HTCメーカー110163 / CZ38の使用説明書/サービス説明書
ページ先へ移動 of 16
For 38 Inch Consumer Z Grass Catcher 1 10163 / CZ38 Model: MANUAL NO. 5391 10995 REV . 03 (02/06/06) Operator And Part s Manual.
2 SAFETY RULES DANGER ! THIS CUTTING MACHINE IS CAP ABLE OF AMPUT A TING HANDS AND FEET AND THROWING OBJECTS. F AILURE TO OBSERVE THE FOLLOWING SAFETY INSTRUCTIONS COULD RESUL T IN SERIOUS INJUR Y OR DEA TH. SAFE OPERA TION PRACTICES FOR RIDE-ON MOWERS I.
3 SAFETY RULES • Do not mow near drop-off, ditches, or embankments. The mower could suddenly turn over if a wheel is over the edge of a cliff or ditch, or if an edge caves in. • Do not mow on wet grass. Reduced trac- tion could cause sliding. • Do not try to stabilize the machine by putting your foot on the ground.
4 SAFETY RULES SAFE OPERA TION PRACTICES FOR RIDE-ON MOWERS CAUTION W ARNING Look for this symbol to point out impor- tant safety p recautions. It means CAU- TION!!! BECOME ALERT!!! Y OUR SAFETY IS INVOL VED.
5 CONGRA TULA TIONS on your purchase of a new Grass Catcher . It has been designed, engi- neered and manufactured to give you the best possible dependability and performance. Should you experience any problem you cannot easily remedy , please contact your nearest au- thorized service center/ department.
6 UNP ACKING INSTRUCTIONS • Remove all parts and packing materials from carton. • Check carton contents against list. Be sure all parts are there. TOOLS REQUIRED FOR ASSEMBL Y (2) 9/16" Wrenc.
7 ASSEMBL Y NOTE: Before mounting your new bagger you will have to remove the mower ’ s utility box and rear guard. 2 MOWER DECK BAFFLE (See Figure 2.) 1. Raise your mower deck to its highest posi- tion. 2. Install the hex bolt, and locknut through mower deck baffle and tighten securely .
8 ASSEMBL Y 5 MOUNTING COVER ASSEMBL Y TO SUPPORT ASSEMBL Y (See Figure 5) NOTE: For ease of assembly , you may wish to obtain the assistance of another person for mounting cover assembly to mower . 1. Position cover assembly on ground behind mower as shown.
9 6 CONT AINER ASSEMBL Y (See Figure 6) 1. Place bottom half inside of top half, as shown. 2. Place one foot inside bottom half and lift top half to meet bottom half.
10 ASSEMBL Y 9 HOSE (See Figures 9A and 9B) 1. Place both clamps over the hose. 2. Slide the hose over the inlet at the top end. 3. Slide the hose over the lower chute inlet. 4. Remove any twists in the hose by rotating it at the top or bottom end. 5.
11 11 LEVEL MOWER DECK Be sure deck is properly leveled for best mower performance. See your mower operator ’s manual for instructions. ASSEMBL Y 10 BLADE REPLACEMENT T ools Needed: 9/16” Socket and Ratchet Ft/Lbs T orque Wrench The mower comes from the factory with a low lift blade.
12 OPERA TION TIPS FOR IMPROVED BAGGING OPERA TION: Follow the mower operation instructions in you mower operator ’s manual. When operating your grass catcher on a lawn where grass and leaf bagging equipment has not been used, you are picking up thatch and debris that has accumulated for long periods of time.
13 CUSTOMER RESPONSIBILITIES GENERAL RECOMMENDA TIONS: Always observe safety rules when performing any maintenance. • Before each use check for loose fasteners. • Clean unit thoroughly after each use. BLADE CARE: For best results mower blades must be kept sharp.
14 P ARTS 2 14 15 16 17 18 4 5 6 7 8 9 10 19 20 13 13 13 1 2 2 8 8 3 11 12 13 13 13 2 2 REF . 22 21 23 24 25 27 28 29 30 31 33 25 34 35 36 35 26 32 2 37.
15 P ARTS ITEM P ART NO. QT Y . DESCRIPTION 1 ......... 5391 1 1 139 ........... 1 ......... COVER ASSEMBL Y , COMPLETE ..................................................... (I NCLUDES ITEM 2 THRU 13) 2 ......... 532063180 .......... 1 0 ........ NUT , 3/10-24, CROWNLOCK 3 .
HTC 401 N. Commerce St. Beatrice, NE 68310.
デバイスHTC 110163 / CZ38の購入後に（又は購入する前であっても）重要なポイントは、説明書をよく読むことです。その単純な理由はいくつかあります：
HTC 110163 / CZ38をまだ購入していないなら、この製品の基本情報を理解する良い機会です。まずは上にある説明書の最初のページをご覧ください。そこにはHTC 110163 / CZ38の技術情報の概要が記載されているはずです。デバイスがあなたのニーズを満たすかどうかは、ここで確認しましょう。HTC 110163 / CZ38の取扱説明書の次のページをよく読むことにより、製品の全機能やその取り扱いに関する情報を知ることができます。HTC 110163 / CZ38で得られた情報は、きっとあなたの購入の決断を手助けしてくれることでしょう。
HTC 110163 / CZ38を既にお持ちだが、まだ読んでいない場合は、上記の理由によりそれを行うべきです。そうすることにより機能を適切に使用しているか、又はHTC 110163 / CZ38の不適切な取り扱いによりその寿命を短くする危険を犯していないかどうかを知ることができます。
ですが、ユーザガイドが果たす重要な役割の一つは、HTC 110163 / CZ38に関する問題の解決を支援することです。そこにはほとんどの場合、トラブルシューティング、すなわちHTC 110163 / CZ38デバイスで最もよく起こりうる故障・不良とそれらの対処法についてのアドバイスを見つけることができるはずです。たとえ問題を解決できなかった場合でも、説明書にはカスタマー・サービスセンター又は最寄りのサービスセンターへの問い合わせ先等、次の対処法についての指示があるはずです。
