Keating Of Chicagoメーカー2005の使用説明書/サービス説明書
ページ先へ移動 of 22
1-800-K EA TI NG www .keatingofchicago.com Users Manual T OP S I D E™ COOK E R S E R I E S 2005 R EAD AN D SA VE TH I S MAN U AL F OR FUTUR E R E FE R E NCE. Keep this manual for training new personnel. I M P ORT ANT: K eep a copy of your bill of s ale.
NOTICE: This operating, installation, and service manual should be given to the user . The operator of the T op- Side Cooker ™ should be familiar with its functions and operation. This manual must be kept in a prominent, easily reachable location near the T op-Side Cooker ™ .
1 I INTRODUCTION GENERAL Keating T op-Side ™ Cookers are designed to give maximum production efficiency , delivering high quality food products. The following design features are incorporated into Keating T op-Side ™ Cookers.
2 ELECTRICAL CONNECTION Each Keating T op-Side ™ Cooking head is equipped with a 9' (2.74m) neoprene covered, 12 gauge 4mm(2), three wire with ground electrical cord. Each cooking head is rated 4000W , 18 amp s, single phase at 220 V olt s and is designed to be connected to its own 208- 240V single phase electrical supply .
3 Programming T o program the timers, the unit must be in the idle mode. Press and hold the set button for approximately two seconds. The display will show “SEt”. Press T1, T2 or T3 for the cook time to be programmed. The display will show the current setting for that cook time.
4 Do not hack, chop or hit the surface. Y ou will dent the steel plate under the trivalent chrome. It is even possible to hack two nicks close together and actually tear the MIRACLEAN ® surface as the chromium will not stretch. Below is a sketch showing a side view of a cooking head and how the surface can be damaged.
INST ALLING A COOKING SEET 1. Raise T op-Side ™ Cooking head completely . 2. Lay the 20'' x 24'' (508mm x 610mm) cooking sheet on the griddle plate with 20'' (508mm) dimension front to back.
6 V SER VICE DIAGNOSIS A properly adjusted Keating T op-Side ™ Cooker , with no load, will cycle “ON” approximately every 5 1 / 2 to 6 1 / 2 minutes. Each cycle will last 40 seconds, ensuring that the temperature setting is held within a narrow range.
T emperature (°F) Resistance (Ohm) 95 0.30 100 3.80 125 4.60 150 5.50 175 6.40 200 7.90 225 8.40 250 9.70 275 10.90 300 12.40 325 13.80 350 15.10 375 17.00 400 18.40 425 20.20 450 21.30 475 23.30 7 TROUBLESHOOTING THE THERMOST A T T emperature reading is incorrect, showing a sensor error , or LOAD LED is switching at the wrong temperature.
8 VI EXPLODED VIEW & P ARTS LIST ORDERING P ARTS Parts may be ordered by p art number by calling 1-800-KEA TING or your local service company . Y ou may also order online at Keating’s p art store, www .keatingofchicago.com. Refer to the Keating T op-Side ™ Cooker Limited W arranty for complete service and ordering information.
TOP-SIDE ™ COOKING HEAD – MANUAL & AUT O-LIFT Figure 6-1 P ART ITEM DESCRIPTION QTY . NUMBER 1 THERMOST A T TEMPERA TURE PROBE KIT 1 016671 2 COOKING HEAD (COMPLETE) 1 1-800-KEA TING 3 STOP CLEVIS PIN, S/S 1 015164 4 SWIVEL BRACKET WIRE SLEEVE (INCL.
10 P ART ITEM DESCRIPTION QTY . NUMBER 1 TOP-SIDE COOKER WELD. AUTO NEW ARM 1 0521 15 2 AUTO TOP SIDE A0-2 ACTUA TOR MTG . 1 053991 3 ACTUA TOR AUTO TOPSIDE COOKER 24V 1 060463 4 TOP-SIDE CONDUIT SUPP.
11 1. Remove the limit switch black plastic cover on the actuator . 2. T urn on the power on unit and push the T1, T2 or T3 button on the timer . The actuator will extend the stroke and lower head. The motor must stop and the stroke should stop extending before it reaches its mechanical stop.
12 TOP-SIDE ™ COOKER CONTROL P ANEL Figure 6-4 P ART ITEM DESCRIPTION QTY . NUMBER 1 THERMOST A T 1 056840 THERMOST A T REPLACEMENT KIT FOR PRE 2005 MODELS 1 057138 2 HI-LIMIT CONTROL 1 01031 1 3 HI.
13 TOP-SIDE ™ COOKER POWER SUPPL Y BOX FOR AUTO-LIFT ACTUA T ORS WITH DIGIT AL TIMER - 120V AC SUPPL Y Figure 6-5 P ART ITEM DESCRIPTION QTY . NUMBER 1 TRANSFORMER STEPDOWN 24V AC 75V A 1 056037 2 R.
14 TOP-SIDE ™ COOKER POWER SUPPL Y BOX FOR AUTO-LIFT ACTUA TORS WITH DIGIT AL TIMER - 240V AC SUPPL Y Figure 6-6 P ART ITEM DESCRIPTION QTY . NUMBER 1 TRANSFORMER STEPDOWN 24V AC 75V A 1 056037 2 RE.
15 VII WIRING DIAGRAM TOP-SIDE ™ COOKER MANUAL LIFT WIRING DIAGRAM Figure 6-7 LIGHTED ROCKER ON/OFF SWITCH GREEN LIGHT ON TOP LIGHTED ROCKER ON/OFF SWITCH GREEN LIGHT ON BOTTOM OR NOTE: ANGLED TERMINALS OF SWITCH ARE AL W A YS TOW ARD CONTROL P ANEL BOTTOM.
16 NOTES: 2. ALL OTHER WIRES ARE 18 AWG. 1. = 12 AWG WIRE. RD - RED GR - GREEN WIRE COLOR CODES: OR - ORANGE WH - WHITE BL - BLACK GY - GRAY BR - BROWN BU - BLUE COMPONENT CODES: CR - CONTACTOR 220/24.
17 TOP-SIDE ™ COOKER AUTO-LIFT WIRING DIAGRAM FOR ELECTRIC GRIDDLE 208 - 240VOL T Figure 6-9.
18 TOP-SIDE ™ COOKER AUTO-LIFT WIRING DIAGRAM FOR ELECTRIC GRIDDLE 480VOL T Figure 6-10.
.
20 SER VICE INFORMA TION If you hav e a service related question call 1-800-KEA TING. Please state the nature of the call; it will ensure speaking with the appropriate person. Hav e your serial and model number av ailable when ordering parts. KEA TING OF CHICA GO, INC.
デバイスKeating Of Chicago 2005の購入後に（又は購入する前であっても）重要なポイントは、説明書をよく読むことです。その単純な理由はいくつかあります：
Keating Of Chicago 2005をまだ購入していないなら、この製品の基本情報を理解する良い機会です。まずは上にある説明書の最初のページをご覧ください。そこにはKeating Of Chicago 2005の技術情報の概要が記載されているはずです。デバイスがあなたのニーズを満たすかどうかは、ここで確認しましょう。Keating Of Chicago 2005の取扱説明書の次のページをよく読むことにより、製品の全機能やその取り扱いに関する情報を知ることができます。Keating Of Chicago 2005で得られた情報は、きっとあなたの購入の決断を手助けしてくれることでしょう。
Keating Of Chicago 2005を既にお持ちだが、まだ読んでいない場合は、上記の理由によりそれを行うべきです。そうすることにより機能を適切に使用しているか、又はKeating Of Chicago 2005の不適切な取り扱いによりその寿命を短くする危険を犯していないかどうかを知ることができます。
ですが、ユーザガイドが果たす重要な役割の一つは、Keating Of Chicago 2005に関する問題の解決を支援することです。そこにはほとんどの場合、トラブルシューティング、すなわちKeating Of Chicago 2005デバイスで最もよく起こりうる故障・不良とそれらの対処法についてのアドバイスを見つけることができるはずです。たとえ問題を解決できなかった場合でも、説明書にはカスタマー・サービスセンター又は最寄りのサービスセンターへの問い合わせ先等、次の対処法についての指示があるはずです。
