WeberメーカーGENESIS 1300の使用説明書/サービス説明書
ページ先へ移動 of 36
W E B E R W E B E R Serial Number Please use this number in registering your w arranty and any correspondence with the f actory . Owner’ s Manual National Association PROPANE GAS ® 92725 11/98 GENESIS ® 1300 Series LP Gas Barbecue W ARNING 1. Do not store spare LP Cylinder within 10 feet (3m) of this appliance.
D ANGER Failure to f ollo w the Dangers, W arnings and Cautions contained in this Owner’ s Manual may result in serious bodil y injur y or death, or in a fire or an explosion causing damage to property . W ARNINGS Do not store a spare or disconnected LP tank under or near this barbecue.
3 W eber-Stephen Products Co. (W eber) hereby warr ants to the ORIGINAL PURCHASER of this W eber Gas Barbecue that it will be free of def ects in mater ial and workmanship from the date of purchase as.
© 1998 W eber . Weber , , Genesis, Fla v orizer and Crossov er are registered U .S. trademarks; P er ma-Mount, Gas Catcher , FlameCheck, Steam-N-Chips , Spider Stopper , and W ar m-Up are U .S. trademarks of W eber-Stephen Products Co ., 200 East Daniels Road, P alatine, IL 60067-6266.
5 Contents WARNINGS ................................................................ 2 W arranty & P atents .................................................. 3-4 General Instructions .................................................... 6 Assembly .
6 General Instructions Y our W eber Gas Barbecue is a por table outdoor cooking appliance. With the W eber Gas Barbecue you can grill, barbecue, roast and bak e with results that are difficult to duplicate with indoor kitchen appliances. The closed lid and Flav or izer Bars produce that "outdoor" fla v or in the food.
7 Step 1 Check pac kage contents Cooking bo x (assembly) Lid (assembly) LP tank LP tank filler adapter Bottom tra y T wo cooking grates Control panel Assembl y T ools needed Regular screwdriv er Phillips screwdriv er Hammer 7/16 inch open-end or an adjustable wrench Pliers Block of w ood Supplies needed Y our LP tank is shipped empty f or saf ety .
Left frame Right frame Wheel frame Caster frame T wo frame connectors W ork table Swing table assemb ly Slide bar assembly Axle T wo accessor y trays W ar ming rack W ar m-Up Basket Five long Fla vori.
T wo plastic buttons (actual size) 1/4-20 keps n ut T wo 1/4-20 wing nuts (actual size) Eighteen 1/4 inch nylon w ashers T wo hair pin cotters T wo wheel hubcaps T wo 10-24 hex n ut (actual size) T wo.
10 Figure 1 W E B E R W E B E R Figure 2 Leg tabs F rame tabs (a) (b) Right frame Left frame Step 2 Assemble wheels Y ou will need: axle, two wheel hubcaps , two wheels, wheel frame, hammer and a b lock of wood. Place one end of the axle on the bloc k of wood (or other protected surf ace).
11 Figure 3 Dimples to the inside Fuel scale decal Figure 4 Step 4 Continue frame assemb ly Y ou will need: caster frame, wheel fr ame, f our 1/4-20 x 1/2 inch bolts, f our nylon washers and a 7/16 inch wrench. Place the caster frame onto the tabs of the left frame with the dimple to the inside.
12 Figure 6 View from rear of barbecue Plastic buttons Figure 5 Step 7 Add front panel Y ou will need: front panel and two plastic b uttons. T ur n frame assembly right side up . Align the panel with the holes in the frame and inser t the plastic buttons through the front panel and fr ame .
13 Guide screw (a) (b) (c) Wing nuts View from behind cooking bo x Figure 9 Figure 7 Burner tubes F rame brace (a) (b) Spacer brac ket K eps nut Ta b F rame cross piece Nylon washer Bolt Slide the cooking bo x to the left within the frame. Put the washer on the bolt.
14 F rame brace Manif old brack et Figure 10 Figure 11 Figure 12 Cross brace T ank panel tabs Slots in frame brace F rame brace Step 9 Install manif old brack et Y ou will need: manif old brac ket Hook the brac ket onto the manif old at the center burner valv e.
15 Figure 13 View from front left View from front right F E F E Figure 14 Igniter lock n ut K eyhole in frame brace Small par t of keyhole in frame brace F rame brace F rame brace (a) (b) (c) Step 11 Add fuel scale assembly Y ou will need: fuel scale assembly , two 1/4-20 wing nuts and two nylon w ashers.
16 F E F E F E Figure 15 T ank lock wing nut (a) (b) Scale setting wing nut Step 13 Set LP fuel scale Y ou will need: LP tank (empty). Note - F or accuracy , the fuel scale must be set with an empty tank. W e utilize v ar ious LP tank manuf acturers. Some of the tanks we receiv e hav e differing top collar assemblies .
17 Figure 16 Figure 18 T ur n so regulator vent does not collect water Hose T ank lock wing nut Quick disconnect engaged V alve handwheel close clockwise T ank valv e Collar Male fitting Pressure reli.
18 Figure 19 (a) Figure 20 (c) (d) (b) Step 17 Check f or gas leaks W ARNING: Y ou should check f or gas leaks every time you disconnect and reconnect a gas fitting. Note - All f actor y made connections hav e been thoroughly check ed for gas leaks .
19 Figure 24 Figure 23 Figure 25 Bottom tra y Finger grip on front edge of bottom tra y Finger grip F ront side of catch pan holder Figure 21 Figure 22 Step 18 Install Flav orizer Bars and Cooking Grates Y ou will need: five long Fla vorizer Bars, eight short Flav or izer Bars and two cooking g rates.
20 Hair pin cotter Hinge pin Figure 26 Figure 27 T ool holders Inser t in frame brace Control panel Phillips screws/ washers (a) (b) Step 20 Install Lid Y ou will need: lid, two hinge pins and two hair pin cotters . Set the lid in place. Align the hinges at the rear of the barbecue.
21 Slot in frame (view from belo w) Inser t one end of the hinge rod into the hole in the frame. Figure 29 (a). Inser t the other end into the hole in the swing tab le end brac ket. Figure 29 (b). Hold the end br ack et at an angle so the lower tab is inside the fr ame tube.
22 Step 23 Complete accessor y installation Y ou will need: W ar m-Up Basket, war ming rack, work table , accessor y rack, three tubing plugs , ther mometer and a hammer . Inser t one end of the Weber W ar m-Up Basket into the hole in the right end of the lid and the other end into the slot in the left end of the lid.
23 6 8 5 2 7 4 3 1 Figure 1 Crosso ver Ignition System Lighting Summar y lighting instructions are on the control panel. W ARNING: The burner control knobs m ust be in the OFF position before turning on the LP tank v alve .
24 8 6 2 4 3 1 7 5 Figure 2 Manual Lighting Manual Lighting 4) T ur n the tank on by turning the tank valv e counterclockwise . 5) Str ike a match and put the flame into the matchlight hole in the front of the cooking bo x. W ARNING: Do not lean over open barbecue.
25 Cooking W ARNING: Do not move the W eber Gas Barbecue when operating or hot. Y ou can adjust the FRONT , CENTER and BACK b ur ners as desired. The control settings High (H), Medium (M), Low (L), or Off (O) are described in your W eber cookbook.
26 Scale setting wing nut T ank lock wing nut T ank valv e Collar (a) (b) Figure 3 Figure 4 Refilling the LP tank W e recommend that y ou refill before the scale indicator reaches "E".
27 Figure 6 Male fitting Regulator Collar Quick disconnect engaged Figure 5 (a) (b) c) Connect the hose to the tank. Route the hose so it does not interf ere with the scale indicator rod. Slide back the collar of the quic k disconnect on the tank valv e.
28 28 Safe handling tips f or LP Gas ■ Liquid Propane (LP) gas is a petroleum product as are gasoline and natural gas. LP gas is a gas at regular temperatures and pressures. Under moder ate pressure, inside a cylinder , LP gas is a liquid. As the pressure is released the liquid readily vaporizes and becomes gas.
29 Figure 8 (b) (c) (d) (a) c) V alves to manif old connections. Figure 7 (c). d) The hose to regulator connection. Figure 7 (d). W ARNING: If there is a leak at connection (b), (c) or (d), turn OFF the gas . DO NO T OPERA TE THE B ARBECUE. Contact Weber -Stephen Customer Service .
30 Burner inside cooking bo x Figure 11 Dark blue Light blue Tips occasionally yello wish Figure 9 V entur i Air shutter V entur i fin W eber Spider Stopper Guard Figure 10 Figure 12 Figure 13 General.
31 e) Remov e the manifold brac ket and unscrew the tw o wing nuts that hold the manif old to the cooking box. Pull the manif old and v alve assemb ly out of the burners and carefully set it down. Figure 15. f) Slide the burner assembly out from under the guide screw and w asher in the corners of the cooking box.
32 i) Reinstall the Spider Stopper Guards. Slightly rotate the Spider Stopper Guards so that the seams are in line with the V enturi fins. There should be no gaps in the seams or in the fit around the burners and valv es.
33 Prob lem Burners b urn with a yello w or orange flame, in conjunction with the smell of gas. Burners do not light. -or - Burners ha ve a small flickering flame in the HIGH position. -or- Barbecue temperature only reaches 250˚ to 300˚ degrees in the HIGH position.
34 W E B E R W E B E R 6 1 2 3 4 5 9 10 11 14 12 13 17-18 25 26 19 60 59 58 61 46 38 47 48 49 50-51 52 53 55 54 44 42 41 40 39 38 36 35 34 33 30 31 32 56-57 45 43 27 28 29 37 15 16 20 21 24 8 7 23 13,.
35 1 Hair pin cotters (2) 2 Hinge pins (2) 3 Left Endcap 4 Shroud Assembly 5 Lid handle 6 W ar m-Up Basket 7 W ar ming rack 8 Shor t Flav orizer bars (8) 9 Long Flav or izer bars (5) 10 Cooking grates.
A F INAL W ORD OF T HANKS hank you for choosing a W eber Barbecue. Our family her e at W eber has worked har d to produce the highest quality products for your satisfaction. While we give much attention to our products, an occasional error may occur .
デバイスWeber GENESIS 1300の購入後に（又は購入する前であっても）重要なポイントは、説明書をよく読むことです。その単純な理由はいくつかあります：
Weber GENESIS 1300をまだ購入していないなら、この製品の基本情報を理解する良い機会です。まずは上にある説明書の最初のページをご覧ください。そこにはWeber GENESIS 1300の技術情報の概要が記載されているはずです。デバイスがあなたのニーズを満たすかどうかは、ここで確認しましょう。Weber GENESIS 1300の取扱説明書の次のページをよく読むことにより、製品の全機能やその取り扱いに関する情報を知ることができます。Weber GENESIS 1300で得られた情報は、きっとあなたの購入の決断を手助けしてくれることでしょう。
Weber GENESIS 1300を既にお持ちだが、まだ読んでいない場合は、上記の理由によりそれを行うべきです。そうすることにより機能を適切に使用しているか、又はWeber GENESIS 1300の不適切な取り扱いによりその寿命を短くする危険を犯していないかどうかを知ることができます。
ですが、ユーザガイドが果たす重要な役割の一つは、Weber GENESIS 1300に関する問題の解決を支援することです。そこにはほとんどの場合、トラブルシューティング、すなわちWeber GENESIS 1300デバイスで最もよく起こりうる故障・不良とそれらの対処法についてのアドバイスを見つけることができるはずです。たとえ問題を解決できなかった場合でも、説明書にはカスタマー・サービスセンター又は最寄りのサービスセンターへの問い合わせ先等、次の対処法についての指示があるはずです。
