APW WyottメーカーM Seriesの使用説明書/サービス説明書
ページ先へ移動 of 20
Phone: +1 (214) 421-7366 Fax: +1 (214) 565-0976 T oll Free: +1 (800) 527-2100 Website: www .apwwyott.com E-mail: info@apwwyott.com INST ALLA TION AND OPERA TING INSTRUCTIONS INTENDED FOR OTHER THAN HO.
T ABLE OF CONTENTS GENERAL INFORMA TION AND TROUBLESHOOTING 2 M SERIES - DIAGONAL CONT ACT CONVEYOR TOASTERS 3-9 Electrical Specifications 3 Installation 3 Location 6 Operating Instructions 6 Field Ad.
Model Stock Dimensions* Electrical Productivity Weight Number Number Halves/Hour Net/Ship 83501 120V -1600W-13.3A Up to 1600 M-83 83502 20"H x 24 5/8"W x 12"D 208V -1600W-7.7A “ “ 83/93 Ibs 83504 50.8 cm x 62.6 cm x 30.5 cm 230V -1470W-6.
4 2. ASSEMBL Y (REFER TO ILLUSTRA TIONS ABOVE) a) Lay the toaster on its side and install the four Adjustable Legs (Item 1) in threaded holes in base. T ighten legs with crescent wrench. The unit may be leveled by unscrewing the lower insert of each leg.
c) Remove T op Front Panel (Item 4A) by gripping rear edge and lifting up. The Bottom Front Panel (Item 4B) can then be removed by holding the top edge with one hand and the bottom edge with the other hand, then lifting panel up. d) Cut and remove the nylon tie securing the conveyor .
6 LOCA TION . 1. Place the toaster on a flat surface and in such a way that the unit's vents are not blocked. Air must circulate under and through the vents provided on the base, right side (M-83, M83D, & M-95), left side (M-91) and rear of the unit.
7 C. PRODUCTION T o Grill Buns - the following is the basic procedure to operate the bun toaster . Fig. 1. Heat toaster oil to melting point and fill the butter roller tray 2/3 full. Fig. 2. T urn "Main" power switch to "on." Turn motor switch "on"; the butter roller and conveyor will start.
8 M-91: Push Butter Roller shaft to the right to disengage the notched end of the shaft from the drive motor and remove. T o facilitate cleaning, the shaft assembly may be separated from the Butter Roller cylinder . Hold cylinder securely with one hand and slide the shaft out with the other hand.
9 a. Set Thermostat at 4000 or number 8 and allow a full 20 minutes for warm-up. b. Coconut oil is the recommended oil. Use of other oils will prove to be unsatisfactory . c. Sun surface should have even application of oil. d. Use fresher bread. Get better cutting from baker .
A T -10, A T -30, A T -10BT , A T -5, A T -200 SPECIFICA TIONS PLEASE READ P AGE 2 - "GENERAL INFORMA TION," BEFORE YOU CONTINUE. Electrical Information - Models A T -10 & A T -30: Each unit is equipped with a 4 foot (122 cm), 3 wire grounded power cord which terminates with a standard 3 prong plug.
Electrical information - A T -200 Each toaster is equipped with a 4 foot (122 cm), 3 wire grounded power supply cord which terminates with a 3 prong plug (6-50P).
12 C. INST ALLA TION 1. Place the toaster on a flat surface and in such a way that the unit's vents are not blocked. Air must circulate under and through vent provided on the base, left side and at the rear of the unit. A minimum clearance of one inch (1", 2.
13 OPERA TING INSTRUCTIONS A. PREP ARA TlON/W ARM-UP: 1. Main Power: T urn toaster on by pressing the Main Power switch up. T urn the toaster of f by pressing the Main Power switch down. 2. T emperature: Set the T op Heat knob and the Bottom Heat knob to the 6 setting (mid range) for warm-up.
14 SPECIFICA TIONS PLEASE READ P AGE 2 - "GENERAL INFORMA TION," BEFORE YOU CONTINUE. Electrical Information - Models BT -15 . Each unit is equipped with a 4 foot (122 cm), 3 wire grounded power cord which terminates with a standard 3 prong plug.
15 B. ASSEMBL Y 1. Lay the toast on its side and install four adjustable legs into threaded holes in base. T ighten legs with crescent wrench. The unit may be leveled by unscrewing the lower insert of each leg. Precise leveling is not required for proper operation of the toaster .
b) T emperature: TOP HEA T - The MIN. setting will help produce the lightest top-toast. The MAX. Setting will help produce the lightest toast. BOTTOM HEA T - The MIN. setting will help produce the lightest bottom- toast. The MAX. setting will help produce the darkest bottom-toast.
IMPORT ANT FOR FUTURE REFERENCE Please complete this information and retain this manual for the life of the equipment. For W arranty Service and/or Parts, this information is required.
Notes: 18.
19 APW WYOTT EQUIPMENT LIMITED W ARRANTY APW W yott Foodservice Equipment Company warrants it's equipment against defects in materials and workmanship, subject to the following conditions: This warranty applies to the original owner only and is not assignable.
20 APW WYOTT 729 Third Avenue Dallas, TX 75226 Phone: +1 (214) 421-7366 Fax: +1 (214) 565-0976 T oll Free: +1 (800) 527-2100 Website: www .apwwyott.com E-mail: info@apwwyott.
デバイスAPW Wyott M Seriesの購入後に（又は購入する前であっても）重要なポイントは、説明書をよく読むことです。その単純な理由はいくつかあります：
APW Wyott M Seriesをまだ購入していないなら、この製品の基本情報を理解する良い機会です。まずは上にある説明書の最初のページをご覧ください。そこにはAPW Wyott M Seriesの技術情報の概要が記載されているはずです。デバイスがあなたのニーズを満たすかどうかは、ここで確認しましょう。APW Wyott M Seriesの取扱説明書の次のページをよく読むことにより、製品の全機能やその取り扱いに関する情報を知ることができます。APW Wyott M Seriesで得られた情報は、きっとあなたの購入の決断を手助けしてくれることでしょう。
APW Wyott M Seriesを既にお持ちだが、まだ読んでいない場合は、上記の理由によりそれを行うべきです。そうすることにより機能を適切に使用しているか、又はAPW Wyott M Seriesの不適切な取り扱いによりその寿命を短くする危険を犯していないかどうかを知ることができます。
ですが、ユーザガイドが果たす重要な役割の一つは、APW Wyott M Seriesに関する問題の解決を支援することです。そこにはほとんどの場合、トラブルシューティング、すなわちAPW Wyott M Seriesデバイスで最もよく起こりうる故障・不良とそれらの対処法についてのアドバイスを見つけることができるはずです。たとえ問題を解決できなかった場合でも、説明書にはカスタマー・サービスセンター又は最寄りのサービスセンターへの問い合わせ先等、次の対処法についての指示があるはずです。
