United States Stoveメーカー1537Mの使用説明書/サービス説明書
ページ先へ移動 of 24
1 C O M P A N Y U N I T E D S T A T E S S T O V E C S S U Model 1537M Model 1537M Model 1537M Model 1537M Model 1537M OWNERS MANUAL OWNERS MANUAL OWNERS MANUAL OWNERS MANUAL OWNERS MANUAL SOLID SOLID .
2 NO NO NO NO NO TE: TE: TE: TE: TE: Y Y Y Y Y OUR UNIT MUST BE INST OUR UNIT MUST BE INST OUR UNIT MUST BE INST OUR UNIT MUST BE INST OUR UNIT MUST BE INST ALLED BY A ALLED BY A ALLED BY A ALLED BY A ALLED BY A Q Q Q Q Q U U U U U ALIFIED FURNA ALIFIED FURNA ALIFIED FURNA ALIFIED FURNA ALIFIED FURNA CE INST CE INST CE INST CE INST CE INST ALLER.
3 CAUTION! CAUTION! CAUTION! CAUTION! CAUTION! CLEANOUT OF THE HEA T EXCHANGER, FLUE PIPE, CHIMNEY , AND DRAFT INDUCER (IF USED), IS ESPECIALL Y IMPOR T ANT A T THE END OF THE HEA TING SEASON T O MINIMIZE CORROSION DURING THE SUMMER MONTHS, CA USED BY A CCUMULA TED ASH.
4 1 . Check your local codes. The installation must comply with their rulings. 2 . Do not install this furnace in a mobile home or trailer. 3 . Always connect this furnace to a chimney and vent to the outside. Never vent to another room or inside a building.
5 Y Y Y Y Y our Hotblast Furnace is designed to be a supplemental or central heating source for your home. This Solid Fuel Furnace may be installed in conjunction with a properly operating central fur.
6 DIMENSIONS OF FURNACE DIMENSIONS OF FURNACE DIMENSIONS OF FURNACE DIMENSIONS OF FURNACE DIMENSIONS OF FURNACE FIGURE 1 1537M.
7 LOCA LOCA LOCA LOCA LOCA TING TING TING TING TING THE FURNA THE FURNA THE FURNA THE FURNA THE FURNA CE CE CE CE CE 1. The furnace should be located in the same room as the central system and as close as possible, but not closer than 9".
8 CHIMNEY CONNECTION CHIMNEY CONNECTION CHIMNEY CONNECTION CHIMNEY CONNECTION CHIMNEY CONNECTION Fig. 4 MASONRY CHIMNEY MASONRY CHIMNEY MASONRY CHIMNEY MASONRY CHIMNEY MASONRY CHIMNEY Before using an existing masonry chimney, clean the chimney and inspect the flue liner to be sure it is safe to use.
9 RULES FOR CONNECT RULES FOR CONNECT RULES FOR CONNECT RULES FOR CONNECT RULES FOR CONNECT OR OR OR OR OR PIPE INST PIPE INST PIPE INST PIPE INST PIPE INST ALLA ALLA ALLA ALLA ALLA TION TION TION TION TION 1. The crimped end of the chimney connector fits inside the furnace flue collar.
10 ASSEMBL ASSEMBL ASSEMBL ASSEMBL ASSEMBL Y OF FURNA Y OF FURNA Y OF FURNA Y OF FURNA Y OF FURNA CE CE CE CE CE Your furnace requires the following items to be assembled or installed by the service p.
11 LOAD FAN LINE LOAD LIMIT LINE BREAK OFF JUMPER FOR LOW VOLTAGE FAN "OFF" INDICATOR FAN "ON" INDICATOR LIMIT INDICATOR Honeywell LIMIT SWITCH R1 R2 G B W 110 VAC, 60 HZ.
12 INST INST INST INST INST ALLA ALLA ALLA ALLA ALLA TION TION TION TION TION Please see all methods of Installation in Please see all methods of Installation in Please see all methods of Installation in Please see all methods of Installation in Please see all methods of Installation in Appendix at the rear of this booklet.
13 2" MI N. AIR SPACE REQUIRED BY CODE PLENUM TO CE ILING 6" MI N. CENTRAL FU RNACE PLENUM Figure 12 P P P P P OWER OWER OWER OWER OWER F F F F F AILURE AILURE AILURE AILURE AILURE I I I I I NSTRUCTIONS NSTRUCTIONS NSTRUCTIONS NSTRUCTIONS NSTRUCTIONS : : : : : Operation after loss of power-- 1.
14 CAUTION CAUTION CAUTION CAUTION CAUTION GASES THAT ARE DRIVEN FROM FRESH GASES THAT ARE DRIVEN FROM FRESH GASES THAT ARE DRIVEN FROM FRESH GASES THAT ARE DRIVEN FROM FRESH GASES THAT ARE DRIVEN FRO.
15 SER SER SER SER SER VICE HINTS VICE HINTS VICE HINTS VICE HINTS VICE HINTS Do not expect a furnace to draw. It is the chimney that creates the draft. Smoke spillage into the house or excessive build-up of water or creosote in the chimney are warnings that the chimney is not functioning properly.
16 MODEL 1537M REPAIR PARTS.
17 PARTS LIST PARTS LIST PARTS LIST PARTS LIST PARTS LIST MODEL 1537M MODEL 1537M MODEL 1537M MODEL 1537M MODEL 1537M (SEE DIAGRAM, PAGE 16) (SEE DIAGRAM, PAGE 16) (SEE DIAGRAM, PAGE 16) (SEE DIAGRAM,.
18 COLD AIR DUCT 6" P IPE DAMPER PIPE CONNECT OR FURN ACE OPTIONA L 11 RPT 90° ELBO W FIGURE 15-1 FIGURE 15-1 6" P IPE COLD A IR DUCT 8" P IPE FURNAC E EXIST ING GAS / O IL/ELE CTRIC F.
19 APPENDIX APPENDIX APPENDIX APPENDIX APPENDIX INSTALLATION - A INSTALLATION - A INSTALLATION - A INSTALLATION - A INSTALLATION - A (U.S. ONLY) TO EXISTIN G DUCT WOR K WARM AIR EXISTING FURNACE SOLID.
20 TO EXI STING DUCT W ORK WARM AIR EXIST ING FURNAC E SOLID FUEL FURNAC E FILT ER BOX COLD AIR RETURN PLENU M TOP (OPTIO NAL) INSTALLATION - B INSTALLATION - B INSTALLATION - B INSTALLATION - B INSTALLATION - B (U.S. ONLY) INSTALLATION - C INSTALLATION - C INSTALLATION - C INSTALLATION - C INSTALLATION - C (U.
21 COLD AIR RETURN 2" MINIMUIM CLEARANCE SOLID F U E L FURNACE DUCT WORK BAFFLE FURNACE P L E NUM EXISTING F U R NACE EXISTING F U R NACE FURNACE P L E NUM CLEARANCE 2" MINIMUIM WORK DUCT RE.
22 SOLID FUEL FURNACE COLD AIR RETURN TO FILTER BOX 2" MINIMUM CLEARANCE DUCT WORK CENTRAL FURNACE INSTALL ATION SOLID FUEL FURNACE EXISTING FURNACE FURNACE PLENUM COLD AIR RETURN 2" MINIMUM.
23 EXISTING OIL, ELECTRIC, OR GAS FURNACE SOLID FUEL FURNACE 2" MINIMUM CLEARANCE SOLID FUEL FURNACE EXISTING OIL, ELECTRIC, OR GAS FURNACE INSTALLATION - H INSTALLATION - H INSTALLATION - H INST.
24 1. Smoking when feed door a ) Insufficient Draft. a ) Set Thermostat higher. is open. b ) Clogged chimney or chimney b ) Clean Chimney. connector. c) Add raincap to chimney. c) Down draft in chimney. 2. Furnace does not heat. a ) Wood not seasoned and dry.
デバイスUnited States Stove 1537Mの購入後に（又は購入する前であっても）重要なポイントは、説明書をよく読むことです。その単純な理由はいくつかあります：
United States Stove 1537Mをまだ購入していないなら、この製品の基本情報を理解する良い機会です。まずは上にある説明書の最初のページをご覧ください。そこにはUnited States Stove 1537Mの技術情報の概要が記載されているはずです。デバイスがあなたのニーズを満たすかどうかは、ここで確認しましょう。United States Stove 1537Mの取扱説明書の次のページをよく読むことにより、製品の全機能やその取り扱いに関する情報を知ることができます。United States Stove 1537Mで得られた情報は、きっとあなたの購入の決断を手助けしてくれることでしょう。
United States Stove 1537Mを既にお持ちだが、まだ読んでいない場合は、上記の理由によりそれを行うべきです。そうすることにより機能を適切に使用しているか、又はUnited States Stove 1537Mの不適切な取り扱いによりその寿命を短くする危険を犯していないかどうかを知ることができます。
ですが、ユーザガイドが果たす重要な役割の一つは、United States Stove 1537Mに関する問題の解決を支援することです。そこにはほとんどの場合、トラブルシューティング、すなわちUnited States Stove 1537Mデバイスで最もよく起こりうる故障・不良とそれらの対処法についてのアドバイスを見つけることができるはずです。たとえ問題を解決できなかった場合でも、説明書にはカスタマー・サービスセンター又は最寄りのサービスセンターへの問い合わせ先等、次の対処法についての指示があるはずです。
