hussmanメーカーIGHT-ESH/ESHS-0010の使用説明書/サービス説明書
ページ先へ移動 of 47
/Chino ESH/ESHS Hot F ood F amily Single-Deck Ser vice Hot F ood Case Re v . 0010 Installation & Operation Manual ESH/ESHS Hot F ood F amily Single-Deck Ser vice Hot F ood Case p/n IGHT -ESH/ESHS-.
IGHT-ESH/ESHS-0010 2 /Chino A publication of Hussmann ® Chino 13770 Ramona A v enue • Chino, California 91710 (909) 628-8942 F AX (909) 590-4910 (800) 395-9229 K eep this booklet with the case at all times for futur e r eference.
Rev. 0010 3 UNCRA TING THE ST AND Place the fixtur e as close to its permanent position as possible . Remov e the top of the crate. Detach the walls fr om each other and remo ve fr om the skid. Unbolt the case fr om the skid. The fixture can no w be lifted off the crate skid.
IGHT-ESH/ESHS-0010 4 LEVELING IMPOR T ANT! IT IS IMPERA TIVE THA T CASES BE LEVELED FROM FR ONT T O BA CK AND SIDE T O SIDE PRIOR T O JOINING. A LEVEL CASE IS NECESSAR Y T O INSURE PROPER OPERA TION, W A TER DRAINAGE, GLASS ALIGNMENT , AND OPERA TION OF THE HINGES SUPPOR TING THE GLASS.
Rev. 0010 5 FINISHING TOUCHES (PERFORM AFTER PLUMBING AND ELECTRICAL) A CCESS P ANELS All electrical and drain access panels ar e clearly labeled on the deck of the stand. . INST ALLING SPLASHGU ARD After mer chandisers ha ve been le veled and joined and all electrical and plumbing w ork has been completed, install the splashguards.
IGHT-ESH/ESHS-0010 6 BEFORE SER VICING Alwa ys Disconnect Electrical P o wer at the Main Disconnect when ser vicing or replacing an y electrical component.
Rev. 0010 7 guide for the use of this equipment. The local health agency for y our area can pr ovide specific temperature requir ements. Critical attention must be giv en to the heat contr ols for these hot tables. Both the upper and lower heat contr ols must be adjusted to achie ve pr oper food temperatures.
IGHT-ESH/ESHS-0010 8 is heating. The pilot lamp beside the contr ol knob indi- cates when the well heater is heating. AUT O-FILL OPERA TION Hussmann hot cases are equipped with an internal auto fill system that allows automatic filling of the heating pans.
Rev. 0010 9 User Information cont. 1. Scrub thoroughl y , cleaning all surfaces, with soap and hot water . 2. Rinse with hot water , but do not flood. 3 . Apply the sanitizing solution accor ding to the manufactur er’ s dir ections. 4. Rinse thor oughly .
IGHT-ESH/ESHS-0010 10 IMPOR T ANT ! READ BEFORE RAISING FRONT GLASS : The top cylinders, which allow the raising and low ering of the glass, ha ve been car efully tested f or pr oper ten- sion. Howe ver , during shipment, the clamshell scre ws can work themselv es out and/or the lubricant inside may ha v e settled.
Rev. 0010 11 PIST ON REPLA CEMENT 1. OPEN GLASS. Glass m ust remain open thr oughout procedur e . 2. Loosen Allen set Scr ew (1). 3. While holding onto piston, remov e and sav e pin (2). 4. Slide piston out. 5. Slide new piston in making sure the U-sha ped end fits around pin at bottom of arm (3).
IGHT-ESH/ESHS-0010 12 RECOMMENDED ADJUSTMENTS, VERIFY THA T THE CASE(S) HA VE BEEN LEVELED PROPERL Y .TIPS & TROUBLESHOO TING Befor e calling for ser vice if something seems wr ong, check the follo wing: 1. INSPECT THE GAP BETWEEN THE GLASS PANELS A.
Rev. 0010 13 3. CHECK OPENING ACTION OF GLASS PANELS A. Lift up adjacent glass panels at the same time and note the follo wing: B. Do the corners of the glass maintain an ev en gap throughout the tra vel of the panels? And do the corners touch or ov erlap at an y point? T o correct pr oblem Go to items 4 & 5.
IGHT-ESH/ESHS-0010 14 5. STRATEGIES FOR CORRECTING GLASS BOUNCE AND OPENING OVERLAP PROBLEMS ADJUST HINGES FRONT – BACK. A. Adjust center Hinge (Outer hinges stationar y) As this diagram indicates, pulling the middle hinge further back, pulls the inside edges closer to the surface or edge which the glass rests upon.
Rev. 0010 15 6. VERTICAL AND FRONT TO BACK ADJUSTMENT AND OPENING OVERLAP PROBLEMS • V ER TICAL A DJUSTMENT 1. Remove 2. Lift open 3. Loosen hex screw 4. Add or remove 5. Close glass panel(s) top glass glass panel(s) (1/4" allen). shims as needed.
IGHT-ESH/ESHS-0010 16 TIPS & TROUBLESHOO TING Befor e calling for ser vice if something seems wrong, check the follo wing: 1. Check electrical pow er supply to the equipment for connection. 2. Check fixtur e loading. Ov erstocking case will affect its pr oper operation.
Rev. 0010 17 WELLS GRIDDLES SHELF CIRCUIT 1 CIRCUIT 2 WIRING Remarks MODEL LENGTH P ANS QTY . SIZE LEVELS VOL TS PHASE Loads PHASE Loads Diagram Number Individual W ells Ser vice ESH, ESHS 4' 3 2.
IGHT-ESH/ESHS-0010 18 Sheet 1 of 1 final BK Boris Kasrel Date: Project Title: Drawing No.: Drawn By: Next Assembly: Drawing Title: Date: Hussmann Corporation 13770 Ramona Avenue Chino, CA. 91710 (909)-590-4910 Lic.#: 644406 Revisions: No. Description: Checked By: By: 10.
Rev. 0010 19 ASH, ESH-S, RGSH-L/S, OSH Sheet 1 of 1 final BK Boris Kasrel Date: Pro ject Title: Drawing N o.: Drawn By: Next Assembly: Drawing Title: Date: Hussmann Corporation 13770 Ramona Avenue Chino, CA. 91710 (909)-590-4910 Lic.#: 644406 Revisions: No.
IGHT-ESH/ESHS-0010 20 ASH, ESH-S, RGSH-L/S, OSH Sheet 1 o f 1 final BK Boris Kasrel Date: Project Title: Drawing No.: Drawn By: Next Assembly: Drawing Title: Date: Hussmann Corporation 13770 Ramona Avenue Chino, CA. 91710 (909)-590-4910 Lic.#: 644406 Revisions: No.
Rev. 0010 21 ASH, ESH-S, RGSH-L/S, OSH Common W ell Remov able Pans Hot Food S ervice Counter Sheet 1 of 1 final BK Boris Kasrel Date: Project Title: Drawing No.: Drawn By: Next Assembly: Drawing Title: Date: Hussmann Corp oratio n 137 70 Ramona Avenue Chino , CA .
IGHT-ESH/ESHS-0010 22 Electrical Schematics ASH, ESH-S, RGSH-L/S, OSH Hot Food Service Counters Sheet 1 of 1 final BK Boris Kasrel Date: Project Title: Drawing No.: Drawn By: Next Assembly: Drawing Title: Date: Hussmann Corporation 13770 Ramona Avenue Chino, CA.
Rev. 0010 23 Electrical Schematics ASH, ESH-S, RGSH-L/S, OSH Sheet 1 of 1 final BK Boris Kasrel Date: Project Title: Drawi ng N o.: Drawn By: Next Assembly: Drawing Title: Date: Hussmann Corporation 13770 Ramona Avenue Chino, CA. 91710 (909)-590-4910 Lic.
IGHT-ESH/ESHS-0010 24 Sheet 1 of 1 final BK Boris Kasrel Date: Project Title: Drawing No.: Drawn By: Next Assembly: Drawing Title: Date: Hussmann Corporation 13770 Ramona Avenue Chino, CA. 91710 (909)-590-4910 Lic.#: 644406 Revisions: No. Description: Checked By: By: 11.
Rev. 0010 25 Electrical Schematics ASH, ESH-S, RGSH-L/S, OSH Sheet 1 of 1 final BK Boris Kasrel Date: Project Title: Drawing No.: Drawn By: Next Assembly: Drawing Title: Date: Hussmann Corporation 13770 Ramona Avenue Chino, CA. 91710 (909)-590-4910 Lic.
IGHT-ESH/ESHS-0010 26 ASH, ESH-S, RGSH-L/S, OSH Sheet 1 of 1 final BK Boris Kasrel Date: Project Title: Drawing No.: Drawn By: Next Assembly: Drawing Title: Date: Hussmann Corporation 13770 Ramona Avenue Chino, CA. 91710 (909)-590-4910 Lic.#: 644406 Revisions: No.
Rev. 0010 27 Electrical Schematics ASH, ESH, ESHS, RGSHL, RGSHS, OSH-SS Sheet 1 of 1 final BK Date: Project Title: Drawing N o.: Drawn By: Next Assembly: Dra wing Title: Date: Hussmann Corporation 13770 Ramona Avenue Chino, CA. 91710 (909)-590-4910 Lic.
IGHT-ESH/ESHS-0010 28 ASH, ESH, ESHS, RGSHL, RGSHS, OSH-SS Sheet 1 of 1 final BK Boris Kasrel Date: Project Title: Drawing No.: Drawn By: Next Assembly: Drawing Title: Date: Hussmann Corporation 13770 Ramona Avenue Chino, CA. 91710 (909)-590-4910 Lic.
Rev. 0010 29 ASH, ESH, ESHS, RGSHL, RGSHS, OSH-SS Sheet 1 of 1 final BK Boris Kasrel Date: Project Title: Drawing N o.: Drawn By: Next Assembly: Drawing Title: Date: Hussmann Corp oratio n 137 70 Ramona Avenue Chino , CA . 91710 (909)- 590- 491 0 Lic.
IGHT-ESH/ESHS-0010 30 By: Checked By: No. Descripti on: Revisions: W6000014 Hussmann Corp oratio n 137 70 Ramona Avenue Chino , CA . 91710 (909)- 590- 491 0 Lic.#: 64440 6 Date: Drawing Title: Next Assembly: Drawn By: Drawing N o.: Pro ject Title: Date: Boris Kasrel BK 01.
Rev. 0010 31 ASH, ESH, ESHS, RGSHL, RGSHS, OSH-SS Plain Griddle Self-Service Display Sheet 1 of 1 final BK Boris Kasrel Date: Project Title: Drawing No.: Drawn By: Next Assembly: Drawing Title: Date: Hussmann Corporation 13770 Ramona Avenue Chino, CA.
IGHT-ESH/ESHS-0010 32 By: Checked By: No. Descripti on: Revisions: W 6000016 Hussmann Corporation 13770 Ramona Avenue Chino, CA. 91710 (909)-590-4910 Lic.#: 644406 Date: Drawing Title: Next Assembly: Drawn By: Drawing N o.: Project Title: Date: Boris Kasrel BK 04.
Rev. 0010 33 ASH, ESH/S, RGSH-L/S, RGSHS Multipurpose Combo Counters Sheet 1 of 1 final BK Boris Kasrel Date: Project Title: Drawing No.: Drawn By: Next Assembly: Drawing Title: Date: Hussmann Corporation 13770 Ramona Avenue Chino, CA. 91710 (909)-590-4910 Lic.
IGHT-ESH/ESHS-0010 34 ASH, ESH/S, RGSH-L/S, RGSHS Multipurpose Combo Counters Sheet 1 of 1 final BK Boris Kasrel Date: Project Title: Drawing No.: Drawn By: Next Assembly: Drawing Title: Date: Hussmann Corporation 13770 Ramona Avenue Chino, CA. 91710 (909)-590-4910 Lic.
Rev. 0010 35 Date: Project Title: Drawing N o.: Drawn By : Assembly: Drawin g Title: Date: Hussmann Corp oratio n, Int'l. 137 70 Ramona Avenue , Ch ino , CA . 91710 (909)- 590- 491 0 Lic.#: 644406 Revisions: No. Descri ption: Checked By: By: File Loc ation: Adrián E.
IGHT-ESH/ESHS-0010 36 6', (5) 12x27 Hot Food W ell ASH, ESH/S, RGSH-L/S, RGSHS Individual W ells Hot Food Self-Service Counter final BK Boris Kasrel Date: Project Title: Drawing No.: Drawn By: Next Assembly: Drawing Title: Date: Hussmann Corporation 13770 Ramona Avenue Chino, CA.
Rev. 0010 37 RGSHS8'-6 Individual W ells Wirin g Diagram ASH, ESH/S-SS, RGSHS/L-SS Hot Food Individual W ells Service Case Sheet 1 o f 1 final BK Boris Kasrel Date: Project Title: Drawing No.: Drawn By: Next Assembly: Drawing Title: Date: Hussmann Corporation 13770 Ramona Avenue Chino, CA.
IGHT-ESH/ESHS-0010 38 ESH/S-RGSHL/S 10'- 8 Individual W ells Individual W ells Hot Food Self Service Cou nters Sheet 1 of 1 final Boris Kasrel Date: Project Title: Drawing No.: Drawn By: Next Assembly: Drawing T itle: Date: Hussmann Corporation 13770 Ramona Avenue Chino, CA.
Rev. 0010 39 final BK Boris Kasrel Date: Project Title: Drawing No.: Drawn By: Next Assembly: Drawing Titl e: Date: Hussmann Corporation 13770 Ramona Avenue Chino, CA. 91710 (909)-590-4910 Lic.#: 644406 Revisions: No. Description: Checked By: By: L1 L2 L3 L1 L2 L3 ~208V ~240V LOADS, Amps 27.
IGHT-ESH/ESHS-0010 40 Sheet 1 of 1 final BK Boris Kasrel Date: Project Title: Dr awin g No .: Drawn By: Next Assembly: Drawing T itle: Date: Hussmann Corporation 13770 Ramona Avenue Chino, CA.
Rev. 0010 41 Sheet 1 of 1 final BK Boris Kasrel Date: Project Title: Dr awin g No .: Drawn By: Next Assembly: Drawing T itle: Date: Hussmann Corporation 13770 Ramona Avenue Chino, CA. 91710 (909)-590-4910 Lic.#: 644406 Revisio ns: No. Description: Checked By: By: 01.
IGHT-ESH/ESHS-0010 42 ASH, ESH/S, RGSH-L/S, RGSHS Combo Hot Food Self-Service Counters Sheet 1 of 1 final BK Boris Kasrel Date: Project Title: Dr awin g No .: Drawn By: Next Assembly: Drawing T itle: Date: Hussmann Corporation 13770 Ramona Avenue Chino, CA.
Rev. 0010 43 ASH, ESH/S, RGSH-L/S,RGSHS Combo Hot Food Self-Service Counter Sheet 2 of 2 final BK Boris Kasrel Date: Project Title: Drawing No.: Drawn By: Next Assembly: Drawing T itle: Date: Hussmann Corp oratio n 137 70 Ramona Avenue Chino , CA . 91710 (909)- 590- 491 0 Lic.
IGHT-ESH/ESHS-0010 44 APPENDIX A. – Temperature Guidelines 1.0 Hot cases are tested to maintain all hot food at 140 ° - 150 ° . These cases are not designed to heat up or cook food. It is the user’s responsibility to stock the hot food cases immediately after the cooking of the food with a pulp temperature of at least 150 ° to 160 ° .
Rev. 0010 45 13. Turn the equipment off and allow to cool before cleaning. 14. To remove “baked-on” splatter from Stainless Steel, the following may be used Grade F Italian Pumice Scour or rub wit.
IGHT-ESH/ESHS-0010 46 Limited W arranty This warranty is made to the original user at the original installation site and is not transf erable . Hussmann mer chandisers are war ranted to be free fr om .
Rev. 0010 47 The MODEL NAME and SERIAL NUMBER is required in or der to pr ovide you with the correct parts and information f or y our particular unit. They can be found on a small metal plate on the unit. Please note them below for futur e refer ence.
デバイスhussman IGHT-ESH/ESHS-0010の購入後に（又は購入する前であっても）重要なポイントは、説明書をよく読むことです。その単純な理由はいくつかあります：
hussman IGHT-ESH/ESHS-0010をまだ購入していないなら、この製品の基本情報を理解する良い機会です。まずは上にある説明書の最初のページをご覧ください。そこにはhussman IGHT-ESH/ESHS-0010の技術情報の概要が記載されているはずです。デバイスがあなたのニーズを満たすかどうかは、ここで確認しましょう。hussman IGHT-ESH/ESHS-0010の取扱説明書の次のページをよく読むことにより、製品の全機能やその取り扱いに関する情報を知ることができます。hussman IGHT-ESH/ESHS-0010で得られた情報は、きっとあなたの購入の決断を手助けしてくれることでしょう。
hussman IGHT-ESH/ESHS-0010を既にお持ちだが、まだ読んでいない場合は、上記の理由によりそれを行うべきです。そうすることにより機能を適切に使用しているか、又はhussman IGHT-ESH/ESHS-0010の不適切な取り扱いによりその寿命を短くする危険を犯していないかどうかを知ることができます。
ですが、ユーザガイドが果たす重要な役割の一つは、hussman IGHT-ESH/ESHS-0010に関する問題の解決を支援することです。そこにはほとんどの場合、トラブルシューティング、すなわちhussman IGHT-ESH/ESHS-0010デバイスで最もよく起こりうる故障・不良とそれらの対処法についてのアドバイスを見つけることができるはずです。たとえ問題を解決できなかった場合でも、説明書にはカスタマー・サービスセンター又は最寄りのサービスセンターへの問い合わせ先等、次の対処法についての指示があるはずです。
