MakitaメーカーBPT351の使用説明書/サービス説明書
ページ先へ移動 of 15
Models No. Description C ONCEPT AND MAIN APPLICATIONS S pecification S tandard equipment O ptional accessories P 1/ 1 5 Note: The standard equipment for the tool shown above may vary by country. BPT351 (LXTP01* 1 ) Cordless Pin Nailer Model BPT351 has been developed as a 18V Cordless Pin Nailer with more working capacity than that of 14.
[1] NECESSARY REPAIRING TOOLS 783201-2 1R228 1R268 Hex. wrench 3 (standard equipment) 1/4" Hex. shank bit for M4 Spring pin extractor M3 screwing / unscrewing Hex socket head bolt and M3x4 Pan head screw 1R266 Spring pin extractor M2 1R254 Torque wrench shaft 2-6N.
[3] DISASSEMBLY/ASSEMBLY [3] -1. Replacing Driver Front cover (1) Remove four Bind PT3x16 Tapping screws and Front cover. ( Fig. 2 ) (2) Remove Upper plate as drawn in Fig. 3 . (3) Remove Pin 4 for connecting Driver and Hammer. ( Fig. 4 ) (4) Remove Driver as drawn in Fig.
[3] DISASSEMBLY/ASSEMBLY [3] -2. Replacing Switch, LED circuit and Terminal (1) Do the steps (1), (2), (3) and (4) of the previous page. (2) Insert Battery and pull the trigger to locate Hammer at lowest position to release tension of Compression spring 17.
[3] DISASSEMBLY/ASSEMBLY [3] -4. Trigger Section DISASSEMBLING DISASSEMBLING (1) Remove Front cover and Housing R. ( Fig. 2 and Fig. 9 ) (2) Remove the parts around trigger section in the following order. ( Fig. 13 ) 1. Safety trigger 2. Light switch arm 3.
[3] DISASSEMBLY/ASSEMBLY [3] -5. Spring Section (cont.) Guide bolt Wrench 8 M6 Hex nut Holder Flat washer 6 Rail Guide bolt Cushion Cushion Cushion is fit into the groove of Guide bolt firmly. Therefore, twist Cushion to pull it off from the groove. Turn compression spring 17 counterclockwise while holding Spring holder with gloved hands.
[3] DISASSEMBLY/ASSEMBLY [3] -6. Spring section (cont.) ASSEMBLING Hook portion of Hammer Hook portion of Hammer Flat washer 4 Bind PT3x16 Tapping screw Bind PT3x16 Tapping screw Spring section Spring section Roller portion of Spur gear 55 (1) Take the reverse steps of the disassembling procedure for Spring section.
ASSEMBLING [3] DISASSEMBLY/ASSEMBLY [3] -5. Motor and Gear Section R epair P 8 / 1 5 (1) Assemble Cam block section to Spur gear 55 complete. ( Fig. 26 ) Usually, there is no need to disassemble Cam block section for repair. Note: Put Makita grease N No.
P 9 / 1 5 R epair [3] DISASSEMBLY/ASSEMBLY [3] -6. Switch Mechanism ASSEMBLING Fig. 33 Fig. 34 Fig. 35 Fig. 36 Fig. 37 Trigger Trigger (1) Insert Guide plate and Compression spring 4 into Trigger. ( Fig. 32 ) (2) Hook the short end of Torsion spring 3 with Swing arm, and then insert the Torsion spring 3 into Swing arm.
P 1 0 / 1 5 R epair [3] DISASSEMBLY/ASSEMBLY [3] -6. Switch Mechanism (cont.) ASSEMBLING Fig. 38 Fig. 39 Fig. 43 Fig. 41 Fig. 42 Fig. 40 (7) Insert the remaining two Pins 2.5 firmly into Housing set L until they stop as drawn in Fig. 38 . (8) Install Link plate to Housing L with Pin 3 through Link plate.
[3] DISASSEMBLY/ASSEMBLY [3] -7. Magazine P 1 1 / 1 5 R epair DISASSEMBLING M4x6 Hex socket head bolt Fig. 44 Fig. 46 Fig. 45 Fig. 47 Fig. 48 Fig. 49 (1) Loosen M4x6 Hex socket head bolt three turns, then pull out Upper rail section from Magazine . ( Fig.
[3] DISASSEMBLY/ASSEMBLY [3] -7. Magazine (cont.) P 1 2 / 1 5 R epair Points of ASSEMBLING Fig. 52 Fig. 50 Fig. 51 Lever Upper rail complete Slide door cap • Be sure to check that Nail stoppers work properly as drawn in Figs.
[3] DISASSEMBLY/ASSEMBLY [3] -8. Fastening Torque Driver guide cover 27 Driver guide 29 12 51 Magazine Lower rail Spacer 57 Lock arm Pin 5 Item No. Description Fastening Torque 29 2.5 N.m 27 4.0 N.m 51 Hex socket head bolt M3x10 for assembling Magazine and Lower rail 1.
W iring diagram Housing L side Flag connector Flag connector with lead wires (black) has to be connected to - Terminal so that the lead wires pass over the mark of - poles. Flag connector with lead wires (orange) has to connected to + Terminal so that the lead wires face the opposite side against the mark of + poles.
Switch put under ON-OFF Switch (for Upper dead point detection) Boss A Lead wire (black) for connecting ON-OFF switch and Upper dead point detection switch Lead wire holder A Lead wire holder A Guide Lead wire (red) of Upper dead point detection switch to DC motor while passing the wire between boss A and lead wire holder A .
デバイスMakita BPT351の購入後に(又は購入する前であっても)重要なポイントは、説明書をよく読むことです。その単純な理由はいくつかあります:
Makita BPT351をまだ購入していないなら、この製品の基本情報を理解する良い機会です。まずは上にある説明書の最初のページをご覧ください。そこにはMakita BPT351の技術情報の概要が記載されているはずです。デバイスがあなたのニーズを満たすかどうかは、ここで確認しましょう。Makita BPT351の取扱説明書の次のページをよく読むことにより、製品の全機能やその取り扱いに関する情報を知ることができます。Makita BPT351で得られた情報は、きっとあなたの購入の決断を手助けしてくれることでしょう。
Makita BPT351を既にお持ちだが、まだ読んでいない場合は、上記の理由によりそれを行うべきです。そうすることにより機能を適切に使用しているか、又はMakita BPT351の不適切な取り扱いによりその寿命を短くする危険を犯していないかどうかを知ることができます。
ですが、ユーザガイドが果たす重要な役割の一つは、Makita BPT351に関する問題の解決を支援することです。そこにはほとんどの場合、トラブルシューティング、すなわちMakita BPT351デバイスで最もよく起こりうる故障・不良とそれらの対処法についてのアドバイスを見つけることができるはずです。たとえ問題を解決できなかった場合でも、説明書にはカスタマー・サービスセンター又は最寄りのサービスセンターへの問い合わせ先等、次の対処法についての指示があるはずです。