there is a belt installation guide decal on bottom side of left footrest. BELT REMOVAL - 1. Remove mower (See "TO REMOVE MOWER" in this section of manual).
TO START ENGINEWiTH A WEAK BAT- TERY ,_kWARNmNG: Lead-acid batteries gen- erate explosive gases. Keep sparks, flame and smoking materials away from bat- teries. Always wear eye protectionwhen around batteries. If your battery is too weak to start the engine, it should be recharged.
Maintenance, repair, or replacement of the emission control devices and systems, which are being done at the customers expense, may be performed by any non-road engine repair establishment or individual. Warranty repairs must be performed by an authorized engine manufacturer's service outlet.
Immediately prepare your tractor for stor- age at the end of the season or if the trac- tor will not be used for 30 days or more. _I, CAUTmON: Never store the tractor with gasoline in the tank inside a building where fumes may reach an open flame or spark.
TROUBLESHOOTmNG CHART: See appropriate section in marluamunmess directed to Sears service center Hard to start Engine wiii not turn over Engine clicks but wiii not start CAUSE 1. Out of fuel. 2. Engine not "CHOKED" properly. 3. Engine flooded.
TROUBLESHOOTmNG CHART: See appropriate section in manuam unmess directed to Sears service center CAUSE CORRECTmON 1. 1. Cutting too much grass/too fast. 2. Throttle in "CHOKE" position. 3. Build=up of grass, leaves and trash under mower. 4. Dirty air filter.
TROUBLESHOOTmNG CHART: See appropriate section in manuam unmess directed to Sears service center Mower blades wiii not rotate PROBLEM CAUSE CORRECTmON 1. Remove obstruction. Poor grass discharge Headlight(s) not working (if so equipped) Battery wiii not charge Engine "backfires" when turning engine "OFF" 1.
30.
SCHEMATIC TRACTOR - - MODEL NUMBER 917.273638 AMMETER (OPTIONAL) IGNITION SWITCH POSITION CIRCUIT "MAKE" OFF M+G+A1 NONE DN + LIGHTS B+A1 L+A2 ON B + A1 NONE START B + S + A1 NONE FUSE SOLEN.
ELECTRICAL TRACTOR - - MODEL NUMBER 917.273638 12 / I 41 16 ] I- ..... I 12 32.
ELECTRmCAL TRACTOR o o MODEL NUMBER 917.273638 KEY PART NO. NO. DESCRiPTiON 1 163465 Battery 2 74760412 Bolt, Hex 1/4-20 x 3/4 8 7603J Trap',Battery 10 145211 Bolt, Battery, Front 1/4-20 x 7-1/2 .
TRACTOR ° ° MODEL NUMBER 917.273638 CHASSmS AND ENCLOSURES 217 9O 278 209 /_. 155 _278 11 209 54 58 _,158 54 ._ 209 .--" 20 59 209 J 206 chassis-stealth,stlt 21 209 6O 209 74 209 38 60 37 >2.
TRACTOR o o MODEL NUMBER 917.273638 CHASSmS AND ENCLOSURES KEY PART NO. NO. DESCRiPTiON 1 174619 Chassis 2 176554 Drawbar 9 161566X428 Dash 10 72140608 Bolt RDHD SQNK 3/8-16 x 1 11 167203 Panel, Dash,.
TRACTOR - - MODEL NUMBER 917.273638 GROUND DRIVE 26 27 75 drive-fender.stlt 43 36.
TRACTOR o o MODEL NUMBER 917.273638 GROUND DRIVE KEY PART KEY PART NO. NO. DESCRiPTiON NO. NO. 1 Transaxle (See Breakdown) 55 105709X Dana 4360-180 56 17060620 2 146682 Spring, Return, Brake 57 160855.
STEERmNG TRACTOR o o MODEL NUMBER 917.273638 / : L _ 38 _72 / / 88 J /, J 68 67 67 / 67 13 65 94 34 4O 43 / / / / /_J / 8 steering steaffh prem 7 38.
STEERmNG TRACTOR o o MODEL NUMBER 917.273638 KEY PART NO. NO. DESCRiPTiON 1 159944X428 Wheel Steering 2 184706 Axle Asm 3 169840 Spindle Asm LH 4 169839 Spindle Asm RH 5 6266H Bearing Race Thrust Hard.
ENGmNE TRACTOR ° ° MODEL NUMBER 917.273638 2 78 32 112 29 81 38 14 23 / 13 4 OPTIONAL EQUIPMENT Spark Arrester engine-bs=lcyF 51 4O.
ENGINE TRACTOR o o MODEL NUMBER 917.273638 KEY PART NO. NO. DESCRIPTION 1 176636X505 Control Throttle 2 191611 Screw 10 x 3/4 Single Lead Hex 3 .......
TRACTOR ° ° MODEL NUMBER 917.273638 SEAT ASSEMBLY 18 14 I 25 .... 15 13 17 12 11 5 _t f Et t _ J t E _x 22 21 KEY PART NO, NO, DESCRiPTiON 1 188714 Seat 2 140551 Bracket Pivot Seat 3 STD523710 Bolt Fin Hex 3/8-16 unc x 1 4 19131610 Washer 13/32 x 1 x 10 Ga= 5 145006 Clip Push-Hn 6 STD541437 Nut Hex w/Hns.
DECALS 18 TRACTOR ° ° MODEL NUMBER 917.273638 11 16 3 13 21 4 11 21 10 24 2O 7 6 15 26 12 1 KEY PART NO. NO. 1 187407 2 138047 3 186242 4 186243 5 160396 6 146046 7 179128 9 189080 10 156439 11 189088 12 172331 13 133644 15 187408 DESCRIPTION Reflector, LH Decal, Battery, Diehard, Sears Decal, Hood RH Decal, Hood LH Decal, Deck Sch.
TRACTOR - - MODEL NUMBER 917.273638 LmFT ASSEMBLY 13 4 6 11 3 1 19 13 32 13 ----_ 31_ 32 19 13 1718 20 16, 15 Fift-rh.1 pc.stlt 9 44.
TRACTOR o o MODEL NUMBER 917.273638 LmFT ASSEMBLY KEY PART NO. NO. DESCRIPTION 1 179504 PIunger Assembiy 2 159476 Shaft Assembly, Lift 3 188822 Pin, Groove 4 12000002 E-Ring 5 19211621 Washer 21/32 x 1 x21Ga. 6 120183X Bearing, NyIon 7 175830 Grip, Handle, Fluted 11 139865 Link, Lift, LH.
TRACTOR o o MODEL NUMBER 917.273638 MOWER DECK _ ""_ 40 159 _i 132 91 t _184 59 117 11 34 92__ 92 4 149 5 6 19F 21 140 - , 138 2 16 14 18 13 102 F 21 _5 _134 29 116 21 2 / 23 24 _,_ 6 28 " 27 42 D,elec.
TRACTOR o o MODEL NUMBER 917.273638 MOWER DECK KEY PART KEY PART NO. NO. DESCRiPTiON NO. NO. 1 182032 Mower Housing 94 132264 2 STD533107 Bolt 95 180533 3 138017 Bracket Assembly, Sway Bar, Fr.
TRACTOR o o MODEL NUMBER 917.273638 DANA TRANSAXLE==MODEL NUMBER D4360=180 26 27 2O 21 22 11. 36 !I* 9 52 53 54 24 31 32 25 57 42 3* 44 59 56 i5 45 46 47 48 49 50 59 62 64 69 6O 6768 23 6 43* 52 48.
TRACTOR o o MODEL NUMBER 917.273638 DANA TRANSAXLE-MODEL NUMBER D4360ol 80 KEY PART KEY PART NO. NO. DESCRmPTmON NO. NO. 1 190972 Housing, Upper 41 105928× 2 2274J Screw, Tapping, 1/4-20 X .734 42 190986 3 190973 BaH, Detent 43 134394" 4 190974 Spring, Detent 44 120473X 5 190975 Screw, Tapping, No.
TRACTOR ° ° MODEL NUMBER 917.273638 BRmGGS & STRATTON ENGmNE=MODEL NUMBER 31P777,TYPE NUMBER 0348=E1 718 358 ENGINE GASKET SET 8680 8_1_ 146 '_ I 741_ 12 524 617 0 842<:3 943 O 1270 _759.
TRACTOR ° ° MODEL NUMBER 917.273638 BRIGGS & STRATTON ENGINE=MODEL NUMBER 31P777,TYPE NUMBER 0348=E1 238 35 1022 1034 6170 914 1095 VALVE GASKET SET 868 _'_ 1022 _] 131 --10_ • _ _-1o6 lo91 105 276@ 1127L4 _ 127 (_ 601 1119_ 947 918 977 CARBURETOR1370GASKET276 _.
TRACTOR o o MODEL NUMBER 917.273638 BRmGGS & STRATTON ENGmNE=MODEL NUMBER 31P777,TYPE NUMBER 0348=E1 KEY PART KEY PART NO. NO. DESCRiPTiON NO. NO. DESCRmPTmON 1 697174 Cylinder Assembly 108 690464.
TRACTOR o o MODEL NUMBER 917.273638 BRmGGS & STRATTON ENGmNE=MODEL NUMBER 31P777, TYPE NUMBER 0348=E1 KEY PART KEY PART NO. NO. DESCRiPTiON NO. NO.
54.
SUGGESTED GUIDE FOR SIGHTING SLOPES FOR SAFE OPERATION L_ ONLY RIDE UP AND DOWN HILL, NOT ACROSS HILL 15 DEGREES MAX. _b ARNING: To avoid serious injury, operate your tractor up and down the face of slopes, never across the face. Do not mow slopes greater than 15 degrees.
iiiiiiiiiiiiiiiiiiiii_ iiiiiiiiiiiiiiiiiiii _ iiiiiiiiiiiiiiiiiii iiiiiiiiiiiiiiiiiii _ iiiiiiiiiiiiiiiiiii _ iiiiiiiiiiiiiiiiiii _ iiiiiiiiiiiiiiiiiii _ iiiiiiiiiiiiiiiiiii _ iiiiiiiiiiiiiiiiiii _ ii.
デバイスCraftsman 917.273638の購入後に（又は購入する前であっても）重要なポイントは、説明書をよく読むことです。その単純な理由はいくつかあります：
Craftsman 917.273638をまだ購入していないなら、この製品の基本情報を理解する良い機会です。まずは上にある説明書の最初のページをご覧ください。そこにはCraftsman 917.273638の技術情報の概要が記載されているはずです。デバイスがあなたのニーズを満たすかどうかは、ここで確認しましょう。Craftsman 917.273638の取扱説明書の次のページをよく読むことにより、製品の全機能やその取り扱いに関する情報を知ることができます。Craftsman 917.273638で得られた情報は、きっとあなたの購入の決断を手助けしてくれることでしょう。
Craftsman 917.273638を既にお持ちだが、まだ読んでいない場合は、上記の理由によりそれを行うべきです。そうすることにより機能を適切に使用しているか、又はCraftsman 917.273638の不適切な取り扱いによりその寿命を短くする危険を犯していないかどうかを知ることができます。
ですが、ユーザガイドが果たす重要な役割の一つは、Craftsman 917.273638に関する問題の解決を支援することです。そこにはほとんどの場合、トラブルシューティング、すなわちCraftsman 917.273638デバイスで最もよく起こりうる故障・不良とそれらの対処法についてのアドバイスを見つけることができるはずです。たとえ問題を解決できなかった場合でも、説明書にはカスタマー・サービスセンター又は最寄りのサービスセンターへの問い合わせ先等、次の対処法についての指示があるはずです。
