Quadra-FireメーカーMTVERNON-AE-Kの使用説明書/サービス説明書
ページ先へ移動 of 56
R www .quadrare.com 7034-106F August 13, 2009 MT . VERNON PELLET ST OVE ADV ANCED ENERGY (AE) O-T L T ested and Listed by Portland Oregon USA OMNI-T est Laboratories, Inc.
Page 7034-106F August 13, 2009 R Mt. V ernon Pellet Stove (AE) R R Hearth & Home T echnologies welcomes you to our tradi - tion of excellence! In choosing a Quadra-Fire appliance, you have our assurance of commitment to quality , durabil - ity , and performance.
R R R August 13, 2009 7034-106F Page Mt. V ernon Pellet Stove (AE) T ABLE OF CONTENTS Safety Alert Key: • DANGER! Indicates a hazardous situation which, if not avoided will result in death or serious injury . • W ARNING! Indicates a hazardous situation which, if not avoided could result in death or serious injury .
Page 7034-106F August 13, 2009 R Mt. V ernon Pellet Stove (AE) R R 1 Listing and Code Approvals A. Appliance Certication E. BTU & Efciency Specications Model Mt. V ernon Pellet Stove AE Laboratory OMNI T est Laboratories, Inc. Report No.
R R R August 13, 2009 7034-106F Page 5 Mt. V ernon Pellet Stove (AE) 2 Getting Started Marginal Location: • Below peak Location NOT recommended: • Not the highest point of the roof • Wind loadin.
Page 6 7034-106F August 13, 2009 R Mt. V ernon Pellet Stove (AE) R R • Installation and use of any damaged appliance. • Modication of the appliance. • Installation other than as instructed by Hearth & Home T echnologies. • Installation and/or use of any component part not approved by Hearth & Home T echnologies.
R R R August 13, 2009 7034-106F Page 7 Mt. V ernon Pellet Stove (AE) 3 Dimensions and Clearances A. Appliance Dimensions Figure 7.4 - Front View Figure 7.1 - T op View with T op V ent Adapter and 3 to 6 in (76-152mm) Adapter Figure 7.5 - Side View Figure 7.
Page 8 7034-106F August 13, 2009 R Mt. V ernon Pellet Stove (AE) R R Straight Back Against Wall Inches Millimeters A Back W all to Appliance 2 51 B Side W all to Appliance 6 152 Corner Installation In.
R R R August 13, 2009 7034-106F Page 9 Mt. V ernon Pellet Stove (AE) 4 V ent Information A. V enting T ermination Minimum Requirements J or K X V M I H A V G B V V A B V F V C B B E L V D V Ele ctri c.
Page 10 7034-106F August 13, 2009 R Mt. V ernon Pellet Stove (AE) R R B. A voiding Smoke and Odors Negative Pressure, Shut-Down and Electrical Power Failure T o reduce the probability of back-drafting.
R R R August 13, 2009 7034-106F Page 1 1 Mt. V ernon Pellet Stove (AE) Negative pressure results from the imbalance of air available for the appliance to operate properly . It can be strongest in lower levels of the house. Causes include: • Exhaust fans (kitchen, bath, etc.
Page 1 7034-106F August 13, 2009 R Mt. V ernon Pellet Stove (AE) R R E. Chimney and Exhaust Connection 1. Chimney & Connector : Use or inch (76-10mm) diame ter type "L" or "PL" venting system . It can be vented vertically or horizontally .
R R R August 13, 2009 7034-106F Page 1 Mt. V ernon Pellet Stove (AE) G. Pipe Selection Chart Do NOT pack insulation or other combustibles between restops. • AL WA YS maintain specied clearances around venting and restop systems. • Install restops as specied.
Page 1 7034-106F August 13, 2009 R Mt. V ernon Pellet Stove (AE) R R 5 V enting Systems NOTE: • Illustrations reect typical installations and are FOR DESIGN PURPOSES ONL Y . • I llustrations/diagrams are not drawn to scale. • Actual installation may vary due to individual design preference.
R R R August 13, 2009 7034-106F Page 15 Mt. V ernon Pellet Stove (AE) 6 in . (15 mm) Min im u m Non -co mbu stible He arth Pa d W all Thimb le Horiz onta l T e rminatio n Cap in. (51 mm) Minim um 6 in. (15 mm ) Minim um From Glass Straight Out B.
Page 16 7034-106F August 13, 2009 R Mt. V ernon Pellet Stove (AE) R R We recommend a minimum of 60 inches (15mm) vertical, however above the eave is preferred.
R R R August 13, 2009 7034-106F Page 17 Mt. V ernon Pellet Stove (AE) Fire Risk. Inspection of Chimney: • Masonry chimney must be in good condition. • Meets minimum standard of NFP A 1 1 • Factory-built chimney must be a minimum 6 inch (15mm) UL10 HT .
Page 18 7034-106F August 13, 2009 R Mt. V ernon Pellet Stove (AE) R R 6 Mobile Home Installation 1. A n outsi de air inle t must be provi ded for the combu sti on air and must remain clear of leaves, debris, ice and/or snow . It must be unrestricted while the appliance is in use to prevent room air starvation which causes smoke spill age.
R R R August 13, 2009 7034-106F Page 19 Mt. V ernon Pellet Stove (AE) 7 Appliance Set-Up A. Leg Leveling System Figure 19.3 - Bolt fully extended Figure 19.2 Figure 19.1 1. Thre ad Alle n bolts throu gh nuts unt il us h. Figu re 19. 1. The Allen bolts and nuts are included in the component pack inside the appliance rebox.
Page 0 7034-106F August 13, 2009 R Mt. V ernon Pellet Stove (AE) R R 3 to 3 inch (76-76mm) T op V ent Adapter 3 to 6 inch (76-152mm) T op V ent Offset Adapter 1. Put a layer of high temperature silicone on the inch (76mm) exhaust outlet. Do not put silicone inside of pipe.
R R R August 13, 2009 7034-106F Page 1 Mt. V ernon Pellet Stove (AE) E. Optional Log Set Placement Instructions CAUTION Logs are FRAGILE. Use extreme care when handling or cleaning logs. NOTICE: Due to the abrasive nature of a pellet appliance re, the logs are not covered under warranty .
Page 7034-106F August 13, 2009 R Mt. V ernon Pellet Stove (AE) R R 1. When mounting the wall control thermostat on the wall, be sure to follow your thermostat wall control’s instal - lation instructions carefully .
R R R August 13, 2009 7034-106F Page Mt. V ernon Pellet Stove (AE) 8 Operating Instructions A. Fire Safety T o provide reasonable re safety , the following should be given serious consideration: • Install at least one smoke detector and CO monitor on each oor of your home.
Page 7034-106F August 13, 2009 R Mt. V ernon Pellet Stove (AE) R R Size • Pellets are either 1/ inch or 5/16 inch (6-8mm) in diameter • Length should be no more that 1-1/ inches (8.
R R R August 13, 2009 7034-106F Page 5 Mt. V ernon Pellet Stove (AE) 3. Automatic or Manual Setting The automatic setting will control the heat output based on the comfort level selection. The manual setting allows you to manually control the heat output settings.
Page 6 7034-106F August 13, 2009 R Mt. V ernon Pellet Stove (AE) R R The appliance has been designed to operate on an optional battery back-up system. If you have frequent power outages in your region, hook the appliance up to a 1 volt battery and it will automatically switch to battery power in the event of a power failure.
R R R August 13, 2009 7034-106F Page 7 Mt. V ernon Pellet Stove (AE) 1. Start-Up Cycle During this cycle: • Igniter turns on for 90 seconds to heat up the air in the repot • C ombustion blow.
Page 8 7034-106F August 13, 2009 R Mt. V ernon Pellet Stove (AE) R R 5. Auto-Clean Cycle The repot auto-clean system will cycle: • W hen the appliance is rst plugged in • W hen the house .
R R R August 13, 2009 7034-106F Page 9 Mt. V ernon Pellet Stove (AE) READY 71 Set at: 68 12:30 PM ME NU 1. At the starting screen, press “MENU” button once or twice until “MENU” screen appears. . Highlight “FUEL TYPE” using the “UP/ DOWN” buttons to the right side of the display .
Page 0 7034-106F August 13, 2009 R Mt. V ernon Pellet Stove (AE) R R READY 71 Set at: 74 12:30 PM HE A T OU TP UT ME NU Hold at: Medium High 1. At the starting screen, press “HEA T OUTPUT”. . Use the “UP” button to change “HEA T OUTPUT LEVEL” to ”MEDIUM-HIGH”.
R R R August 13, 2009 7034-106F Page 1 Mt. V ernon Pellet Stove (AE) M. Frequently Asked Questions ISSUES SOLUTIONS 1. Metallic noise 1. Noise is caused by metal expanding and contracting as it heats up and cools down, similar to the sound pro - duced by a furnace or heating duct.
Page 7034-106F August 13, 2009 R Mt. V ernon Pellet Stove (AE) R R 9 T roubleshooting With proper installation, operation, and maintenance your appliance will provide years of trouble-free service.
R R R August 13, 2009 7034-106F Page Mt. V ernon Pellet Stove (AE) 10 Maintaining & Servicing Y our Appliance CAUTION! SHOCK AND SMOKE HAZARD! • Proper Shutdown Procedure must be followed. • Smoke spillage into room can occur if appliance is not cool before unplugging appliance.
Page 7034-106F August 13, 2009 R Mt. V ernon Pellet Stove (AE) R R 4. Disposal of Ashes • Frequency: As needed • By: Homeowner a. Ashes should be placed in a metal container with a tight- tting lid.
R R R August 13, 2009 7034-106F Page 5 Mt. V ernon Pellet Stove (AE) Figure 35.1 - Large Clinker 5. Cleaning Firepot with Firepot Clean-Out T ool • Frequency: Softwood Pellets: Weekly or every 5 bags Hardwood Pellets: Weekly or every 3 bags Alternate Fuel: Daily or everyr 1 bag • By: Homeowner a.
Page 6 7034-106F August 13, 2009 R Mt. V ernon Pellet Stove (AE) R R c. Assemble the crevice tool from the micro cleaning kit to attach to a Shop V ac.
R R R August 13, 2009 7034-106F Page 7 Mt. V ernon Pellet Stove (AE) 8. Cleaning the Glass • Frequency: When clear view of repot becomes obscure • By: Homeowner a. Be sure the wall control screen says OFF and the appliance is allowed to cool.
Page 8 7034-106F August 13, 2009 R Mt. V ernon Pellet Stove (AE) R R 13. Soot and Fly Ash: Formation & Need for Removal in Exhaust V enting System. • Frequency: Prior to each burn season and after pro - longed shut down. • By: Qualied Service T echnician/Homeowner The products of combustion will contain small particles of y ash.
R R R August 13, 2009 7034-106F Page 9 Mt. V ernon Pellet Stove (AE) E. Bafe Removal a. The appliance must be in complete shutdown, com - pletely cool and the exhaust blower off . b. Open door . c. The bafe is located at the top inside of rebox.
Page 0 7034-106F August 13, 2009 R Mt. V ernon Pellet Stove (AE) R R F . Convection Blower Replacement Figure 40.1 Figure 40.3 Depress T ab and Snap Out Power Supply R e m o v e L e f t Side Panel D is co nn ec t Wi re H ar ne ss f ro m Bo tt om o f Bl ow er Remove 2 Screws R em ov e R ig ht Side Panel Figure 40.
R R R August 13, 2009 7034-106F Page 1 Mt. V ernon Pellet Stove (AE) H. Glass Replacement • Glass is 5mm thick high temperature heat-re - sistant ceramic glass. • DO NOT REPLACE with any other material. • Alternate material may shatter and cause injury .
Page 7034-106F August 13, 2009 R Mt. V ernon Pellet Stove (AE) R R 1 1 Reference Materials 9. Firepot The repot is made of high quality ductile iron. The oor of the repot automatically opens for cleaning and is operated by the auto-clean repot system.
R R R August 13, 2009 7034-106F Page Mt. V ernon Pellet Stove (AE) 17. Power Supply The power supply is located at the rear of the appliance. It converts 10 volt AC current to 15 volt DC current to power the appliance.
Page 7034-106F August 13, 2009 R Mt. V ernon Pellet Stove (AE) R R B. Component Locations Baffle Firep ot Ash Pan Ther mocouple an d Ther mocouple Cover Heat Exchan ge r , Fron t & Back Figure 44.
R R R August 13, 2009 7034-106F Page 5 Mt. V ernon Pellet Stove (AE) C. Exploded Drawings 1 2 3 4 5 6 7 8 9 10 1 1 12 13 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 25 39 40 705-001B 7-15-09 Figure 45.
Page 6 7034-106F August 13, 2009 R Mt. V ernon Pellet Stove (AE) R R Glass Size: 21 in. W x 14 in. H # 13 Door Assembly 14 15 16 17 18 19 20 # 41 Auto Clean Motor/Arm Assembly 41 42 43 44 45 46 47 48 # 49 Firepot Riser Assembly 50 51 52 53 54 55 57 56 58 59 60 # 61 Feed Assembly 62 63 64 65 66 67 Part number list on following pages.
R R R August 13, 2009 7034-106F Page 7 Mt. V ernon Pellet Stove (AE) D. Service Parts and Accessories T o order the entire assembly , order the top line part number only . T o order an individual part from an assembly , order the part(s) listed in the indented portion.
Page 8 7034-106F August 13, 2009 R Mt. V ernon Pellet Stove (AE) R R T o order the entire assembly , order the top line part number only . T o order an individual part from an assembly , order the part(s) listed in the indented portion.
R R R August 13, 2009 7034-106F Page 9 Mt. V ernon Pellet Stove (AE) T o order the entire assembly , order the top line part number only . T o order an individual part from an assembly , order the part(s) listed in the indented portion.
Page 50 7034-106F August 13, 2009 R Mt. V ernon Pellet Stove (AE) R R T o order the entire assembly , order the top line part number only . T o order an individual part from an assembly , order the part(s) listed in the indented portion.
R R R August 13, 2009 7034-106F Page 51 Mt. V ernon Pellet Stove (AE) T o order the entire assembly , order the top line part number only . T o order an individual part from an assembly , order the part(s) listed in the indented portion.
Page 5 7034-106F August 13, 2009 R Mt. V ernon Pellet Stove (AE) R R Date of Service Performed By Description of Service E. Service And Maintenance Log.
R R R August 13, 2009 7034-106F Page 5 Mt. V ernon Pellet Stove (AE) Date of Service Performed By Description of Service E. Service And Maintenance Log (Cont’d).
Page 5 7034-106F August 13, 2009 R Mt. V ernon Pellet Stove (AE) R R.
R R R August 13, 2009 7034-106F Page 55 Mt. V ernon Pellet Stove (AE).
R Hearth & Home T echnologies 1445 North Highway Colville, W A 991 14 Division of HNI INDUSTRIES 7034-106F August 13, 2009 Page 56 CONT ACT INFORMA TION : Please contact your Quadra-Fire dealer with any questions or concerns. For the number of your nearest Quadra-Fire dealer visit our web site at www .
デバイスQuadra-Fire MTVERNON-AE-Kの購入後に（又は購入する前であっても）重要なポイントは、説明書をよく読むことです。その単純な理由はいくつかあります：
Quadra-Fire MTVERNON-AE-Kをまだ購入していないなら、この製品の基本情報を理解する良い機会です。まずは上にある説明書の最初のページをご覧ください。そこにはQuadra-Fire MTVERNON-AE-Kの技術情報の概要が記載されているはずです。デバイスがあなたのニーズを満たすかどうかは、ここで確認しましょう。Quadra-Fire MTVERNON-AE-Kの取扱説明書の次のページをよく読むことにより、製品の全機能やその取り扱いに関する情報を知ることができます。Quadra-Fire MTVERNON-AE-Kで得られた情報は、きっとあなたの購入の決断を手助けしてくれることでしょう。
Quadra-Fire MTVERNON-AE-Kを既にお持ちだが、まだ読んでいない場合は、上記の理由によりそれを行うべきです。そうすることにより機能を適切に使用しているか、又はQuadra-Fire MTVERNON-AE-Kの不適切な取り扱いによりその寿命を短くする危険を犯していないかどうかを知ることができます。
ですが、ユーザガイドが果たす重要な役割の一つは、Quadra-Fire MTVERNON-AE-Kに関する問題の解決を支援することです。そこにはほとんどの場合、トラブルシューティング、すなわちQuadra-Fire MTVERNON-AE-Kデバイスで最もよく起こりうる故障・不良とそれらの対処法についてのアドバイスを見つけることができるはずです。たとえ問題を解決できなかった場合でも、説明書にはカスタマー・サービスセンター又は最寄りのサービスセンターへの問い合わせ先等、次の対処法についての指示があるはずです。
