Weed EaterメーカーWET2242STCの使用説明書/サービス説明書
ページ先へ移動 of 48
MODEL NO . WET2242STC 22.0 HP 42 Inc h La wn T ractor 188313 6.5.03 MH PRINTED IN U .S .A. ® F or P ar ts and Ser vice, contact our authorized distributor: call 1-800-849-1297 F or T echnical Assista.
2 • A void star ting or stopping on a slope. If tires lose tr ac- tion, disengage the blades and proceed slo wly straight down the slope . DO NO T: • Do not turn on slopes unless necessar y , and then, turn slowly and gradually downhill, if possib le.
3 W ARNING: In order to prevent ac- ci den tal star ting when setting up, trans por t ing, ad just ing or making re- pairs, al ways dis con nect spark plug wire and place wire where it can not contact spark plug. W ARNING: Do not coast do wn a hill in neutral, you ma y lose control of the tractor .
4 T ABLE OF CONTENTS SAFETY RULES ......................................................... 2-3 PRODUCT SPECIFICA TIONS ....................................... 4 CUST OMER RESPONSIBILITIES ................................. 4 ASSEMBL Y ................
5 CONTENTS OF HARD W ARE P A CK Steering Wheel Seat Keys Slope Sheet (1) Oil Drain Tube (1) Bolt (1) Washer 17/32 x 1-3/16 x 12 Gauge (1) Lock Washer 1/2 (1) Large Flat Washer (1) Hex Bolt 1/4-28 x 1-.
6 ASSEMBL Y T OOLS REQUIRED FOR ASSEMBL Y A sock et wrench set will make assembly easier . Stan dard wrench sizes are listed. (2) 7/16" wrenches Utility knif e (2) 3/4" wrench Tire pres sure.
7 ASSEMBL Y FIG. 2 T O ROLL TRA CT OR OFF SKID (See Op- er a tion section for location and func tion of con trols) • Press lift le ver plunger and raise attachment lift le ver to its highest po si tion. • Release parking brake b y depressing clutch/brak e ped al.
8 ASSEMBL Y ✓ CHECKLIST BEFORE Y OU OPERA TE AND ENJO Y Y OUR NEW TRAC- T OR, WE WISH TO ASSURE THA T Y OU RECEIVE THE BEST PER FOR MANCE AND SA TISF ACTION FR OM THIS QU ALITY PROD UCT . PLEASE REVIEW THE FOLLO WING CHECKLIST: ✓ All assembly instructions hav e been completed.
9 OPERA TION These symbols ma y appear on your tractor or in literature supplied with the product. Lear n and understand their mean- ing. DANGER, KEEP HANDS AND FEET AWAY FREE WHEEL (Automatic Models .
10 OPERA TION KNO W Y OUR TRA CT OR READ THIS O WNER'S MANU AL AND SAFETY RULES BEFORE OPERA TING Y OUR TRA CT OR Compare the illustrations with y our tractor to f amiliar ize y ourself with the locations of various controls and ad just ments. Sav e this manual f or future ref erence.
11 NO TE: Under cer tain conditions when tractor is standing idle with the engine running, hot engine exhaust gases ma y cause “brown ing” of grass .
12 T O OPERA TE ON HILLS W ARNING: Do not drive up or do wn hills with slopes great er than 15° and do not drive across an y slope . • Choose the slowest speed bef ore star ting up or down hills. • A void stopping or changing speed on hills. • If slowing is necessary , move throttle control le ver to slower position.
13 OPERA TION T O ST ART ENGINE (See Fig. 5) When star ting the engine for the fi rst time or if the engine has run out of fuel, it will take e xtra cranking time to mov e fuel from the tank to the engine. • Sit on seat in operating position, depress clutch/brak e pedal and set parking brake .
14 MAINTENANCE BEFO RE EAC H USE T R A C T 0 R Inspect Muffler/Spark Arrester Lubrication Chart Check Brake Operation Clean Air Filter Change Engine Oil (with oil filter) Replace Air Filter Paper Cart.
15 MAINTENANCE FIG. 9 FIG. 8 B A TTER Y Y our tractor has a batter y charging system which is suf fi cient f or nor mal use. Howe ver , per iodic charging of the batter y with an automotive charger will e xtend its lif e. • K eep batter y and ter minals clean.
16 MAINTENANCE V- B E LT S Check V -belts for deterioration and wear after 100 hours and replace if necessar y . The belts are not adjustable. Re place belts if they begin to slip from w ear. TRANSAXLE COOLING K eep transaxle free from build-up of dirt and chaff which can restrict cooling.
17 MAINTENANCE CLEANING • Clean engine, batter y , seat, fi nish, etc. of all f oreign matter . • Keep fi nished surfaces and wheels free of all gasoline , oil, etc.
18 SER VICE AND ADJUSTMENTS W ARNING: T O A V OID SE RI OUS IN JU R Y , BEFORE PERFORMING ANY SER VICE OR ADJUST - MENTS: • Depress clutc h/brake pedal fully and set parking brake. • Place gearshift lever in neutral (N) position. • Place attachment c lutch in “DISENGAGED” position.
19 T O REPLA CE MO WER BLADE DRIVE BEL T (See Fig. 18) The mower b lade dr iv e belt ma y be replaced without tools. P ar k the tractor on le vel surf ace. Engage parking brake . BEL T REMO V AL - • Remove mo wer from tractor (See “T O REMO VE MO W ER” in this section of this man ual).
20 SER VICE AND ADJUSTMENTS FIG. 18 T O REPLA CE MO TION DRIVE BEL T (See Fig. 20) P ar k the tractor on le vel surf ace. En gage parking brake . Fo r a s sis tance, there is a belt installation guide decal on bottom side of left f ootrest. BEL T REMO V AL - • Remov e mower (See “TO RE MO VE MOWER” in this section of manual).
21 FIG. 20 ADJUSTMENT BOL T NEUTRAL LOCK GA TE GEARSHIFT LEVER FIG. 21 SER VICE AND ADJUSTMENTS TRANSAXLE PULLEY ST A TION ARY IDLER CLUTCHING IDLER ENGINE PULLEY CENTER SP AN KEEPER TRANSAXLE GEAR SHIFT LEVER NEU TRAL- ADJUSTMENT (See Fig. 21) The transaxle should be in neutral when the gear shift le ver is in neutral (N) (loc k gate) position.
22 FIG. 23 SER VICE AND ADJUSTMENTS REPLA CING B A TTER Y (See Figs. 24 and 25) W ARNING: Do not short battery ter mi nals by allowing a wrenc h or any other object to contact both terminals at the same time. Bef ore connect- ing battery , remo ve metal bracelets, wristwatch bands, rings, etc.
23 SER VICE AND ADJUSTMENTS ENGINE T O AD JUST THRO TTLE CON TROL CABLE The throttle control has been preset at the f actor y and ad just ment should not be necessar y . If adjustment is nec- es sar y , see engine manual. T O AD JUST CHOKE CON TROL The choke control has been preset at the f actor y and ad- just ment should not be necessar y .
24 ST ORA GE Immediately prepare your tr actor f or storage at the end of the season or if the tractor will not be used f or 30 days or more. W ARNING: Ne ver store the trac tor with gas o line in the tank inside a building where fumes may reac h an open fl ame or spark.
25 TR OUBLESHOO TING POINTS Will not start 1. Out of fuel. 1. Fill fuel tank. 2. Engine not “CHOKED” properly . 2. See “TO ST ART ENGINE” in Operation section. 3. Engine fl ooded. 3. W ait sever al minutes bef ore attempting to star t. 4. Bad spark plug.
26 TR OUBLESHOO TING POINTS PROBLEM CA USE CORRECTION Engine continues to run 1. F aulty operator-safe ty presence control system. 1. Check wiring, switches and connections. If not when operator leaves seat corrected, contact an authorized service center/ with attachment clutc h department.
27 REP AIR P ARTS TRA CT OR - - MODEL NUMBER WET2242STC SCHEMA TIC BATTERY FUSE IGNITION SWITCH RED RED RED BLACK IGNITION UNIT HEADLIGHTS REMOVABLE CONNECTIONS BLACK BLACK BLACK WHITE WHITE WHITE RED.
28 REP AIR P ARTS TRA CT OR - - MODEL NUMBER WET2242STC ELECTRICAL 28 29 26 24 42 43 27 27 25 41 27 27 40 33 90 30 8 2 1 27 16 16 52 48 22 21.
29 REP AIR P ARTS TRA CT OR - - MODEL NUMBER WET2242STC ELECTRICAL 1 163465 Batter y 12 V olt 28 Amp 2 74760412 Bolt Hex Hd 1/4-20unc X 3/4 8 176689 Box Battery 16 176138 Switch Interlock Push -In 21 .
30 REP AIR P ARTS TRA CT OR - - MODEL NUMBER WET2242STC CHASSIS AND ENCLOSURES 26 25 58 64 208 13 208 11 1 3 2 9 208 209 209 209 5 5 207 3 3 3 142 3 3 3 142 17 29 28 12 51 57 53 52 54 55 145 37 3 37 24 26 25 31 24 30 35 3 26 33 10 26 34 35 18 14 38 14 206 212 219 20 219 chassis-pl.
31 REP AIR P ARTS TRA CT OR - - MODEL NUMBER WET2242STC CHASSIS AND ENCLOSURES 1 174619 Chassis 2 176554 Drawbar 3 17060612 Screw 3/8-16x.75 5 155272 Bumper Hood/Dash 9 168336X010 Dash P/L 10 72140608.
32 REP AIR P ARTS TRA CT OR - - MODEL NUMBER WET2242STC DRIVE 29 28 112 14 41 38 39 57 51 74 75 78 76 77 1 25 19 24 2 53 35 34 37 36 35 62 36 59 212 55 77 61 22 27 26 6 113 18 51 5 18 6 85 52 30 32 32.
33 REP AIR P ARTS TRA CT OR - - MODEL NUMBER WET2242STC DRIVE KEY P ART NO . NO . DESCRIPTION KEY P ART NO . NO . DESCRIPTION 1 - - - - - - T ransaxle P eerless (206-545C) (Order par ts from transaxle.
34 REP AIR P ARTS TRA CT OR - - MODEL NUMBER WET2242STC STEERING ASSEMBL Y 44 51 54 5 9 5 7 7 9 4 3 32 43 6 43 8 10 40 11 8 6 9 46 46 8 6 9 2 47 47 26 30 28 1 41 42 37 36 37 38 12 39 68 67 67 67 13 65.
35 REP AIR P ARTS TRA CT OR - - MODEL NUMBER WET2242STC STEERING ASSEMBL Y 1 140044X428 Wheel Steering Auto Blac k 2 175131 Axle Asm F ront 3 169840 Spindle Asm Lh 4 169839 Spindle Asm Rh 5 6266H Bear.
36 REP AIR P ARTS TRA CT OR - - MODEL NUMBER WET2242STC ENGINE 2 1 OPTIONAL EQUIPMENT Spark Arrester 29 26 25 4 23 45 8 10 62 6 5 72 13 14 38 105 16 105 3 81 engine-tecumseh_16 33 37 33 44 46 32 31 41.
37 REP AIR P ARTS TRA CT OR - - MODEL NUMBER WET2242STC ENGINE NO TE: All component dimensions given in U .S. inches 1 inch = 25.4 mm 1 170803 Control Throt /Ch Flag 2 17720408 Screw He x Thd Cut 1/4-.
38 REP AIR P ARTS TRA CT OR - - MODEL NUMBER WET2242STC SEA T ASSEMBL Y KEY P ART NO . NO . DESCRIPTION KEY P ART NO . NO . DESCRIPTION 14 72050412 Bolt Rdhd Sht Nk 1/4-20 x 1-1/2 15 134300 Spacer Spl.
39 5 11 16 6 9 12 3 10 7 8 14 WHEELS & TIRES KEY P ART NO . NO . DESCRIPTION KEY P ART NO . NO . DESCRIPTION 6 2 1 5,8 4,10 3,9 1 1 7 REP AIR P ARTS TRA CT OR - - MODEL NUMBER WET2242STC DECALS 20 1 4 4 KEY P ART NO .
40 REP AIR P ARTS TRA CT OR - - MODEL NUMBER WET2242STC MO WER LIFT 15 20 16 17 18 20 20 15 20 4 5 6 2 3 1 6 5 4 7 8 12 11 31 32 31 32 19 19 13 13 13 13.
41 REP AIR P ARTS TRA CT OR - - MODEL NUMBER WET2242STC MO WER LIFT 1 159460 Wire Asm Inner/Sprg w/Plunger 2 159471 Shaft Asm Lift 3 105767X Pin Groov e 4 12000002 E Ring #5133-62 5 19211621 W asher 21/32 x 1 x 21 Ga.
42 REP AIR P ARTS TRA CT OR - - MODEL NUMBER WET2242STC MO WER DECK 15 14 13 11 10 9 8 16 68 37 184 30 31 32 33 146 148 145 150 45 144 147 147 142 149 142 54 52 53 55 56 34 1 46 44 21 24 25 26 27 2 28.
43 REP AIR P ARTS TRA CT OR - - MODEL NUMBER WET2242STC MO WER DECK 1 165892 Mower Dec k Assembly , 42" 2 72140506 Bolt 3 138017 Brack et Asm F r .
44 SER VICE NO TES.
45 LIMITED W ARRANTY The Manuf acturer warrants to the original consumer purchaser that this product as manufactured is free from def ects in materi- als and work man ship .
46 T E C U M S E H ® Issued Jan uar y 1980 Re vised Jan uar y 1991 T E C U M S E H ® SERVICE POLICY POLICY W ARRANTY LIMITED W ARRANTIES FOR NEW PEERLESS GEAR PO WER TRAIN COMPONENTS A.
47 15 DEGREES MAX. FOLD ALONG DOTTED LINE THIS IS A 15 DEGREE SLOPE ONLY RIDE UP AND DOWN HILL, NOT ACROSS HILL SUGGESTED GUIDE FOR SIGHTING SLOPES FOR SAFE OPERATION WARNING: To avoid serious injury, operate your tractor up and down the face of slopes, never across the face.
®.
デバイスWeed Eater WET2242STCの購入後に（又は購入する前であっても）重要なポイントは、説明書をよく読むことです。その単純な理由はいくつかあります：
Weed Eater WET2242STCをまだ購入していないなら、この製品の基本情報を理解する良い機会です。まずは上にある説明書の最初のページをご覧ください。そこにはWeed Eater WET2242STCの技術情報の概要が記載されているはずです。デバイスがあなたのニーズを満たすかどうかは、ここで確認しましょう。Weed Eater WET2242STCの取扱説明書の次のページをよく読むことにより、製品の全機能やその取り扱いに関する情報を知ることができます。Weed Eater WET2242STCで得られた情報は、きっとあなたの購入の決断を手助けしてくれることでしょう。
Weed Eater WET2242STCを既にお持ちだが、まだ読んでいない場合は、上記の理由によりそれを行うべきです。そうすることにより機能を適切に使用しているか、又はWeed Eater WET2242STCの不適切な取り扱いによりその寿命を短くする危険を犯していないかどうかを知ることができます。
ですが、ユーザガイドが果たす重要な役割の一つは、Weed Eater WET2242STCに関する問題の解決を支援することです。そこにはほとんどの場合、トラブルシューティング、すなわちWeed Eater WET2242STCデバイスで最もよく起こりうる故障・不良とそれらの対処法についてのアドバイスを見つけることができるはずです。たとえ問題を解決できなかった場合でも、説明書にはカスタマー・サービスセンター又は最寄りのサービスセンターへの問い合わせ先等、次の対処法についての指示があるはずです。
