United States Stoveメーカー1557Mの使用説明書/サービス説明書
ページ先へ移動 of 28
UNITED STATES STOVE COMPANY 227 Industrial Park Road P .O.Box 151 South Pittsburg, TN 37380 (423) 837-2100 www .USST OVE.com C S S U C O M P A N Y U N I T E D S T A T E S S T O V E Models 1357M & 1557M OWNER'S MANUAL SOLID FUEL WARM AIR FURNACE FOR P ARALLEL INST ALLA TION WITH EXISTING FORCED AIR-GAS OR OIL FIRED FURNACE (U.
NOTE: YOUR UNIT MUST BE INST ALLED BY A QUALIFIED FURNACE INST ALLER. Y ou've purchased one of America's Finest Wood and Coal Burning Furnaces. By heating with wood and coal you're helping CONSER VE AMERICA'S ENERGY! W ood is our Renewable Energy Resource.
Caution Labels Y our Furnace has the following labels. Read and Obey all labels. DANGER: RISK OF FIRE OR EXPLOSION. DO NOT burn garbage, gasoline, drain oil, or other ammable liquids. WARNING: FIRE HAZARD. DO NOT operate with re draft exceeding .
Rules for safe installation and operation Read these rules and the instructions carefully . Failure to follow them will cause a hazard that could result in death, serious bodily injury , and/or property damage.
Y our HOTBLAST Furnace is designed to be a supplemental or central heating source for your home. This Solid Fuel Furnace may be installed in conjunction with a properly operating central furnace t.
DIMENSIONS OF FURNACE .
Locating the Furnace 1. The furnace should be located in the same room as the central system and as close as possible, but not closer than 9". There should be no wall between the furnace and the warm air outlet duct that is connected directly to the warm air outlet plenum of the central furnace.
10' 2' MIN. 3' MIN. 6" CHIMNEY CONNECTOR 6" ELBOW 6" SOLID DAMPER 6" BAROMETRIC DRAFT REGULATOR REFER TO CHIMNEY MANUFACTURER'S INSTRUCTIONS AND PARTS.
1. The crimped end of the chimney connector ts inside the furnace ue collar . Install additional chimney con- nec tors and elbow with the CRI MPED END T OW ARD THE FURNACE. This will allow any condensation in the ue to run back into the furnace.
CONNECTION OF CHIMNEY CONNECTOR TO A MASONRY CHIMNEY THROUGH A COMBUSTIBLE WALL Figure 8 shows how to connect the chimney connector of a heater to a masonry chimney through a combustible wall. There are ve allowable ways that a chimney connector can be connected to a masonry chimney by passing through a combustible wall.
1. Use a minimum 3-1/2" thick brick masonry wall framed into the combustible wall. A reclay liner (ASTM C315 or equivalent) having a 5/8" minimum wall thickness must be used and it must be at least 12" away from any material that could catch re.
SHEET STEEL SUPPORTS CHIMNEY SECTION CHIMNEY CONNE CTOR AIR SPACE 2 IN. FIGU RE 12, PA RT D MINIMUM CLEARANCE 2 IN. ALL AROUND CHIMNEY THIMBLE 1 IN. A IR SPACE TO CHIMNEY LENGTH MASONRY CHIMNEY CONSTRUCTED TO NFPA 211 SHEET STEEL SUPPORTS (24 GAUGE MIN.
THERMODISC THERMODISC COVER 4” ELEC TRICAL JUNC TION BO X BL OWERS BL OWERS GASKE T CLIP NUTS (Not used in the upper center hole .) Assembly of Furnace Y our furnace requires the following it.
NOTE: For model 1357M, disregard the wiring (wires M1 & M2) of one blower motor. .
Installation Please see all methods of Installation at the rear of this booklet. This is a furnace, not a free standing stove. Y ou must direct heated air from 8" outlets away from the furnace, or it will not function properly . 1. This installation must be done by a qualied heating equipment installer .
Operating Instructions FUEL Models 1357M & 1557M Egg size (1-3/16" or larger) bituminous coal for residential furnaces, or any of the specially packed replace coals can be used. Coal with a low ash content (2% to 6%) is recommended.
Service Hints Do not expect a furnace to draw . It is the chimney that creates the draft. Smoke spill- age into the house or excessive build-up of water or creosote in the chimney are warn- ings that the chimney is not functioning properly . Correct the problem before using furnace.
Trouble Shooting Tips for Warm Air Furnace 1. Problem: Smoke puffs from furnace Solution: A. Check chimney draft. Check for blocked chimney or ue pipe. Use mirror to check chimney clearance. B. Check ash pit — if it is too full, empty . C.
Repair Parts 22 6 8 7 9 20 18 19 17 16 14 10 15 11 12 13 21 1 5 2 3 4 1 28 27 26 29 30 31 24 25 32 33 23 35 34 38 37 36 40 38 36 37 39 34 42 41 46 48 47 44 43 45 49 1 35 7 M 15 5 7 M 69399.
1 25541G Cabinet Side (Left & Right) 1357M 2 25467G 1557M 2 88032 Flue Collar Gasket 2 3 40246 Flue Collar 1 N/S 83227 Bolt, 1/4-20 x 1" 6 N/S 83250 Kep Nut, 1/4-20 6 4 25540G Cabinet Back 1357M 1 23459G 1557M 5 25561G Cabinet T op 1357M 1 25466G 1557M N/S 891214 8" Collar 2 6 68217 Feed Door Assy .
Optional Equiptment 11DIKL Draft Inducer Kit w/ Limit Swich This optional kit allows your furnace to be thermostati- cally controlled and gives the option to change the on/of f times of the distribution blower(s).
Bulletin rc454 A GUIDE TO BURNING COAL IN YOUR FURNACE Furnaces that are capable of burning coal usually will burn both Bituminous and Anthracite coal. An- thracite is perhaps the best coal fuel because of its long even burn time, high heat output, and clean- liness which make it a good choice for the home.
Before adding further fuel, be sure to leave a red spot of glowing coals in the center of the rebox to insure that the re has not been smothered and to help ignite the gases given of f by the new charge.
CENTRAL INSTALLATION ADD-ON INSTALLATION.
TO EXISTING DUCT WORK WARM AIR EXISTING FURNACE SOLID FUEL FURNACE FILTER BOX COLD AIR RETURN TO EXISTING DUCT WORK WARM AIR EXISTING FURNACE SOLID FUEL FURNACE FILTER BOX PLENUM COLLECTOR BOX .
INSTALLATION D INSTALLATION E.
INSTALLATION H TOP VIEW FRONT VIEW INSTALLATION F INSTALLATION G.
.
デバイスUnited States Stove 1557Mの購入後に（又は購入する前であっても）重要なポイントは、説明書をよく読むことです。その単純な理由はいくつかあります：
United States Stove 1557Mをまだ購入していないなら、この製品の基本情報を理解する良い機会です。まずは上にある説明書の最初のページをご覧ください。そこにはUnited States Stove 1557Mの技術情報の概要が記載されているはずです。デバイスがあなたのニーズを満たすかどうかは、ここで確認しましょう。United States Stove 1557Mの取扱説明書の次のページをよく読むことにより、製品の全機能やその取り扱いに関する情報を知ることができます。United States Stove 1557Mで得られた情報は、きっとあなたの購入の決断を手助けしてくれることでしょう。
United States Stove 1557Mを既にお持ちだが、まだ読んでいない場合は、上記の理由によりそれを行うべきです。そうすることにより機能を適切に使用しているか、又はUnited States Stove 1557Mの不適切な取り扱いによりその寿命を短くする危険を犯していないかどうかを知ることができます。
ですが、ユーザガイドが果たす重要な役割の一つは、United States Stove 1557Mに関する問題の解決を支援することです。そこにはほとんどの場合、トラブルシューティング、すなわちUnited States Stove 1557Mデバイスで最もよく起こりうる故障・不良とそれらの対処法についてのアドバイスを見つけることができるはずです。たとえ問題を解決できなかった場合でも、説明書にはカスタマー・サービスセンター又は最寄りのサービスセンターへの問い合わせ先等、次の対処法についての指示があるはずです。
