Lincolnメーカー1100-000-A SERIES (SN 2038615 & BELOW)の使用説明書/サービス説明書
ページ先へ移動 of 36
1100advexport REV 1/5/07 SER VICE MA NUAL (INTERN A TIO NAL) IMPING ER COUNTERTOP O VEN MODEL 1100-000-A SERIES (SN 2038615 & BELOW) SERVICE MANUAL Lincoln Foo dservi ce Prod ucts, LLC 1111 North Hadley Road Fort W ayne, Indiana 46804 United States of America Phone : (800) 374 -3004 U.
Impinger II – 1100-000-A Series (SN 2038615 & B elow) Servic e Manual –In t’l 2 SEQUENCE OF OPERATIONS (For seria l numbers before 2038616 w/ ana log control) MODEL 1154 -000-EA NAT. GAS 230 VAC 50 HZ. 1 PHASE MODEL 1155 -000-EA LP GAS 230 VAC 50 HZ.
Impinger II – 1100-000-A Series (SN 2038615 & B elow) Servic e Manual –In t’l 3 SEQUENCE OF OPERATIONS MODEL 1164 -000-EA 400/230 VA C 50 HZ. 3 PHASE POW ER SUPPLY Electrical po wer to be sup plied to the o ven by a four conductor ser vice. Brown conduc tor is Hot.
Impinger II – 1100-000-A Series (SN 2038615 & B elow) Servic e Manual –In t’l 4 SCHEMATI C DIAGRAM MODEL 1154 -000-EA, 1155-000-EA.
Impinger II – 1100-000-A Series (SN 2038615 & B elow) Servic e Manual –In t’l 5 SCHEMATI C DIAGRAM MODEL 1164 -000-EA.
Impinger II – 1100-000-A Series (SN 2038615 & B elow) Servic e Manual –In t’l 6 TROUBLESHO OTING GUIDE GAS OVENS 1154-000 -EA NAT. GAS 230VAC 50 HZ.
Impinger II – 1100-000-A Series (SN 2038615 & B elow) Servic e Manual –In t’l 7 Air pressure s witch Check air switch term inals for suppl y voltage t o term inals NO 2 and CO M. If voltage is pr esent on one side o nly, check for air tube b lockage or mis alignment.
Impinger II – 1100-000-A Series (SN 2038615 & B elow) Servic e Manual –In t’l 8 Flame s ensor To check for flame s ensor operation, c onnect a digital m ultimeter (capabl e of meas uring DC microam ps) between th e flame sens or wire and term inal #1 on the ignition control.
Impinger II – 1100-000-A Series (SN 2038615 & B elow) Servic e Manual –In t’l 9 most of the problems listed under “O ven will not heat” can cause inter mittent failure. Power supp ly Check incoming power su ppl y , If no volta ge is present, ch eck circ uit breakers.
Impinger II – 1100-000-A Series (SN 2038615 & B elow) Servic e Manual –In t’l 10 Speed adjus tment potentiom eter This is a 0 to 10K ohm , 1 turn potentiom eter. W ith power off, remove th e black and white pot. leads f rom the m otor control board at term inals P1 and P2.
Impinger II – 1100-000-A Series (SN 2038615 & B elow) Servic e Manual –In t’l 11 temper ature display. TROUBLESHO OTING GUIDE ELECTRIC OV ENS MODEL 1164 -000-EA 400/230 VA C 50 HZ. 3 PHASE REFER TO PRO PER SCHEMATIC FO R IDENTIFIED COMPONENTS SYMPTO M POSSIBLE CAUSE EVALUAT ION Incom ing power suppl y Check circuit breakers .
Impinger II – 1100-000-A Series (SN 2038615 & B elow) Servic e Manual –In t’l 12 Main fan m otor Check for main fan operati on. If fan is n ot operating, ref er to "Oven f an will not run" . Air pressure s witch This norm ally open switc h should close when the main f an is activated.
Impinger II – 1100-000-A Series (SN 2038615 & B elow) Servic e Manual –In t’l 13 under “O ven will not hea t” can cause intermittent f ailure. Power supp ly Check incoming power su ppl y , If no volta ge is present, ch eck circ uit breakers.
Impinger II – 1100-000-A Series (SN 2038615 & B elow) Servic e Manual –In t’l 14 Speed adjus tment potentiom eter This is a 0 to 10K ohm , 1 turn potentiom eter. W ith power off, remove th e black and white pot. leads f rom the m otor control board at term inals P1 and P2.
Impinger II – 1100-000-A Series (SN 2038615 & B elow) Servic e Manual –In t’l 15 temper ature display. REMOVAL, INSTALLATION AND ADJUST MENT INTERNAT IONAL IMPING ER II ADVANT AGE CAUTION ! BEFORE REM OVING O R INST A LLING ANY COM PONENT IN T HE IMPINGER OVEN, BE SUR E TO DISC ONNECT ELECTRIC AL POWER AND GAS SUP PLY.
Impinger II – 1100-000-A Series (SN 2038615 & B elow) Servic e Manual –In t’l 16 FUSE HOLD ER – REPL ACEMENT A. Shut of f power at m ain break er. B. Rem ove control pa nel top and f ront cover. C. Rem ove wires from fuse holder and m ark for reassem bly .
Impinger II – 1100-000-A Series (SN 2038615 & B elow) Servic e Manual –In t’l 17 THERMOC OUPLE – RE PLACEMENT A. Shut of f power at m ain break er. B. Rem ove control pa nel top and f ront cover. C. Rem ove conve yor and bottom finger assem bly.
Impinger II – 1100-000-A Series (SN 2038615 & B elow) Servic e Manual –In t’l 18 ELECTR ONIC TEMPERAT URE CONT ROL – CALIBR ATION . Place the therm ocouple of your test m eter through a fi nger hole in th e top center of the oven.
Impinger II – 1100-000-A Series (SN 2038615 & B elow) Servic e Manual –In t’l 19 BYPASS OR IFICE – RE PLACEMENT . Shut off power at main bre aker. . Shut off gas supply to o ven. . Rem ove control panel to p and front cov er. . Rem ove pilot tube from bypass orif ice and rem ove orifice.
Impinger II – 1100-000-A Series (SN 2038615 & B elow) Servic e Manual –In t’l 20 BURNER ALARM – REP LACEMENT . Shut off power at main bre aker. . Rem ove control panel to p and front cov er. . Rem ove two wires from burner alarm and mark for reassem bly.
Impinger II – 1100-000-A Series (SN 2038615 & B elow) Servic e Manual –In t’l 21 . Rem ove fan shroud. . Rem ove heating elem ent(s) from oven back. . Reassem ble in reverse or der and chec k s y stem opera tion. Appl y anti-seize com pound to al l mounting bolts on elem ents and back bolts.
Impinger II – 1100-000-A Series (SN 2038615 & B elow) Servic e Manual –In t’l 22 HALL EFF ECT SENSOR – REPLACEMENT . Shut off power at main bre aker. . Rem ove control panel to p and front cov er. . Rem ove conveyor m otor assembl y (see “CON VEYOR D RIVE MOTO R”).
Impinger II – 1100-000-A Series (SN 2038615 & B elow) Servic e Manual –In t’l 23 This page in tentionally left blank..
Impinger II – 1100-000-A Series (SN 2038615 & B elow) Servic e Manual –In t’l 24 GENERAL VIEW IMPINGER II ADVANTAGE LETT ER PART NUM BER DESCRIPTION A 369390 C aster, 4” with m ounting pla.
Impinger II – 1100-000-A Series (SN 2038615 & B elow) Servic e Manual –In t’l 25.
Impinger II – 1100-000-A Series (SN 2038615 & B elow) Servic e Manual –In t’l 26 CONTROL BOX V IE W IMPINGER II ADVANTAGE MODELS 115 4-000-EA, 1155-000-EA LETT ER PART NUM BER DESCRIPT ION A.
Impinger II – 1100-000-A Series (SN 2038615 & B elow) Servic e Manual –In t’l 27.
Impinger II – 1100-000-A Series (SN 2038615 & B elow) Servic e Manual –In t’l 28 CONTROL BOX V IE W IMPINGER II ADVANTAGE MODEL 1164 -000-EA LETT ER PART NUMBER DESCRIPTION A 370108 Control .
Impinger II – 1100-000-A Series (SN 2038615 & B elow) Servic e Manual –In t’l 29.
Impinger II – 1100-000-A Series (SN 2038615 & B elow) Servic e Manual –In t’l 30 CONVEYOR/DOOR V IE W IMPINGER II ADVANTAGE LETT ER PART NUM BER DESCRIPT ION A 369611 Coupler B 369664 Coupli.
Impinger II – 1100-000-A Series (SN 2038615 & B elow) Servic e Manual –In t’l 31.
Impinger II – 1100-000-A Series (SN 2038615 & B elow) Servic e Manual –In t’l 32 OVEN BA CK VIE W IMPINGER II ADVANTAGE LETT ER PART N UMBER DESCRIPTION A 369182 Fan B 369899 Fan shr oud C 369655 Stand-off D 370164 Heating elem ent, 230 volt E 369549 Rear wall F 369581 Motor m ount G 369196 Motor, 240 volt, 50H z.
Impinger II – 1100-000-A Series (SN 2038615 & B elow) Servic e Manual –In t’l 33.
Impinger II – 1100-000-A Series (SN 2038615 & B elow) Servic e Manual –In t’l 34 This page in tentionally left blank..
Impinger II – 1100-000-A Series (SN 2038615 & B elow) Servic e Manual –In t’l 35 This page in tentionally left blank..
Impinger II – 1100-000-A Series (SN 2038615 & B elow) Servic e Manual –In t’l 36.
デバイスLincoln 1100-000-A SERIES (SN 2038615 & BELOW)の購入後に（又は購入する前であっても）重要なポイントは、説明書をよく読むことです。その単純な理由はいくつかあります：
Lincoln 1100-000-A SERIES (SN 2038615 & BELOW)をまだ購入していないなら、この製品の基本情報を理解する良い機会です。まずは上にある説明書の最初のページをご覧ください。そこにはLincoln 1100-000-A SERIES (SN 2038615 & BELOW)の技術情報の概要が記載されているはずです。デバイスがあなたのニーズを満たすかどうかは、ここで確認しましょう。Lincoln 1100-000-A SERIES (SN 2038615 & BELOW)の取扱説明書の次のページをよく読むことにより、製品の全機能やその取り扱いに関する情報を知ることができます。Lincoln 1100-000-A SERIES (SN 2038615 & BELOW)で得られた情報は、きっとあなたの購入の決断を手助けしてくれることでしょう。
Lincoln 1100-000-A SERIES (SN 2038615 & BELOW)を既にお持ちだが、まだ読んでいない場合は、上記の理由によりそれを行うべきです。そうすることにより機能を適切に使用しているか、又はLincoln 1100-000-A SERIES (SN 2038615 & BELOW)の不適切な取り扱いによりその寿命を短くする危険を犯していないかどうかを知ることができます。
ですが、ユーザガイドが果たす重要な役割の一つは、Lincoln 1100-000-A SERIES (SN 2038615 & BELOW)に関する問題の解決を支援することです。そこにはほとんどの場合、トラブルシューティング、すなわちLincoln 1100-000-A SERIES (SN 2038615 & BELOW)デバイスで最もよく起こりうる故障・不良とそれらの対処法についてのアドバイスを見つけることができるはずです。たとえ問題を解決できなかった場合でも、説明書にはカスタマー・サービスセンター又は最寄りのサービスセンターへの問い合わせ先等、次の対処法についての指示があるはずです。
