Craftsmanメーカー917.274953の使用説明書/サービス説明書
ページ先へ移動 of 60
Owner's Manual ICRRFTSMRN'I GARDEN TRACTOR 21.0 HP, 46" Mower Electric Start 6 Speed Model No. 917.274953 I _ This product has a low emission engine which operates differently from previously built engines. Before you start the en- gine, read and understand this Owner's Manual.
Warranty ............................................... 2 Safety Rules ......................................... 3 Product Specifications .......................... 6 Assembly/Pre-Operation ...................... 7 Operation .........................
IMPORTANT:. This cutting machine is capable of amputating hands and feet and throwing objects. Failure to observe the following safety instructions could result in serious injury or death. &Look for this symbol to point out • Do not mow in reverse unless absolutely important safety precautions.
DO: • Mow up and down slopes, not across. • Remove obstacles such as rocks, tree limbs, etc. • Watch for holes, ruts, or bumps. Uneven terrain could overtum the machine. Tall grass can hide obstacles. • Use slow speed. Choose a low gear so that you will not have to stop or shift while on the slope.
• Be sure the area is clear of other people before mowing. Stop machine if anyone enters the area. • Never carry passengers or children even with the blades off. • Do not mow in reverse unless abso- lutely necessary. Always look down and behind before and while backing.
PRODUCT SPECIFICATIONS Gasoline Capacity and Type: Oil Type API-SF-SJ): Oil Capacity: 5 Gallons Unleaded Regular SAE 10W30 (above 32°F) SAE 5W-30 (below 32°F) W/Filter:. 4.5 Pints W/O Filter: 4.0 Pints Spark Plug: Champion RC12YC '_Gap: .030') Ground Speed Lo: Hi: (MPH): 0.
Video Cassette For Future Use Keys (2) Keys Slope Sheet Your new tractor has been assembled at the factory. Review the video cassette before you begin. When right or left hand is mentioned in this manual, it means, from your point of view, when you are in the operating position (seated behind the steering wheel).
ADJUST SEAT I. Raise seat and loosen adjustment knobs. 2. Lower seat into operating position and sit in seat. 3. Slide seat until a comfortable position is reached which allows you to press clutch/brake pedal all the way down. 4. Get off seat without moving its adjusted position.
CHECK TIRE PRESSURE The tires on your tractor were overinflated at the factory for shipping purposes. Correct tire pressure is important for best cutting performance. • Reduce tire pressure to PSI shown in "PRODUCT SPECIFICATIONS" section of this manual.
These symbols may appear on your tractor or In literature supplied with the product. Leam and understand their meaning. BATTERY CAUTION OR REVERSE FORWARD FAST SLOW WARNING ENGINE ON ENGINE OFF OIL PR.
KNOWYOUR TRACTOR READ THIS OWNER'S MANUAL AND SAFETY RULES BEFORE OPERATING YOUR TRACTOR Compare the illustrations with your tractor to familiadze yourself with the locations of vadous controls and adjustments. Save this manual for future reference.
The operationof any tractor can result in foreign objectsthrown into the J eyes, which can result in severe eye damage. Alwayswear safety I glasses or eye shields while operating your tractor or performing any adjustments or repairs. We recommend standard safety glasses or a wide vision safety mask wom over spectacles.
The cutting height range is approximately 1-1/2" to 4-1/2". The heights are mea- sured from the ground to the blade tip with the engine not running. These heights are approximate and may vary depending upon soil conditions, height of grass and types of grass being mowed.
TO TRANSPORT • Raise attachment lift to highest position with attachment lift control. • When pushing or towing your tractor, be sure gearshift lever is in neutral (N) posi- tion.
• The attachments and ground drive can now be used. If the engine does not accept the load, restart the engine and allow it to warm up for one minute using the choke as described above. COLD WEATHER STARTING (50 ° F and below) 7. When engine starts, slowly push choke control in until the engine begins to run smoothly.
REGULAR SERVICE i_'(/"¢W_/CWr,'/CWr//CP'(fCWr_,t'_,;_r S E RVIC E DATES Check Broke OpemUon Cheo_ Tire p_ _1_ R c_ _ u_ F=_ra 1_5 If T L_ 0.
TRACTOR Always observe safety rules when performing any maintenance. BRAKE OPERATION If tractor requires more than six (6) feet stopping distance at high speed in highest gear, then brake must be ad- justed. (See =TO ADJUST BRAKE" in the Service and Adjustments section of this manual).
• Keep battery and terminals clean. • Keep battery bolts tight. • Keep small vent holes open. • Recharge at 6-10 amperes for I hour. NOTE: The odginal equipment battery on your tractor is maintenance free. Do not attempt to open or remove caps or covers.
ENGINE OIL FILTER Replace the engine oil filter every season or every other oil change if the tractor is used more than 100 hours in one year. AIR FILTER Your engine will not run properly using a dirty air filter. Clean the foam pre-cleaner after every 25 hours of operation or every season.
WARNING: TO AVIOD SERIOUS INJURY, BEFORE PERFORMING ANY i_ SERVICE OR ADJUSTMENTS: 1. Depress clutch/brake pedal fully and set parking brake. 2. Place gearshift lever in neutral (N) position. 3. Place attachment clutch in "DISENGAGED" position.
NOTE: To assist in locating hole in flanged pin, the hole in pin is inline with notch on head of pin. If necessary, move mower side-to-side to give space between plate and mower brackets. IMPORTANT: Check belt for proper routing in all mower pulley grooves.
TO REPLACE MOWER DRIVE BELT MOWER DRIVE BELT REMOVAL 1. Park tractoron a level surface. Engage parking brake. 2. Remove screws from LH. mandrel cover and removecover. 3. Roll belt over the top of L.H. mandrel pulley. 4. Remove belt from electric clutch pulley.
TO REPLACE MOWER BLADE DRIVE BELT Park the tractor on level surface. Engage parking brake. 1. Remove mower drive belt (See "TO REPLACE MOWER DRIVE BELT" in this section of this manual). 2. Remove mower (See =TO REMOVE MOWER" in this section of this manual).
4. Road test tractor for proper stopping distance as stated above. Readjust if necessary. If stopping distance is still greater than six (6) feet In highest gear, further maintenance is necessary. Contact a Sears or other qualified service center. IMPORTANT:.
Jam Nuts TO REMOVE WHEEL FOR REPAIRS FRONT WHEEL - 1. Block up axle securely. 2. Remove axle cover, retaining ring and washers to allow wheel removal. 3. Repair tire and reassemble. 4. Replace washers and snap retaining ring securely in axle groove. 5.
Terminal ..::; ex Access :: _ _ _ Bolt Door :----'_'fl_ _ _' ][----Positive i L_ _L (Red) Terminal _ I _. _ Cable Guard "_ _ "(_egb_ive (Black) TO REPLACE HEADLIGHT BULB 1. Raise hood. 2. Pull bulb holder out of the hole in the backside of the grill.
TO ADJUST CHOKE CONTROL The choke control has been preset at the factory and adjustment should not be necessary, check adjustment as de- scribed below before loosening cable. If adjustment is necessary, proceed as follows: 1. With engine not running, move choke control (located on dash panel) to full choke position.
Immediately prepareyour tractor for storage at the end of the season or if the tractor will not be used for 30 days or more. _CAUTION: Never store the tractor with gasoline In the tank inside a building where fumes may reach an open flame or spark. Allow the engine to cool before storing in any enclosure.
TROUBLESHOOTING CHART: See appropriate section In manual unless directed to Sears service center PROBLEM Will not start Hard to start Engine will not turn over Engine clicks but will not start CAUSE 1. Out of fuel. 2. Engine not =CHOKED" properly.
TROUBLESHOOTING CHART: See appropriate section in manual unless directed to Sears service center CAUSE . 2. 3. 4. 5. 6. 7. Dirty fuel filter. 8. Stale or dirty fuel. PROBLEM Loss of power Excessive vibration Englne contlnues to run when operator leaves seat with with attachment clutch engaged Poor cut - uneven 9.
TROUBLESHOOTING CHART: See appropriate section in manual unless directed to Sears service center PROBLEM Mower blades will not rotate Poor grass discharge Headlight(s) not working (if so equipped) Battery will not charge Engine "backfires" _henturnlng _ngine"OFF" CAUSE 1.
.
SCHEMATIC TRACTOR-- MODEL NUMBER 917.274953 l AMMETER i ;wrrcH REO SOLEN_D ST_TER IGNmON s_CH O_ M+G+A1 _ ÷ B+A|I L+A2 ON B+A1 NONE +E+AI WIRING I_U_TED C_S NO_: IF WIRING INSULTED CLIPS WERE RE_VED FOR SERVICING OF UN_, _ S_W BE REP_CED TO PROPERLY SECURE YOUR WIRING.
ELECTRICAL TRACTOR - - MODEL NUMBER 917.274953 12 29 l 33 T .... I I I I 34.
TRACTOR -- MODEL NUMBER 917.274953 ELECTRICAL KEY PART NO. NO. DESCRIPTION 1 144927 Battery 2 74760412 Bolt Hex Head 1/4-20 x 3/4 8 7603J Tray, Battery 10 145211 Bolt 1/4-20 x 7.
TRACTOR -- MODEL NUMBER 917.274953 CHASSIS AND ENCLOSURES 138 158 37 17 36.
TRACTOR - - MODEL NUMBER 917.274953 CHASSIS AND ENCLOSURES KEY PART KEY NO. NO. DESCRIPTION NO. 1 180372 Rail, Frame RH 67 2 175282 Drawbar, Gt 68 4 73680700 Nut, CrownlockHex 7/16-14UNC 70 5 163976X4.
TRACTOR - - MODEL NUMBER 917.274953 GROUND DRIVE 28 39 36 27 69 3 29 66 47 62 4 38.
TRACTOR - - MODEL NUMBER 917.274953 GROUND DRIVE KEY PART KEY PART NO. NO. DESCRIPTION NO. NO. DESCRIPTION 3 7563R Washer, Thrust, Axle 38 150035 4 17490508 Screw Thdrol 5/16-18 x 3/4 39 74321016 5 ST.
TRACTOR - - MODEL NUMBER 917.274953 STEERING ASSEMBLY 2O 23 34 31 27 42 / / / I / I 7 8 4O.
TRACTOR -- MODEL NUMBER 917.274953 STEERING ASSEMBLY KEY PART NO. NO. 1 139768 2 178557 3 6855M 4 161849 5 161848 6 6_66H 7 121748X 8 12000029 9 121232X 10 74781044 11 136518 12 73901000 13 121749X 14.
ENGINE TRACTOR -- MODEL NUMBER 917.274953 25 21 _ 20 16 39 KEY PART NO. NO. DESCRIPTION 1 ...... Engine (See Breakdown) Kohler Model No. CV624-65577 2 149723 Muffler 8 121361X Pulley V-Idler 9 177748 Keeper Asm.
TRACTOR -- MODEL NUMBER 917.274953 SEAT ASSEMBLY 5 KEY PART NO. NO. 1 180597 2 180166 3 14O675 5 145OO6 6 STD541437 7 124181X 8 171877 10 180186 12 121246X 13 121248X 14 72050412 15 134300 DESCRIPTION.
DECALS TRACTOR -- MODEL NUMBER 917.274953 9 1 16 1"_ 19 15 8 4 10 12 1 KEY PART NO. NO. 1 177423 2 164085 3 171702 4 171703 5 149516 6 133644 8 177415 9 1632O4 10 156439 11 181249 12 146047 DESCR.
LIFT ASSEMBLY 4O 39 TRACTOR-- MODEL NUMBER 917.274953 42 43 36 73 34 31 23 KEY PART KEY PART NO. NO. DESCRIPTION NO. NO. I 121006X Rod Asm., Lever 32 137150 2 180045 Shaft Asrn., Lift Vgt 34 137167 3 159189 Lever Asm., Lift Rh 35 138057 4 1200(X_2 E-RingTruam#5133-87 38 155097 5 19292016 Washer 29/32 x 1-I/4 x 16 Ga.
TRACTOR -- MODEL NUMBER 917.274953 MOWER DECK 45 46 49 I 49 41 46 116 117 >3O 32 19 117 21 26 18 46.
TRACTOR - - MODEL NUMBER 917.274953 MOWER DECK KEY PART KEY PART NO. NO. DESCRIPTION NO. NO. I 156948 DeckWeldment 36 STD551037 3 138457 Bracket Asm., Sway Bar 37 131494 5 STD624008 Retainer Spdng 38 156086 6 178024 Bar SWay Deck 39 144917 8 850857 Boll, Patched 3/8-24 x 1-1/4 40 137273 Gr.
TRACTOR -- MODEL NUMBER 917.274953 TRANSAXLE 7 23 _. 28 29 $ 7 48.
TRANSAXLE TRACTOR - - MODEL NUMBER 917.274953 KEY PART NO. NO. 1 4197R 2 12O00O34 3 4199R 4 42161:1 5 4215R 6 4217R 7 174728 8 74020652 9 7392M 10 137261 11 49asP, 12 6266H 13 4212R 14 137125 15 62781.
TRACTOR - - MODEL NUMBER 917.274953 KOHLER ENGINE-MODEL NUMBER CV624, TYPE NUMBER 65577 CYLINDER HEAD, VALVE AND BREATHER I _--13 I 4 CRANKCAS_ O_Ig O 5O.
TRACTOR -- MODEL NUMBER 917.274953 KOHLER ENGINE-MODEL NUMBER CV624, TYPE NUMBER 65577 HEADNALVF./BREATHER CRANKCASE KEY PART KEY PART NO. NO. DESCRIPTION NO.
TRACTOR -- MODEL NUMBER 917.274953 KOHLER ENGINE-MODEL NUMBERCV624,TYPE NUMBER 65577 IGNITION/ELECTRICAL I s_- V AIR INTAKE J BLOWER HOUSING AND BAFFLES I 14--'1.
TRACTOR-- MODEL NUMBER 917.274953 KOHLER ENGINE-MODEL NUMBER CV624, TYPE NUMBER 65577 IGNmON/CHARGING BLOWER HOUSING & BAFFLES KEY PART KEY PART NO. NO. DESCRIPTION NO. NO. DESCRIPTION 1 54-755-15-S Kit, grass screen 1 24-027-20-S Housing, blower (Includes 2-4,and 24 113 16- (Incl.
TRACTOR -- MODEL NUMBER 917.274953 KOHLER ENGINE-MODEL NUMBER CV624, TYPE NUMBER 65577 STARTING SYSTEM J / 3 b | OIL PAN/LUBRICATION J 54.
TRACTOR -- MODEL NUMBER 917.274953 KOHLER ENGINE-MODEL NUMBER CV624, TYPE NUMBER 65577 STARTING SYSTEM OIL PAN/LUBRICATION KEY PART KEY PART NO. NO. DESCRIPTION NO. NO. DESCRIPTION 1 M-839080-S Screw, hex. flange M8x1.25x80 (2) 2 25-098-08-S Starter, solenoid shift (Includes 4-7) 3 M-841080-S Nut, hex.
TRACTOR -- MODEL NUMBER 917.274953 KOHLER ENGINE-MODEL NUMBER CV624,TYPE NUMBER 65577 CRANKSHAFT J EXHAUST I FUEL SYSTEM I / 1 ® _p 7 8 lf0 9 "_ /_ _/.
TRACTOR - - MODEL NUMBER 917.274953 KOHLER ENGINE-MODEL NUMBER CV624,TYPE NUMBER 65577 CRANKSHAFT KEY PART NO. NO. DESCRIPTION 1 24-014-72-S Crankshaft (includes 2) 2 52-139-09-S Plug, cup EXHAUST KEY PART NO. NO. DESCRIPTION 1 24-041-02-S Gasket, exhaust (2) 2 25-072-04-S Stud, M8x1.
_ , i •.
SUGGESTED GUIDE FOR SIGHTING SLOPES FOR SAFE OPERATION 1. Fold this page along dotted line Indicated above. 2. Hold page before you so that Its left edge Is vertically parallel to a tree trunk or other upright structure. 3. Sight across the fold In the direction of hill slope you want to measure.
For rep_r of majorbrand appliances in your own home... no matter who made it,no matter who sold _ 1-800-4-MY-HOME _ Anya_, clay or night (1-_o469.4a_ (U.SA and Canada) W_WI.I_EblLcom Wtl_lt#.llaEIIllJ¢_ For repair of carry-in products likevacuums,lawn equipment, and electronics, call for the nearestSeats Parts and Repair Center.
デバイスCraftsman 917.274953の購入後に（又は購入する前であっても）重要なポイントは、説明書をよく読むことです。その単純な理由はいくつかあります：
Craftsman 917.274953をまだ購入していないなら、この製品の基本情報を理解する良い機会です。まずは上にある説明書の最初のページをご覧ください。そこにはCraftsman 917.274953の技術情報の概要が記載されているはずです。デバイスがあなたのニーズを満たすかどうかは、ここで確認しましょう。Craftsman 917.274953の取扱説明書の次のページをよく読むことにより、製品の全機能やその取り扱いに関する情報を知ることができます。Craftsman 917.274953で得られた情報は、きっとあなたの購入の決断を手助けしてくれることでしょう。
Craftsman 917.274953を既にお持ちだが、まだ読んでいない場合は、上記の理由によりそれを行うべきです。そうすることにより機能を適切に使用しているか、又はCraftsman 917.274953の不適切な取り扱いによりその寿命を短くする危険を犯していないかどうかを知ることができます。
ですが、ユーザガイドが果たす重要な役割の一つは、Craftsman 917.274953に関する問題の解決を支援することです。そこにはほとんどの場合、トラブルシューティング、すなわちCraftsman 917.274953デバイスで最もよく起こりうる故障・不良とそれらの対処法についてのアドバイスを見つけることができるはずです。たとえ問題を解決できなかった場合でも、説明書にはカスタマー・サービスセンター又は最寄りのサービスセンターへの問い合わせ先等、次の対処法についての指示があるはずです。
