Craftsmanメーカー917.27537の使用説明書/サービス説明書
ページ先へ移動 of 56
Owner's Manual CRRFTSMRN ° LAWN TRACTOR 1 7.5 HP, 42" Mower Electric Start 6 Speed Transaxle Model No. 917.275370 i_ This product has a low emission engine which operates differently from previously built engines. Before you start the engine, read and understand this Owner's Manual.
Warranty ................................................. 2 Safety Rules ........................................... 3 Product Specifications ............................ 6 Assembly/Pre-Operation ........................ 8 Operation .................
IMPORTANT: This cutting machine is capable of amputating hands and feet and throw- ing objects. Failure to observe the following safety instructions could result in serious injury or death.
II. SLOPE OPERATION Slopes are a major factor related to loss of control and tip-over accidents, which can result in severe injury or death. Opera- tion on all slopes requires extra caution. If you cannot back up the slope or if you feel uneasy on it, do not mow it.
• Remove gas-powered equipment from the truck or trailer and refuel it on the ground. If this is not possible, then refuel such equipment with a portable container, rather than from a gasoline dispensernozzle. • Keep the nozzle in contact with the rim of the fuel tank or container opening at all times until fueling is complete.
PRODUCT SPECIFICATIONS Gasoline Capacity 1.25 Unleaded and Type: Regular Oil Type SAE 30 (above 32°F) 'API-SG-SL): SAE 5W-30(below 32°F Oil Capacity: W/Filter 3.5 Pints W/O Filter 3.0 Pints Spark Plug: Champion RC12YC (Gap: .030") Ground Speed Forward: (MPH): 1st 1.
Steering Wheel Insert (1) Hex Bolt 5/16-18 x 4 _ Steering Wheel Adapter i I I i Steering Wheel @ (1) Large Flat Washer © (1) 5/16 Lock Washer Steering Boot Steering Extension Shaft Seat (1) Washer @ .
Your new tractor has been assembled at the factory with the exception of those parts left unassembled for shipping purposes. To ensure safe and proper operation of your tractor all parts and hardware you assemble must be tightened securely. Use the correct tools as necessary to insure proper tightness.
7. Slide seat until a comfortable position is reached which allows you to press clutch/brake pedal all the way down. 8. Get off seat without moving its ad- justed position. 9. Raise seat and tighten adjustment knob securely. Seat Seat Shoulder Bolts Flat Washer djustment KnobN CHECK BATTERY 1.
CHECK TIRE PRESSURE The tires on your tractor were overin- flated at the factory for shipping purposes. Correct tire pressure is important for best cutting performance. ° Reduce tire pressure to PSI shown in "PRODUCT SPECIFICATIONS" section of this manual.
These symbols may appear on your tractor or in literature supplied with the product. Learn and understand their meaning. R N H L I'.,I REVERSE NEUTRAL HIGH LOW CHOKE FAST ENGINE OFF REVERSE ENGIN.
KNOW YOUR TRACTOR READ THIS OWNER'S MANUAL AND SAFETY RULES BEFORE OPERATING YOUR TRACTOR Compare the illustrations with your tractor to familiarize yourself with the locations of various controls and adjustments. Save this manual for future reference.
The operation of any tractor can result in foreign objects thrown into the eyes, which can result in severe eye damage. Always wear safety glasses or eye shields while operating your tractor or performing any adjustments or repairs. We recommend a wide vision safety mask over spectacles or standard safety glasses.
• The average lawn should be cut to ap- proximately 2-1/2 inches during the cool season and to over 3 inches during hot months. For healthier and better looking lawns, mow often and after moderate growth. • For best cutting performance, grass over 6 inches in height should be mowed twice.
TO TRANSPORT • Raise attachment lift to highest position with attachment lift control. • When pushing or towing your tractor, be sure gearshift lever is in neutral (N) position.
COLD WEATHER STARTING ( 50 ° F and below) 6. When engine starts, leave throttle control in choke position until engine warms up and begins to run roughly.
MAINTENANCE SCHEDULE _____ FILL IN DATES /_/@_/_-_,_" AS YOU COMPLETE /_'_ _'_ _.Oq'_ " BE OLAR SERV,CE OATES Check Operator Presence and T ROS Systems R Check for Loose Faste.
TRACTOR Always observe safety rules when per- forming any maintenance. BRAKE OPERATION If tractor requires more than five (5) feet to stop at highest speed in highest gear on a level, dry concrete or paved surface, then brake must be checked and adjusted.
• To check blade balance, you will need a 5/8" diameter steel bolt, pin, or a cone balancer. (When using a cone balancer, follow the instructions supplied with balancer.) NOTE: Do not use a nail for balancing blade. The lobes of the center hole may appear to be centered, but are not.
6. Remove the drain tube and replace the cap onto the end of the drain valve. 7. Refill engine with oil through oil fill dip- stick tube. Pour slowly. Do not overfill. For approximate capacity see "PROD- UCT SPECIFICATIONS" section of this manual.
4. Immediately wipe up any spilled gaso- line. Clamp_" Clamp I Filter CLEANING • Clean engine, battery, seat, finish, etc. of all foreign matter. • Keep finished surfaces and wheels free of all gasoline, oil, etc. • Protect painted surfaces with auto- motive type wax.
TO INSTALL MOWER 1. Raise attachment lift leverto its highest position. 2. Slide mower under tractor with deflec- tor shield to right side of tractor. 3. Lower lift lever to its lowest position. 4. Connect front links to mower deck and secure with retainer springs.
TO REPLACE MOWER BLADE DRIVE BELT The mower blade drive belt may be re- placed without tools. Park the tractor on level surface. Engage parking brake. BELT REMOVAL - 1. Remove mower from tractor (See "TO REMOVE MOWER" in this section of manual).
5. Make sure belt is in all pulley grooves and inside all belt guides and keepers. 6. Install mower (See "TO INSTALL MOWER" in this section of manual).
2. Connect one end of the BLACKcable to the NEGATIVE (-) terminal (C) of fully charged battery. 3. Connect the other end of the BLACK cable (D) to good chassis ground, away from fuel tank and battery. TO REMOVE CABLES, REVERSE ORDER - 1. BLACK cable first from chassis and then from the fully charged battery.
ENGINE Maintenance, repair, or replacement of the emission control devices and systems, which are being done at the customers expense, may be performed by any non-road engine repair establishment or individual. Warranty repairs must be performed by an authorized engine manufacturer's service outlet.
Immediately prepare your tractor for stor- age at the end of the season or if the trac- tor will not be used for 30 days or more. _WARNING: Neverstore the tractor with gasoline in the tank inside a building where fumes may reach an open flame or spark.
TROUBLESHOOTING CHART: See appropriate section in manual unless directed to Sears service center PROBLEM Will not start Hard to start Engine will not turn over Engine clicks but will not start CAUSE CORRECTION 1. Out of fuel. 2. Engine not "CHOKED" properly.
TROUBLESHOOTING CHART: See appropriate section in manual unless directed to Sears service center PROBLEM CAUSE CORRECTION 1. Cutting too much grass/too fast. 2. Throttle in "CHOKE" position. 3. Build-up of grass, leaves and trash under mower.
TROUBLESHOOTING CHART: See appropriate section in manual unless directed to Sears service center PROBLEM CAUSE CORRECTION Poorcut-uneven continued Mower blades will not rotate Poor grass discharge Headlight(s) not working (if so equipped) Battery will not charge Engine "backfires" when turning engine "OFF" 4.
SCHEMATIC TRACTOR - - MODEL NUMBER 917.275370 BATTERY A_,_MFER FUSE (OPTIONAL) SOLENOID STARTER ': II / i© ", 0-_ , _ a i a k i i '-=-2 C[LTTC I_ 7B-R,_K=E ATTACHMENT CLUTCH (CLUTCH OF.
TRACTOR - - MODEL NUMBER 917.275370 ELECTRICAL 90_ _ . ........ i i 42 41 22 1 I 1 I I I / I 26 25 / / / l O: II / // / // 32.
ELECTRICAL TRACTOR - - MODEL NUMBER 917.275370 KEY PART NO. NO. 1 163465 2 74760412 8 176689 16 176138 21 183759 22 4152J 24 4799J 25 146147 26 175158 27 73510400 28 4207J 29 192749 30 193350 33 14040.
TRACTOR - - MODEL NUMBER 917.275370 CHASSIS AND ENCLOSURES 29 212 / 28 39 278 31 209 _/5 @/5 208 209 208 60 74 209 60 -209 37 _209 14 38_ 38_4 208 chassis-Laser-It.
TRACTOR - - MODEL NUMBER 917.275370 CHASSIS AND ENCLOSURES KEY PART NO. NO. DESCRIPTION 1 174619 2 176554 5 155272 9 193510X012 10 STD533710 11 174996 13 172105X010 14 17490608 17 185682X613 18 184921.
GROUND DRIVE TRACTOR . . MODEL NUMBER 917.275370 77 37 • 48 75 26 27 53 drive-fender.stlL41 36.
TRACTOR - - MODEL NUMBER 917.275370 GROUND DRIVE KEY PART KEY NO. NO. DESCRIPTION NO. 1 Transaxle Peerless 206-545C 63 (See Breakdown) 64 2 146682 Spring Brake Return 65 3 123666X Pulley Transaxle 66 .
TRACTOR - - MODEL NUMBER 917.275370 STEERING ASSEMBLY -38 -_97 J J _ t t ,_42 _ 71 65 67 67 67 J , J" 3 82 _ 1" steering pl.lt 58 38.
TRACTOR - - MODEL NUMBER 917.275370 STEERING ASSEMBLY KEY PART NO. NO. DESCRIPTION 1 186780 Steering Wheel 2 175131 Axle Assembly STMP Dropped STL 3 169840 Spindle Assembly, L.FI. 4 169839 Spindle Assembly, R.FI. 5 6266H Bearing, Race, Thrust, Hardened 6 121748X Washer 25/32 x 1-5/8 x 16 Ga.
ENGINE TRACTOR - - MODEL NUMBER 917.275370 40 I 33 23 37 29 38 72 62 81 E 78 / 13 4 OPTIONAL EQUIPMENT Spark Arrester engine-bs.lcyl 49 KEY PART NO. NO. 1 170545 2 17720408 4 137352 13 165291 14 148456 23 169837 29 137180 31 187750 32 140527 33 123487X DESCRIPTION KEY PART NO.
TRACTOR - - MODEL NUMBER 917.275370 SEAT ASSEMBLY 5 8_ °q '! 17 seat It.knob 9 12 6 /1 21 KEY PART NO. NO. DESCRIPTION 1 188716 Seat 2 180166 Bracket, Pivot, Seat 3 71110616 Bolt 4 19131610 Washer 13/32 x 1 x 10 Ga.
DECALS TRACTOR - - MODEL NUMBER 917.275370 14 6 11 7 3 5 14 10 8 12 15 16 13 KEY PART NO. NO. 1 193308 2 186377 3 186280 4 179128 5 186281 6 133644 7 195879 8 138047 9 186282 10 149516 DESCRIPTION Decal Fender Opr.
TRACTOR -- MODEL NUMBER 917.275370 LIFT ASSEMBLY 7 19 13 32 13 32 19 13 6 5 2O 18 20 _" 15 lift-rh.lpiece 3 KEY PART NO. NO. 1 159460 2 159471 3 105767X 4 12000002 5 19211621 6 120183X 7 125631X .
TRACTOR - - MODEL NUMBER 917.275370 MOWER DECK 67 185 ii47142 5 6 f 19 21 42 D man-topath stir 3 16 21 28 29 27 44.
TRACTOR - - MODEL NUMBER 917.275370 MOWER DECK KEY PART KEY PART NO. NO. DESCRIPTION NO. NO. DESCRIPTION 1 165892 Mower Deck Assembly, 42" 44 140088 2 STD533107 Bolt 45 STD624003 3 138017 Bracket.
TRACTOR - - MODEL NUMBER 917.275370 PEERLESS TRANSAXLE - - MODEL NUMBER 206-545C 35A 29B 5 47 O _71B 8 70 6A 82 11 83 18 4 ;426 MODEL and SERIAL NUMBERS HERE i-o_',,;,_o% 'o' ] 79 51 29.
TRACTOR - - MODEL NUMBER 917.275370 PEERLESS TRANSAXLE - - MODEL NUMBER 206-5450 REF PART REF PART NO. NO. DESCRIPTION NO. NO. 1 772147 Transaxle Cover 41A 790079 2 780086A Needle Bearing 5/8" 42.
TRACTOR - - MODEL NUMBER 917.275370 BRIGGS ENGINE-MODEL NUMBER 31C707, TYPE NUMBER 0230-E1 25_ 27 307_ 358 ENGINE GASKET SET 20@ 6170 868_) 943 O 81_ 524 @ 1022 691 (_ 8420 1266 0 I 1019 LABEL KIT ] I 1088OWNER'S MANUAL I [ 1036 EMISSION LABEL ] 11 .
TRACTOR - - MODEL NUMBER 917.275370 BRIGGS ENGINE-MODEL NUMBER 31C707,TYPE NUMBER 0230-E1 238 g5 1 o22 6170 1022 914 1095 VALVE GASKET SET 617 0 1022 868 13_ .
TRACTOR -- MODEL NUMBER 917.275370 BRIGGS ENGINE-MODEL NUMBER 310707,TYPE NUMBER 0230-E1 142_ 117 _}-- 106 105 137 276@ 95o_ [ 1091 1869 127 G 108A _ e,.
TRACTOR - - MODEL NUMBER 917.275370 BRIGGS ENGINE-MODEL NUMBER 310707,TYPE NUMBER 0230-E1 305A _ 3041 968 3o_ 1265 801 (_ 603 _ 310 1 802 (_ 87-q-- _o1_ (_ 783A_ 544A 310 [ 513_ 803A _A _/311A NOTE: For Replacement Starter Motor, See Reference 309.
TRACTOR -- MODEL NUMBER 917.275370 BRIGGS ENGINE-MODEL NUMBER 310707,TYPE NUMBER 0230-E1 KEY PART KEY PART NO. NO. DESCRIPTION NO. NO. DESCRIPTION 1 697174 2 399265 3 391086 4 697106 5 698147 7 692410.
TRACTOR - - MODEL NUMBER 917.275370 BRIGGS ENGINE-MODEL NUMBER 310707,TYPE NUMBER 0230-E1 KEY PART KEY PART NO. NO. DESCRIPTION NO. NO. DESCRIPTION 383 89838 Wrench-Spark Plug 851 692424 404 691691 Wa.
54.
SUGGESTED GUIDE FOR SIGHTING SLOPES FOR SAFE OPERATION O7 O7 ...... ..,,... ONLY RIDE UP AND DOWN HILL, NOT ACROSS HILL 15 DEGREES MAX. _[i ARNING: To avoid serious injury, operate your tractor up and down the face of slopes, never across the face. Do not mow slopes greater than 15 degrees.
iiiiiiiiiiiiiiiiiiijiii,_ iiiiiiiiiiiiiiiii ,_ HHHHHHHHh,_ iiiiiiiiiiiiiiiii ''_ iiiiiiiiiiiiiiiiiii iiiiiiiiiiiiiiiiiii iiiiiiiiiiiiiiiiiii iiiiiiiiiiiiiiiiiii iiiiiiiiiiiiiiiiiii iiiiiiiii.
デバイスCraftsman 917.27537の購入後に（又は購入する前であっても）重要なポイントは、説明書をよく読むことです。その単純な理由はいくつかあります：
Craftsman 917.27537をまだ購入していないなら、この製品の基本情報を理解する良い機会です。まずは上にある説明書の最初のページをご覧ください。そこにはCraftsman 917.27537の技術情報の概要が記載されているはずです。デバイスがあなたのニーズを満たすかどうかは、ここで確認しましょう。Craftsman 917.27537の取扱説明書の次のページをよく読むことにより、製品の全機能やその取り扱いに関する情報を知ることができます。Craftsman 917.27537で得られた情報は、きっとあなたの購入の決断を手助けしてくれることでしょう。
Craftsman 917.27537を既にお持ちだが、まだ読んでいない場合は、上記の理由によりそれを行うべきです。そうすることにより機能を適切に使用しているか、又はCraftsman 917.27537の不適切な取り扱いによりその寿命を短くする危険を犯していないかどうかを知ることができます。
ですが、ユーザガイドが果たす重要な役割の一つは、Craftsman 917.27537に関する問題の解決を支援することです。そこにはほとんどの場合、トラブルシューティング、すなわちCraftsman 917.27537デバイスで最もよく起こりうる故障・不良とそれらの対処法についてのアドバイスを見つけることができるはずです。たとえ問題を解決できなかった場合でも、説明書にはカスタマー・サービスセンター又は最寄りのサービスセンターへの問い合わせ先等、次の対処法についての指示があるはずです。
