MultiquipメーカーDCA-15SPXU4の使用説明書/サービス説明書
ページ先へ移動 of 46
P AR TS AND OPERA TION MANUAL OPERA TION MANUAL Re vision #0 (03/31/11) THIS MANU AL MUST A CCOMP ANY THE EQUIPMENT A T ALL TIMES. WHISPER W A TT TM SERIES MODEL DCA-15SPXU4 60 Hz GENERA TOR.
P A GE 2 — DCA-15SPXU4— OPERA TION MANU AL — REV . #0 (03/31/11) Diesel engine exhaust and some of PR OPOSITION 65 W ARNING.
DCA-15SPXU4— OPERATION MANUAL — REV. #0 (03/31/11) — PAGE 3 1 NO TE P A GE.
P A GE 4 — DCA-15SPXU4— OPERA TION MANU AL — REV . #0 (03/31/11) T ABLE OF CONTENTS NO TE MQ POWER DCA-15SPXU4 MQ POWER DCA-15SPXU4 MQ POWER DCA-15SPXU4 MQ POWER DCA-15SPXU4 MQ POWER DCA-15SPXU4.
DCA-15SPXU4— OPERATION MANUAL — REV. #0 (03/31/11) — PAGE 5 1 NO TE P A GE.
P A GE 6 — DCA-15SPXU4— OPERA TION MANU AL — REV . #0 (03/31/11) DCA-15SPXU4 — SPECIFICA TIONS T able 1. Generator Specifications Model DCA-15SPXU4 Ty p e Re volving field, self v entilated, open protected type synchronous generator Phase Single Phase 3-Wire Standby Output 16.
DCA-15SPXU4— OPERATION MANUAL — REV. #0 (03/31/11) — PAGE 7 1 DCA-15SPXU4 — DIMENSIONS (T OP , SIDE AND FRONT) Figure 1. Dimensions WHISPERW A TT 15 MQPOWER FRONT VIEW F E D TOP VIEW SIDE VIEW Denyo B C A U N V T ABLE 3. DIMENSIONS Refere nce Letter Dimension in.
P A GE 8 — DCA-15SPXU4— OPERA TION MANU AL — REV . #0 (03/31/11) This Owner's Manual has been developed to provide complete instructions for the safe and efficient operation of the MQ P ow er Model DCA-15SPXU4 Whisperwatt™ Generator .
DCA-15SPXU4— OPERATION MANUAL — REV. #0 (03/31/11) — PAGE 9 1 DCA-15SPXU4 — SAFETY MESSA GE ALERT SYMBOLS AL W A YS place the engine ON/OFF switch ( MPEC ) in the OFF/RESET position when the generator is not in use. AL W A YS wear approv ed respiratory protection.
P A GE 10 — DCA-15SPXU4— OPERA TION MANU AL — REV . #0 (03/31/11) DCA-15SPXU4 — R ULES FOR SAFE OPERA TION The following safety guidelines should always be used when operating the DCA-15SPXU4 Whisperwatt™ A C Generator . General Safety: ■ DO NO T operate or ser vice this equipment before reading this entire manual.
DCA-15SPXU4— OPERATION MANUAL — REV. #0 (03/31/11) — PAGE 11 1 DCA-15SPXU4 — R ULES FOR SAFE OPERA TION ■ AL W A YS be sure the operator is familiar with proper saf ety precautions and operation techniques before using generators. ■ NEVER leave the generator unattended, turn off engine when unattended.
P A GE 12 — DCA-15SPXU4— OPERA TION MANU AL — REV . #0 (03/31/11) DCA-15SPXU4 — R ULES FOR SAFE OPERA TION Battery Safety Use the following guidelines when handling the battery: ■ The battery contains acids that can cause injur y to the ey es and skin.
DCA-15SPXU4— OPERATION MANUAL — REV. #0 (03/31/11) — PAGE 13 1 DCA-15SPXU4 — R ULES FOR SAFE OPERA TION Backfeed to a utility system can cause electrocution and or property damage. NEVER connect the generators to a building's electrical system without a transfer switch or other approved device.
P A GE 14 — DCA-15SPXU4— OPERA TION MANU AL — REV . #0 (03/31/11) Check with your local county or state safety towing regulations, in addition to meeting Department of T ranspor tation ( DO T ) Safety T o wing Regulations , bef ore towing your gener ator .
DCA-15SPXU4— OPERATION MANUAL — REV. #0 (03/31/11) — PAGE 15 1 NO TE P A GE.
P A GE 16 — DCA-15SPXU4— OPERA TION MANU AL — REV . #0 (03/31/11) Figure 2. T ypical Generator Grounding Application DCA-15SPXU4 — INST ALLA TION.
DCA-15SPXU4— OPERATION MANUAL — REV. #0 (03/31/11) — PAGE 17 1 Outdoor Installation Install the generator in a area that is free of debris, bystanders, and overhead obstructions. Make sure the generator is on secure level ground so that it cannot slide or shift around.
P A GE 18 — DCA-15SPXU4— OPERA TION MANU AL — REV . #0 (03/31/11) DCA-15SPXU4 — GENERAL INFORMA TION DCA-15SPXU4 Whisperwatt™ Series Familiarization Generator This MQ P ow er generator is a .
DCA-15SPXU4— OPERATION MANUAL — REV. #0 (03/31/11) — PAGE 19 1 DCA-15SPXU4 — MAJOR COMPONENTS Figure 3. Major Components 4 e l b a T. s t n e n o p m o C r o j a M r o t a r e n e G .
P A GE 20 — DCA-15SPXU4— OPERA TION MANU AL — REV . #0 (03/31/11) Figure 4. Generator Control Panel DCA-15SPXU4 — GENERA T OR CONTROL P ANEL U N V 14 A V HZ WATER TEMP.
DCA-15SPXU4— OPERATION MANUAL — REV. #0 (03/31/11) — PAGE 21 1 The definitions below describe the controls and functions of the Generator Control Panel (Figure 4). 1. Frequency Meter – Indicates the output frequency in her tz (Hz). Nor mally 60 Hz.
P A GE 22 — DCA-15SPXU4— OPERA TION MANU AL — REV . #0 (03/31/11) Output T erminal Familiarization The “ Output T erminal P anel ” (Figure 5) is provided with the following: ■ ■ ■ ■ .
DCA-15SPXU4— OPERATION MANUAL — REV. #0 (03/31/11) — PAGE 23 1 120 V A C GFCI Receptac le This120 V AC , 20 amp GFCI (Duplex Nema 5-20R) receptacle can be used anytime the generator is in operation. Remember the load output (current) of the GFCI receptacle is dependent on the load requirements of the U , N, and V output ter minal lugs.
P A GE 24 — DCA-15SPXU4— OPERA TION MANU AL — REV . #0 (03/31/11) Figure 11. Connecting Loads Connecting Loads Loads can be connected to the generator by the Ouput T erminal Lugs or the con venience receptacles (Figure 11). Make sure to read the operation manual before attempting to connect a load to the generator .
DCA-15SPXU4— OPERATION MANUAL — REV. #0 (03/31/11) — PAGE 25 1 DCA-15SPXU4 — LO AD APPLICA TION/MAXIMUM AMPERA GE Single Phase Load Always be sure to check the nameplate on the generator and e.
P A GE 26 — DCA-15SPXU4— OPERA TION MANU AL — REV . #0 (03/31/11) DCA-15SPXU4 — GA UGE READING/ TERMINAL P ANEL CONNECTIONS UNV T erminal Output V oltages 240/120V output voltages can be obtained using the Output T erminal Lugs . Use the voltage regulator (VR) to either in- crease or decrease the selected voltage.
DCA-15SPXU4— OPERATION MANUAL — REV. #0 (03/31/11) — PAGE 27 1 DCA-15SPXU4 — SETUP Figure 17. Engine Oil Dipstick When checking the engine oil, be sure to check if the oil is clean.
P A GE 28 — DCA-15SPXU4— OPERA TION MANU AL — REV . #0 (03/31/11) DCA-15SPXU4 — SETUP Refueling Procedure: 1. Level T anks – Mak e sure fuel cells are lev el with the ground. F ailure to do so will cause fuel to spill from the tank before reaching full capacity (Figure 19).
DCA-15SPXU4— OPERATION MANUAL — REV. #0 (03/31/11) — PAGE 29 1 Coolant (Antifreeze/Summer Coolant/W ater) KUBO T A recommends antifreeze/summer coolant f or use in their engines, which can be purchased in concentrate (and mixed with 50% demineralized water) or pre-diluted.
P A GE 30 — DCA-15SPXU4— OPERA TION MANU AL — REV . #0 (03/31/11) DCA-15SPXU4 — SETUP When connecting battery do the following: 1. NEVER connect the battery cables to the battery terminals when the ignition switch is in the ON position 2. Place a small amount of battery terminal treatment compound around both batter y ter minals.
DCA-15SPXU4— OPERATION MANUAL — REV. #0 (03/31/11) — PAGE 31 1 DCA-15SPXU4 — GENERA T OR ST ART -UP PR OCEDURE The engine's exhaust contains harmful emissions. AL W A YS have adequate ventilation when operating . Direct exhaust away from nearby personnel.
P A GE 32 — DCA-15SPXU4— OPERA TION MANU AL — REV . #0 (03/31/11) DCA-15SPXU4 — GENERA T OR ST ART -UP PR OCEDURE Figure 33. V oltage Adjust Control Knob 7. The generator's AC-voltmeter (Figure 32) will display the generator’ s output in VO L T S .
DCA-15SPXU4— OPERATION MANUAL — REV. #0 (03/31/11) — PAGE 33 1 DCA-15SPXU4 — GENERA T OR SHUT -DO WN PROCEDURES NEVER stop the engine suddenly e xcept in an emergency . W ARNING - SHUTTING DO WN THE GENERA T OR Normal Shutdown Procedure T o shutdown the gener ator use the follo wing procedure: 1.
P A GE 34 — DCA-15SPXU4— OPERA TION MANU AL — REV . #0 (03/31/11) DCA-15SPXU4 — MAINTENANCE Service Daily If the engine is operating in very dusty or dry grass conditions, a clogged air cleaner will result. This can lead to a loss of pow er , e xcessiv e carbon buildup in the comb ustion chamber and high fuel consumption.
DCA-15SPXU4— OPERATION MANUAL — REV. #0 (03/31/11) — PAGE 35 1 DCA-15SPXU4 — MAINTENANCE Generator Storage For longe term storage of the generator the following is recommended: Fill the fuel tank completely . T reat with a fuel stabilizer if necessar y .
P A GE 36 — DCA-15SPXU4— OPERA TION MANU AL — REV . #0 (03/31/11) DCA-15SPXU4 — MAINTENANCE T o ensure adequate star ting capability , al ways hav e power applied to the generator's internal battery char g er .
DCA-15SPXU4— OPERATION MANUAL — REV. #0 (03/31/11) — PAGE 37 1 DCA-15SPXU4 — TRAILER MAINTENANCE Hydraulic Surge Brakes Hydraulic surge brakes (Figure 37) should not require any special attention with the exception of routine maintenance such as shoe and lining replacement.
P A GE 38 — DCA-15SPXU4— OPERA TION MANU AL — REV . #0 (03/31/11) Tires/Wheels/Lug Nuts Tires and wheels are a v er y impor tant and critical components of the trailer . When specifying or replacing the trailer wheels it is impor tant the wheels, tires , and axle are properly matched.
DCA-15SPXU4— OPERATION MANUAL — REV. #0 (03/31/11) — PAGE 39 1 NEVER use an pneumatic air gun to tighten wheel lug nuts. Figure 39. Wheel Lug Nuts Tightening Sequence DCA-15SPXU4 — TRAILER MAINTENANCE NOTE Lug Nut T orque Requirements It is e xtremely impor tant to apply and maintain proper wheel mounting torque on the trailer .
P A GE 40 — DCA-15SPXU4— OPERA TION MANU AL — REV . #0 (03/31/11) DCA-15SPXU4 — GENERA T OR WIRING DIA GRAM Figure 40. Generator Wiring Diagram.
DCA-15SPXU4— OPERATION MANUAL — REV. #0 (03/31/11) — PAGE 41 1 DCA-15SPXU4 — ENGINE WIRING DIA GRAM Figure 41. Engine Wiring Diagram.
P A GE 42 — DCA-15SPXU4— OPERA TION MANU AL — REV . #0 (03/31/11) G N I T O O H S E L B U O R T E N I G N E . 6 1 E L B A T M O T P M Y S M E L B O R P E L B I S S O P N O I T U L O S . t r a t s t o n s e o d e n i g n E ? l e u f o N . l e u f h s i n e l p e R ? m e t s y s l e u f e h t n i r i A .
DCA-15SPXU4— OPERATION MANUAL — REV. #0 (03/31/11) — PAGE 43 1 ) D E U N I T N O C ( G N I T O O H S E L B U O R T E N I G N E . 6 1 E L B A T M O T P M Y S M E L B O R P E L B I S S O P N O I T U L O S . h t o o m s t o n s i n o i t u l o v e r e n i g n E ? y t r i d r o d e g g o l c r e t l i f l e u F .
P A GE 44 — DCA-15SPXU4— OPERA TION MANU AL — REV . #0 (03/31/11) Practically all breakdowns can be prevented by proper handling and maintenance inspections, but in the event of a breakdown, use T ab le 17 shown below f or diagnosis of the generator .
DCA-15SPXU4— OPERATION MANUAL — REV. #0 (03/31/11) — PAGE 45 1 DCA-10SPX4 — TR OUBLESHOO TING (PRE-HEA T LAMP CODES) E D O C P M A L S I S O N G A I D E R U L I A F .
P AR TS AND OPERA TION MANUAL OPERA TION MANUAL Y our Local Dealer is: HERE’S HOW TO GET HELP PLEASE HA VE THE MODEL AND SERIAL NUMBER ON-HAND WHEN CALLING UNITED ST A TES Multiquip Corporate Offi ce MQ P ar ts Department 18910 Wilmington A ve . Carson, CA 90746 Contact: mq@multiquip .
デバイスMultiquip DCA-15SPXU4の購入後に（又は購入する前であっても）重要なポイントは、説明書をよく読むことです。その単純な理由はいくつかあります：
Multiquip DCA-15SPXU4をまだ購入していないなら、この製品の基本情報を理解する良い機会です。まずは上にある説明書の最初のページをご覧ください。そこにはMultiquip DCA-15SPXU4の技術情報の概要が記載されているはずです。デバイスがあなたのニーズを満たすかどうかは、ここで確認しましょう。Multiquip DCA-15SPXU4の取扱説明書の次のページをよく読むことにより、製品の全機能やその取り扱いに関する情報を知ることができます。Multiquip DCA-15SPXU4で得られた情報は、きっとあなたの購入の決断を手助けしてくれることでしょう。
Multiquip DCA-15SPXU4を既にお持ちだが、まだ読んでいない場合は、上記の理由によりそれを行うべきです。そうすることにより機能を適切に使用しているか、又はMultiquip DCA-15SPXU4の不適切な取り扱いによりその寿命を短くする危険を犯していないかどうかを知ることができます。
ですが、ユーザガイドが果たす重要な役割の一つは、Multiquip DCA-15SPXU4に関する問題の解決を支援することです。そこにはほとんどの場合、トラブルシューティング、すなわちMultiquip DCA-15SPXU4デバイスで最もよく起こりうる故障・不良とそれらの対処法についてのアドバイスを見つけることができるはずです。たとえ問題を解決できなかった場合でも、説明書にはカスタマー・サービスセンター又は最寄りのサービスセンターへの問い合わせ先等、次の対処法についての指示があるはずです。
