Poulan ProメーカーLAWN TRACTOR PO17H42STAの使用説明書/サービス説明書
ページ先へ移動 of 48
| OWNER'S MANUAL MODEL NO. PO17H42STA 17.0 HP 42 Inch Lawn Tractor Assembly • Operation • Maintenance • Service and Adjustments • Storage • Troubleshooting • Rel)air Parts For Parts and Service, contact our authorized distributor: call 1-800-849-1297 ForTechnical Assistance: call 1-800-829-5886 184217 Rev.
SAFETY RULES ,tl 411 Safe Operation Practices for Ride-On Mowers IMPORTANT: THIS CUTTING MACHINE IS CAPABLE OF AMPUTATING HANDS AND FEET AND THROWING OBJECTS. FAILURE TO OBSERVE THE FOLLOWING SAFETY INSTRUCTIONS COULD RESULTIN SERIOUS INJURYOR DEATH. I.
SAFETY RULES &Safe Operation Practices for Ride-On Mowers & Be sure the area is clear of other people before mowing. Stop machine if anyone enters the area. Never carry passengers or children even with the blades off. Do not mow in reverse unless absolutely necessary.
PRODUCT SPECIFICATIONS GASOLINE CAPACITY AND TYPE: OIL TYPE (API-SF-SJ): OiL CAPACITY: SPARK PLUG: GAP: .030") GROUND SPEED (MPH): FORWARD: 5.2 REVERSE: 2.7 TIRE PRESSURE: FRONT: 14 PSI REAR: 12 PSI ;HARGING SYSTEM: 3 AMPS BATTERY 5 AMPS HEADLIGHTS BATTERY: AMP/HR: 28 MIN, CCA: 230 CASE SIZE: U1R BLADE BOLTTORQUE: 27-35 FT.
UNASSEMBLED PARTS Steering Wheel Steering Boot : Steering Steering Extension Wheel Shaft Insert Steering Wheel L_l Adapter Seat (1) Washer 17/32 x 1-3/16 x 12 Gauge (1) Lock (_ Washer 1/2 (1) Bolt Key.
ASSEMBLY i i Your new tractor has been assembled at the factory with exception of those parts left unassembled for shipping purposes, To ensure safe and proper operation of your tractor all parts and hardware you assemble must be tightened securely. Use the correct tools as necessary to insure proper tightness.
ASSEMBLY HOW TO SET UP YOUR TRACTOR INSTALL SEAT (See Fig. 2) Adjust seat before tightening adjustment bolt. • Remove adiustment bolt, lock washer and flat washer securing seat to cardboard packing and set aside for assembly of seat to tractor. • Pivot seat upward and remove from the cardboard pack- ing.
ASSEMBLY CHECKTIRE PRESSURE The tires on your tractor were overinflated at the factory for shipping purposes. Correct tire pressure is important for best cutting performance. Reduce tire pressure to PSI shown in "PRODUCT SPECIFICATIONS" section of this manual.
OPERATION These symbols may appear on your tractor or in literature supplied with the product. Learn and understand their mean- R N H L I',,I REVERSE NEUTRAL HIGH LOW CHOKE FAST SLOW IGNITION ENG.
OPERATION KNOW YOUR TRACTOR READ THIS OWNER'S MANUAL AND SAFETY RULES BEFORE OPERATING YOUR TRACTOR Compare the illustrations with your tractor to familiarize yourself with the locations of various controls and adjustments. Save this manual for future reference.
OPERATION ,_FETY GLASSES The operation of any tractor can result in foreign objects thrown into the eyes, which can result in severe eye damage. Always wear safety glasses or eye shields while op- erating your tractor or performing any adjustments or repairs.
OPERATION TO OPERATE MOWER (See Fig. 6) Your tractor is equipped with an operator presence sensing switch. Any attempt by the operator to leave the seat with the engine running and the attachment clutch engaged will shut off the engine. Select desired height of cut.
OPERATION ADD GASOLINE • Fill fuel tank to bottom of filler neck. Do not overfill. Use fresh, clean, regular unleaded gasoline with a minimum of 87 octane. (Use of leaded gasoline will increase carbon and lead oxide deposits and reduce valve life). Do not mix oil with gasoline.
OPERATION Move motion control lever to neutral (N) position. Shut- off engine and set parking brake. Engage transmission by placing freewheel control in driving position (See "TO TRANSPORT" in this section of manual). Sitting in the tractor seat, start engine.
MAINTENANCE M A,NTENA.CE SC.EOULE FILL IN DATES _O/_. AS YOU COMPLETE REOU . SE.V.CE OATES C_ kk B;::P ' eOsP:r:;i°n _ I1_ Check Operator Presence and T Interlock Systems V t R Check for Loose F.
MAINTENANCE MANDREL ASSEMBLY TRACTOR Always observe safety rules when performing any main- tenance. BRAKE OPERATION If tractor requires more than six (6) feet stopping distance at high speed in highest gear, then brake must be adjusted. (See"TO ADJUST BRAKE" inthe Service and Adjustments section of this manual).
MAINTENANCE TO CLEAN BATTERY AND TERMINALS Corrosion and dirt on the battery and terminals can cause the battery to "leak" power. Disconnect BLACK battery cable first then RED bat- tery cable and remove battery from tractor. Rinse the battery with plain water and dry.
MAINTENANCE ENGINE COOLING FINS (See Fig. 13) Remove any dust, dirt or oil from engine cooling fins to prevent engine damage from overheating. • Remove screws from blower housing and lift housing and dipstick tube assembly off engine. • Cover oil fill opening to prevent entry of dirt.
SERVICE AND ADJUSTMENTS WARNING: TO AVOID SERIOUS INJURY, BEFORE PERFORMING ANY SERVICE OR ADJUST- MENTS: Depress clutch/brake pedal fully and set parking brake. Place motion control lever in neutral (N) position, Place attachment clutch in "DISENGAGED" position.
SERVICE AND ADJUSTMENTS SIDE-TO-SIDE ADJUSTMENT (See Figs. 17 and 18) • Raise mower to its highest position. • At the midpoint of both sides of mower, measure height from bottom edge of mower to ground. Distance "A" on both sides of mower should be the same or within 1/4" of each other.
SERVICE AND ADJUSTMENTS TO CHECK BRAKE • Park tractor on a level, dry concrete or paved surface, depress clutch/brake pedal all the way down and en- gage parking brake. • Disengage transmission by placing freewhel control in "transmission disengaged" position.
SERVICE AND ADJUSTMENTS MOTION CONTROL , NEUTRAL LEVER _ LOCK GATE FIG. 24 ADJUSTMENT BOLT TRANSMISSION REMOVAL/REPLACEMENT Should your transmission require removal for service or replacement, it should be purged after reinstailation and before operatingthe tractor.
SERVICE AND ADJUSTMENTS • Lift seat pan to raised position. Disconnect BLACK battery cable first then RED battery cable and carefully remove battery from tractor. • Install new battery with terminals in same position as old battery. First connect RED battery cable to positive(+) terminal with hex bolt and keps nut as shown.
STORAGE ENGINE Immediately prepare your tractor for storage at the end of the season or if the tractor will not be used for 30 days or more. WARNING: Never store the tractor with gasoline in the tank inside a building where fumes may reach an open flame or spark.
TROUBLESHOOTING POINTS PROBLEM Will not start Hard to start Engine will not turn over Engine clicks but will not start Loss of power Excessive vibration CAUSE 1. Out of fuel. 2. Engine not "CHOKED" properly. 3. Engine flooded. 4. Bed spark plug.
TROUBLESHOOTING POINTS PROBLEM Engine continues to run when operator leaves seat with attachment clutch engaged Poor cut - uneven Mower blades will not rotate Poor grass discharge Headlight(s) not working (if so equipped) Battery will not charge Loss of drive Engine "backfires" when turning engine "OFF" CAUSE 1.
REPAIR PARTS TRACTOR -- MODEL NUMBER PO17H42STA, PRODUCT NO. 954 56 91-89 SCHEMATIC BATi-ERY /; ? RED ) WHITE G All IGNITION SWITCH FUSE ' I i I '© ' ,O-€--- i I i I t L ....... J CLUTCH / BRAKE (PEDALUP) BL_CK BLACK _J METER (OPTIONAL) i I RED r _ STARTER SOLENOID SEAT SWITCH (NOT OCCUPIED i .
REPAIR PARTS TRACTOR -- MODEL NUMBER PO17H42STA, PRODUCT NO. 954 56 91-89 ELECTRICAL I t 42 41 I I I / I I I 25 / L 48 F i t I I i t t f I _27 29 I I I t 28.
REPAIR PARTS ..... TRACTOR - - MODEL NUMBER PO17H42STA, PRODUCT NO. 954 56 91-89 ELECTRICAL KEY PART NO. NO. DESCRIPTION 1 163465 2 74760412 8 176689 16 176138 21 175685 22 4152J 24 4799J 25 146147 26.
REPAIR PARTS TRACTOR - - MODEL NUMBER PO17H42STA, PRODUCT NO. 954 56 91-89 CHASSIS AND ENCLOSURES 212 30 29 2O8 i 26 31 208 26 26 25 12 54 28 2O6 33 10 14 30 35 34 26.
REPAIR PARTS TRACTOR -- MODEL NUMBER PO17H42STA, PRODUCT NO. 954 56 91-89 CHASSIS AND ENCLOSURES KEY PART NO. NO. DESCRIPTION 1 174619 2 176554 3 17060612 5 155272 9 168336X010 10 72140608 11 174996 1.
REPAIR PARTS TRACTOR-- MODEL NUMBER PO17H42STA, PRODUCT NO. 954 56 91-89 DRIVE 77 32 ' 30 151 27 • 51 62 120_ 36 3O 32 26 16 22 _. 84 2 25 ._ _,_'_ 250 200 250 36 • 53 55 32.
REPAIR PARTS TRACTOR - - MODEL NUMBER PO17H42STA, PRODUCT NO. 954 56 91-89 DRIVE KEY PART KEY PART NO. NO. DESCRIPTION NO. NO. 1 ...... Transaxle Hydro Gear Model 322- 69 142432 0510 70 134683 (Order .
REPAIR PARTS TRACTOR -- MODEL NUMBER PO17H42STA, PRODUCT NO. 954 56 91-89 STEERING ASSEMBLY 34 43.
REPAIR PARTS TRACTOR- - MODEL NUMBER PO17H42STA, PRODUCT NO. 954 56 91-89 STEERING ASSEMBLY KEY PART NO, NO. DESCRIPTION 1 140044X428 2 175131 3 169840 4 169839 5 6266H 6 121748X 7 19272016 8 12000029.
REPAIR PARTS TRACTOR -- MODEL NUMBER PO17H42STA, PRODUCT NO. 954 56 91-89 ENGINE 3 81 13 4 31 40 33 29 _38 1{_//_ 16 78 33 37 OPTIONAL EQUIPMENT Spark Arrester 23 36.
REPAIR PARTS TRACTOR -- MODEL NUMBER PO17H42STA, PRODUCT NO. 954 56 91-89 ENGINE KEY PART NO, NO. DESCRIPTION 1 2 3 170551 17720408 4 137352 13 165291 14 148456 16 11050600 23 169837 29 137180 31 1092.
REPAIR PARTS TRACTOR - - MODEL NUMBER PO17H42STA, PRODUCT NO. 954 56 91-89 SEAT ASSEMBLY KEY NO. 1 2 3 4 5 6 7 8 9 10 12 13 PART NO. 140116 140551 71110616 19131610 145006 73800600 124181X 17000616 19.
REPAIR PARTS TRACTOR -- MODEL NUMBER PO17H42STA, PRODUCT NO. 954 56 91-89 DECALS 9 12 2 5 3 4 10 12 6 16 KEY PART KEY PART NO. NO. DESCRIPTION NO. NO. DESCRIPTION 2 3 4 5 6 7 9 157032 Decal Instructio.
REPAIR PARTS TRACTOR -- MODEL NUMBER PO17H42STA, PRODUCT NO. 954 56 91-89 MOWER LIFT 5 3 13 2 4 6 13 4O.
REPAIR PARTS TRACTOR - - MODEL NUMBER PO17H42STA, PRODUCT NO. 954 56 91-89 MOWER LIFT KEY PART NO, NO. DESCRIPTION 1 159460 Wire Asm Inner/Sprg w/Plunger 2 159471 Shaft Asm Lift 3 105767X Pin Groove 4 12000002 E Ring #5133-62 5 19211621 Washer 21/32 x 1 x 21 Ga.
REPAIR PARTS TRACTOR -- MODEL NUMBER PO17H42STA, PRODUCT NO. 954 56 91-89 MOWER DECK 157 153 154 67 156 _"_ 36 _ _,,_"J'_ K 43 144 ,_45 ,- 37 i.
REPAIR PARTS TRACTOR -- MODEL NUMBER PO17H42STA, PRODUCT NO. 954 56 91-89 MOWER DECK KEY PART KEY PART NO. NO. DESCRIPTION NO. NO. DESCRIPTION 1 165892 2 72140506 3 138017 4 165460 5 4939M 6 178024 8 .
SERVICE NOTES 44.
SERVICE NOTES 45.
LIMITED WARRANTY The Manufacturer warrants to the original consumer purchaser that this product as manufactured is free from defects in materi- als and workmanship.
SUGGESTED GUIDE FOR SIGHTING SLOPES FOR SAFE OPERATION & ONLY RIDE UP AND DOWN HILL, NOT ACROSS HILL 15 DEGREES MAX. WARNING: To avoid serious injury, operate your tractor up and down the face of slopes, never across the face. Do not mow slopes greater than 15 degrees.
Poulan.
デバイスPoulan Pro LAWN TRACTOR PO17H42STAの購入後に（又は購入する前であっても）重要なポイントは、説明書をよく読むことです。その単純な理由はいくつかあります：
Poulan Pro LAWN TRACTOR PO17H42STAをまだ購入していないなら、この製品の基本情報を理解する良い機会です。まずは上にある説明書の最初のページをご覧ください。そこにはPoulan Pro LAWN TRACTOR PO17H42STAの技術情報の概要が記載されているはずです。デバイスがあなたのニーズを満たすかどうかは、ここで確認しましょう。Poulan Pro LAWN TRACTOR PO17H42STAの取扱説明書の次のページをよく読むことにより、製品の全機能やその取り扱いに関する情報を知ることができます。Poulan Pro LAWN TRACTOR PO17H42STAで得られた情報は、きっとあなたの購入の決断を手助けしてくれることでしょう。
Poulan Pro LAWN TRACTOR PO17H42STAを既にお持ちだが、まだ読んでいない場合は、上記の理由によりそれを行うべきです。そうすることにより機能を適切に使用しているか、又はPoulan Pro LAWN TRACTOR PO17H42STAの不適切な取り扱いによりその寿命を短くする危険を犯していないかどうかを知ることができます。
ですが、ユーザガイドが果たす重要な役割の一つは、Poulan Pro LAWN TRACTOR PO17H42STAに関する問題の解決を支援することです。そこにはほとんどの場合、トラブルシューティング、すなわちPoulan Pro LAWN TRACTOR PO17H42STAデバイスで最もよく起こりうる故障・不良とそれらの対処法についてのアドバイスを見つけることができるはずです。たとえ問題を解決できなかった場合でも、説明書にはカスタマー・サービスセンター又は最寄りのサービスセンターへの問い合わせ先等、次の対処法についての指示があるはずです。
