True Manufacturing CompanyメーカーTCGDZ-50の使用説明書/サービス説明書
ページ先へ移動 of 21
............ www .truemfg.com ............ INST ALLA TION MANUAL FOR TCGDZ DISPLA Y CASES (DUAL ZONE) MODELS CUR VED GLASS DISPLA Y CASES - DUAL ZONE MODELS - CONGRA TULA TIONS! Y ou have just purchased the finest commercial refrigeration available. Y ou can expect many years of trouble-free operation.
NOTICE TO CUSTOMER: Loss Or Spoilage Of Products In Your Refrigerator/Freezer Is NOT Covered By Warranty. In Addition To Following Recommended Installation Procedures You Must Run The Refrigerator/Freezer 24 Hours Prior To Usage. True Manufacturing Company, Inc.
............ www .truemfg.com ............ SAFETY INFORMA TION • This display case must be pr operly installed and located in accordance with the Installation Instructions before it is used. • Do not allow childr en to climb, stand or hang on the shelves in the displa y case.
............ www .truemfg.com ............ T rue Food Service Equipment, Inc. 2 2 SAFETY INFORMA TION PROPER DISPOSAL OF THE DISPLA Y CASE DANGER! RISK OF CHILD ENTRAPMENT USE OF EXTENSION CORDS NEVER USE AN EXTENSION CORD! TRUE will not warranty any display case that has been connected to an extension cord.
............ www .truemfg.com ............ T rue Food Service Equipment, Inc. 3 3 Bef ore your ne w display case is connected to a power suppl y , chec k the incoming voltag e with a voltmeter . If anything less than 100% of the rated voltag e f or operation is noted, correct immediately .
............ www .truemfg.com ............ T rue Food Service Equipment, Inc. 4 4 INST ALLA TION / OPERA TION INSTRUCTIONS T o insure that your unit wor ks properl y from the first day , it must be installed properly . W e highly recommend a trained mec hanic and electrician install your T r ue equipment.
............ www .truemfg.com ............ T rue Food Service Equipment, Inc. 5 5 INST ALLA TION / OPERA TION INSTRUCTIONS Warning For proper performance of refrigerated cabinet an ambient temperature no greater than 75°F (24°C) with a relative humidity of 55% is required.
............ www .truemfg.com ............ T rue Food Service Equipment, Inc. 6 6 INST ALLA TION / OPERA TION INSTRUCTIONS Step 4 A. Bef ore your ne w unit is connected to a pow er supply , check the incoming v oltage with a v olt- meter . If anything less than 100% of the r ated voltag e f or operation is noted, correct immedi- ately .
............ www .truemfg.com ............ T rue Food Service Equipment, Inc. 7 7 INST ALLA TION / OPERA TION INSTRUCTIONS CONDUCTORS AND CIRCUITS Wire Gauge for 2% Voltage Drop in Supply Circuits.
............ www .truemfg.com ............ T rue Food Service Equipment, Inc. 8 8 Step 5 A. The compressor is r eady to oper ate. Plug in the display case. B. Check the temperature control setting in the lower right of the cabinet backside. The set- ting should be at No.
INST ALLA TION / OPERA TION INSTRUCTIONS SHEL VING INST ALLA TION (REFRIGERA TED BAKERY) SHELF INST ALLA TION: A. Lift each door up and out of track (do not dis- connect elastic tubing). Stretch elastic surgical tubing and set doors on each side of unit.
INST ALLA TION / OPERA TION INSTRUCTIONS OPTIONAL (INST ALLING OPTIONAL CASTORS) CASTOR INST ALLA TION: TOOLS REQUIRED: • Castor wrenc h (if not included contact T r ue) • Adjustable wrenc h NOTE Castors not available for hard wired or remote models.
INST ALLA TION / OPERA TION INSTRUCTIONS FORMICA KIT INST ALLA TION: FORMICA KIT COMPONENTS: (2) F or mica T op End P anels 10 3 / 4 "w x 33"h (27.3 cm x 83.8 cm). (2) Bottom End P anels (1) left side, (1) right side (For mica glued to black plastic panel with 4 key hole slots).
............ www .truemfg.com ............ T rue Food Service Equipment, Inc. 12 12 MAINTENANCE, CARE & CLEANING • The e xterior may be wiped clean with mild soap and water . Use a good stainless cleaner on coun- tertop. CAUTION: Do not use any steel wool, abrasive or chlorine based products to clean stainless steel sur - faces.
............ www .truemfg.com ............ T rue Food Service Equipment, Inc. 13 13 MAINTENANCE, CARE & CLEANING LIGHT BULB REPLACEMENT SHELF MOUNTED BULB REPLACEMENT : WARNING When replacing a light bulb make sure power to the unit is either turned off or unplugged.
............ www .truemfg.com ............ T rue Food Service Equipment, Inc. 14 14 MAINTENANCE, CARE & CLEANING TEMPERA TURE CONTROL ADJUSTMENT FOR HIGH AL TITUDE ONL Y! TERMS: • Cut-out - T emperature sensed by the controller that shuts the compressor off.
............ www .truemfg.com ............ T rue Food Service Equipment, Inc. 15 15 CLEANING THE CONDENSER COIL When using electrical appliances, basic safety precautions should be followed, including the following CONDENSER CLEANING: TOOLS REQUIRED: • Phillips screwdriver • Stiff br istle brush • Adjustable wrench • V acuum A.
............ www .truemfg.com ............ T rue Food Service Equipment, Inc. 16 16 Condensers accumulate dirt and require cleaning every 30 days. Dirty condensers result in compressor failure, product loss, and lost sales... which are not covered by warranty .
............ www .truemfg.com ............ T rue Food Service Equipment, Inc. 17 17 CAUTION: Do not use any steel wool, abrasive or chlorine based products to clean stainless steel surfaces.
............ www .truemfg.com ............ T rue Food Service Equipment, Inc. 18 18 Recommended cleaners f or cer tain situations / environments of stainless steel A) Soap, ammonia and detergent medallion applied with a cloth or spong e can be used for routine cleaning.
............ www .truemfg.com ............ T rue Food Service Equipment, Inc. 19 19 W ARRANTY INFORMA TION (U.S.A. and Canada ONL Y!) ONE YEAR P ARTS & LABOR W ARRANTY TRUE warrants to the origina.
デバイスTrue Manufacturing Company TCGDZ-50の購入後に（又は購入する前であっても）重要なポイントは、説明書をよく読むことです。その単純な理由はいくつかあります：
True Manufacturing Company TCGDZ-50をまだ購入していないなら、この製品の基本情報を理解する良い機会です。まずは上にある説明書の最初のページをご覧ください。そこにはTrue Manufacturing Company TCGDZ-50の技術情報の概要が記載されているはずです。デバイスがあなたのニーズを満たすかどうかは、ここで確認しましょう。True Manufacturing Company TCGDZ-50の取扱説明書の次のページをよく読むことにより、製品の全機能やその取り扱いに関する情報を知ることができます。True Manufacturing Company TCGDZ-50で得られた情報は、きっとあなたの購入の決断を手助けしてくれることでしょう。
True Manufacturing Company TCGDZ-50を既にお持ちだが、まだ読んでいない場合は、上記の理由によりそれを行うべきです。そうすることにより機能を適切に使用しているか、又はTrue Manufacturing Company TCGDZ-50の不適切な取り扱いによりその寿命を短くする危険を犯していないかどうかを知ることができます。
ですが、ユーザガイドが果たす重要な役割の一つは、True Manufacturing Company TCGDZ-50に関する問題の解決を支援することです。そこにはほとんどの場合、トラブルシューティング、すなわちTrue Manufacturing Company TCGDZ-50デバイスで最もよく起こりうる故障・不良とそれらの対処法についてのアドバイスを見つけることができるはずです。たとえ問題を解決できなかった場合でも、説明書にはカスタマー・サービスセンター又は最寄りのサービスセンターへの問い合わせ先等、次の対処法についての指示があるはずです。
