Hearth and Home TechnologiesメーカーBODBAYの使用説明書/サービス説明書
ページ先へ移動 of 24
SA VE THESE INSTRUCTIONS www .quadrare.com This manual contains instructions for Installation, Operation & Maintenance. Please read this entire manual before you install and use your new room heater . Failure to follow instructions may result in property damage, bodily injury , or even death.
BODEGA BA Y WOOD INSERT Page 2 August 20, 2008 R 435-1320B and Welcome to the Quadra-Fire Family ! H earth & Home T echnologies welcomes you to our tradition of excellence! In choosing a Quadra-Fire appliance, you have our assurance of commitment to quality , durability , and perfor - mance.
Page 3 August 20, 2008 BODEGA BA Y WOOD INSERT R 435-1320B SAFETY & OVER VIEW OF APPLIANCE Location & Sample of Serial Number Label ----------- 2 Dimensions -----------------------------------.
BODEGA BA Y WOOD INSERT Page 4 August 20, 2008 R 435-1320B DIMENSIONS T OP VIEW SIDE VIEW FRONT VIEW SERIAL NUMBER LABEL LOCA TION: ON BEADED CHAIN, LEFT SIDE BEHIND OUTER SKIN Hearth Extension A B C .
Page 5 August 20, 2008 BODEGA BA Y WOOD INSERT R 435-1320B A VOID FIRE: T o ensure that insulation or any other combustible material does not contact the chimney , a chimney inside the house must have at least 2 inches (51mm) of air space clearance around the chimney .
BODEGA BA Y WOOD INSERT Page 6 August 20, 2008 R 435-1320B IF INST ALLING THIS MODEL T O A MASONRY CHIMNEY , AL W A YS BE SURE THE CHIMNEY IS IN GOOD CONDITION AND THA T IT MEETS THE MINIMUM ST ANDARDS OF THE NA TIONAL FIRE PROTECTION ASSOCIA TION (NFP A) ST ANDARD 21 1.
Page 7 August 20, 2008 BODEGA BA Y WOOD INSERT R 435-1320B Floor Ceiling Caulk Floor (second Story) Non-Combustible Firestopping Material Minimum 1 inch (25mm) clearance from exterior chimney to sheat.
BODEGA BA Y WOOD INSERT Page 8 August 20, 2008 R 435-1320B 1. An outside air inlet must be provided for combustion and must remain clear of leaves, debris, ice and/or snow . It must be unrestricted while unit is in use to prevent room air starvation which can cause smoke spillage and an inability to maintain a re.
Page 9 August 20, 2008 BODEGA BA Y WOOD INSERT R 435-1320B MASONR Y FIREPLACE USING DIRECT -CONNECT METHOD Refer to: Clearances to Combustibles on page 4, Canadian Installation Requirements on page 1 1, Hearth Requirements on page 4 and Zero Clearance Adjustable Support Kit on page 15.
BODEGA BA Y WOOD INSERT Page 10 August 20, 2008 R 435-1320B F ACT OR Y BUIL T ZERO CLEARANCE FIREPLACE (USA INST ALLA T ONS ONL Y) Listed Liner Mantel SEAL DAMPER AREA OR FACE SEAL Figure 10A - Instal.
Page 1 1 August 20, 2008 BODEGA BA Y WOOD INSERT R 435-1320B INST ALLA TION IN CANADA MASONR Y and HEA T -CIRCULA TING (INST ALLA TIONS INTO F ACTORY -BUIL T FIREPLACES ARE PROHIBITED IN CANADA) Wheth.
BODEGA BA Y WOOD INSERT Page 12 August 20, 2008 R 435-1320B SECURING LINER T O CHIMNEY RING There are 2 options to secure the liner to the chimney ring: (See Figure 12A). Option One: If there is enough room on the top of the insert to work, hand bend the two tabs upward 90°.
Page 13 August 20, 2008 BODEGA BA Y WOOD INSERT R 435-1320B 1. Remove contents from box being careful not to scratch or damage trim pieces. 2. Lay the panel set face down on protective covering to prevent scratching the painted surface. 3. Secure panel set together with screws provided.
BODEGA BA Y WOOD INSERT Page 14 August 20, 2008 R 435-1320B BLOWER CORD LOCA TION Remove Bolt Remove Bolt Figure 14A Figure 14C Figure 14D Figure 14B - Right Side Location Black Red White Snap Disc Blower Control Box with Switch Cooling Fan Black Operating the Blower Control Box with Switch 1.
Page 15 August 20, 2008 BODEGA BA Y WOOD INSERT R 435-1320B ZERO CLEARANCE ADJUST ABLE TRIM SUPPORT , 2” to 10” Part No. 841-0990, size 9”d x 45”w and Part No.
BODEGA BA Y WOOD INSERT Page 16 August 20, 2008 R 435-1320B WOOD SELECTION AND STORAGE Burn only dry seasoned wood. Dry , well-seasoned wood will not only minimize the chance of creosote formation but will give you the most efcient heat output.
Page 17 August 20, 2008 BODEGA BA Y WOOD INSERT R 435-1320B BURN RA TES ST ARTING FIRE : Open both controls (push in) completely . After a wood load has been burning on high for 5 to 15 minutes or longer for very large pieces, close the Start-Up Air Control (bottom rod) by pulling it out.
BODEGA BA Y WOOD INSERT Page 18 August 20, 2008 R 435-1320B AIR QUALITY AND YOUR QUADRA-FIRE INSERT In recent years there has been an increasing concern about the quality of our air . Much of the blame for poor air quality has been placed on the burning of wood for home heating.
Page 19 August 20, 2008 BODEGA BA Y WOOD INSERT R 435-1320B MAINTENANCE CARE AND CLEANING OF PLA TED SURF ACES IMPORT ANT : Y ou must clean all the ngerprints and oils from the plated surfaces before ring the insert for the rst time.
BODEGA BA Y WOOD INSERT Page 20 August 20, 2008 R 435-1320B 1 1 2 2 3 4 4 4 4 4 4 4 4 4 4 6 6 4 4 5 2 6-1/8" 2-1/4" 5 5 Allen wrench on retainer bolt First tube has larger holes BRICK REPLACEMENT INSTRUCTIONS P ART 832-3500 The rebox of your insert is lined with high quality re - brick which has exceptional insulating properties.
Page 21 August 20, 2008 BODEGA BA Y WOOD INSERT R 435-1320B EXPLODED VIEW 1 10 2 3 4 5 6 7 8 9 1 1 12 13 14 15 16 17 18 24 19 20 21 22 23 Item Part Name 1 Strain Relief Bushing 2 Speed Control (Rheost.
BODEGA BA Y WOOD INSERT Page 22 August 20, 2008 R 435-1320B SER VICE P ARTS DC-BB-GD Door Crown, Gold DC-BB-NL Door Crown, Nickel SP-BB3044-GD Panel & Gold T rim Set, Small, 30-1/2”h x 44-5/8”.
Page 23 August 20, 2008 BODEGA BA Y WOOD INSERT R 435-1320B W arranty Policy LIMITED LIFETIME W ARRANTY The Hearth & Home T echnologies limited Lifetime Warranty guarantees that the following components will work as designed for the lifetime of the stove or Hearth & Home T echnologies will repair or replace them.
Page 24 August 20, 2008 435-1320B R • Do NOT discard this manual. • Important operating and maintenance instructions included. • Read, understand and follow these instruci- tons for safe installation and operation. • Leave this manual with party responsible for use and operation.
デバイスHearth and Home Technologies BODBAYの購入後に（又は購入する前であっても）重要なポイントは、説明書をよく読むことです。その単純な理由はいくつかあります：
Hearth and Home Technologies BODBAYをまだ購入していないなら、この製品の基本情報を理解する良い機会です。まずは上にある説明書の最初のページをご覧ください。そこにはHearth and Home Technologies BODBAYの技術情報の概要が記載されているはずです。デバイスがあなたのニーズを満たすかどうかは、ここで確認しましょう。Hearth and Home Technologies BODBAYの取扱説明書の次のページをよく読むことにより、製品の全機能やその取り扱いに関する情報を知ることができます。Hearth and Home Technologies BODBAYで得られた情報は、きっとあなたの購入の決断を手助けしてくれることでしょう。
Hearth and Home Technologies BODBAYを既にお持ちだが、まだ読んでいない場合は、上記の理由によりそれを行うべきです。そうすることにより機能を適切に使用しているか、又はHearth and Home Technologies BODBAYの不適切な取り扱いによりその寿命を短くする危険を犯していないかどうかを知ることができます。
ですが、ユーザガイドが果たす重要な役割の一つは、Hearth and Home Technologies BODBAYに関する問題の解決を支援することです。そこにはほとんどの場合、トラブルシューティング、すなわちHearth and Home Technologies BODBAYデバイスで最もよく起こりうる故障・不良とそれらの対処法についてのアドバイスを見つけることができるはずです。たとえ問題を解決できなかった場合でも、説明書にはカスタマー・サービスセンター又は最寄りのサービスセンターへの問い合わせ先等、次の対処法についての指示があるはずです。
