ZenoahメーカーEB4401の使用説明書/サービス説明書
ページ先へ移動 of 28
The engine exhaust from this product contains chemicals known to the State of California to cause cancer, birth defects or other reproductive harm. WARNING O WNER / OPERA T OR MANU AL BA CKP A CK BLO WER 848-L3A-93A1 (704) EB4401 Thank you for purchasing a RedMax product.
Read this manual carefull y to understand all safety precautions, contr ols, pr oper operation and maintenance of y our RedMax blo wer . F ailure to do so could result in serious injury .
CONTENTS SAFETY PRECA UTIONS ·······························································4 OPERA T OR USE OF BLO WER FUEL W ORKING CON.
• Read this Blower Owner/Operator Manual carefully. Be sure you understand how to operate this unit properly before you use it. Failure to do so could result in serious injury. • Be sure to keep this manual handy so that you may refer to it later whenever any questions arise.
• To reduce the risk of injury associated with contacting rotating parts, stop the engine before installing or removing attachments. Do not operate without net in place . Always disconnect the spark plug before performing maintenance or accessing movable parts.
• Avoid using the blower where stable footing and balance are not assured. • Never to touch the spark plug or plug cord while the engine is in operation.
7 (1) Read owner's manual before operating this machine. (2) Wear head, eye and ear protection. (3) Handling this machine improperly could result in accidents causing serious injury or death. Read this manual carefully and practice using the blower until you are fully acquainted with all operations and have learned to use it correctly.
8 For safe operation and maintenance, symbols are carved in relief on the machine. According to these indications, please be careful not to make a mistake.
MODEL EB4401 Dimensions ( L x W x H ) mm ( in ) 480 x 535 x 495 (189 x 211 x 195) Dry Weight kg ( lbs ) 8.8 (19.3) Fuel Tank Capacity liter ( fl. oz ) 2.0 (67.6) Engine Type Air cooled 2-cycle gasoline engine Piston Displacement cc ( cu. in ) 41.5 (2.
Fuel 10 ■ RECOMMENDED MIXING RATIO GASOLINE 50:OIL 1 (When using RedMax/ZENOAH genuine oil) • Exhaust emission are controlled by the fundamental engine parameters and components(eq., carburation, ignition timing and port timing) without addition of any major hardware or the introduction of an inert material during combustion.
Fuel 11 4. Pour In the rest of gasoline and agitate again for at least one minute. As some oils may be difficult to agitate depending on oil ingredients, sufficient agitation is necessary for the engine to last long.
12 ■ CONTROL ARM 1.Hold the upper end of the control arm in hand and, while pulling it away from the unit, rotate arm forward (anti-clockwise as the arrow direction) until it clicks. (The first position) And if you want, you can rotate arm more forward until it clicks.
Operation the choke if it was set closed, and let the engine run at idle speed for a minute to warm it up. • When the engine fails to start after several attempts due to overchoking, open the choke and repeat pulling the rope. ■ ADJUSTING IDLE SPEED • The idling speed is set for 2000 rpm at the factory.
14 ■ FUEL FILTER •A clogged fuel filter may cause poor acceleration of the engine. Check periodically to see if the filter is clogged with dirt. The filter can be taken out of the fueling port using a small wire hook. Disconnect the filter assembly from the fuel pipe and unhook the retainer to disassemble it.
■ MUFFLER • Inspect periodically, the muffler for loose fasteners, any damage or corrosion. If any sign of exhaust leakage is found, do not use the blower and have it repaired immediately. •N ote that failing to do so may result in the engine catching on fire.
Disposal • When disposing your machine, fuel or oil for the machine, be sure to allow your local regulations. Storage BEFORE STORING THE BLOWER: 1.Drain a fuel tank and push the primer bulb until it becomes empty of fuel. 2.Remove the spark plug and drop a spoonful of 2-cycle oil into the cylider.
17 Pa r ts List NOTE : 1. Use RedMax/ZENOAH genuine parts as specified in the parts list for repair and/or replacement. 2. RedMax/ZENOAH does not warrant the machines, which have been damaged by the use of any parts other than those specified by the company.
18 Pa r ts List : EB4401 Fig.1 BLO WER GROUP (S/N 310001 and up).
19 EB4401 Fig.1 BLO WER GROUP (S/N 310001 and up) Key# Part Number Description Q'ty 1 2750-31111 VOLUTE CASE 1 2 2750-31212 VOLUTE COVER 1 3 2750-31150 SCREW M5x25 9 4 3490-11150 ELBOW 1 .
20 Pa r ts List : EB4401 Fig.2 ENGINE GROUP (S/N 310001 and up).
21 EB4401 Fig.2 ENGINE GROUP (S/N 310001 and up) Key# Part Number Description Q'ty 1 1490-12114 Cylinder 1 2 2756-12210 Gasket, base 1 3 1850-12130 Bolt M5x20 4 4 1484-13161 Insulator 1 5.
22 Pa r ts List : EB4401 Fig.3 CARBURET OR COMPONENTS (S/N 310001 and up) Key# Part Number Description Q'ty 1 1850-81450 Body ass’y 1 2 ————— Screen 1 3 ————— Valve .
23 Pa r ts List : EB4401 Fig.4 LEVER SET (S/N 310001 and up) Key# Part Number Description Q'ty 1 848L583300 LEVER SET 1 2 T4012-25100 • LEVER 1 3 3310-53331 • NUT M5 1 4 01642-20508 .
The California Air Resources Board and ZENOAH AMERICA, INC. are pleased to explain the emission control system warranty on your 2007 and later small off-road engine. In California, new small off-road engines must be designed, built and equipped to meet the state’s stringent anti-smog standards.
EMISSION-RELATED PARTS, FOR TWO (2) YEARS FROM THE DATE OF ORIGINAL DELIVERY OF THE UNIT, RedMax/ZENOAH AMERICA, INC. (THE COMPANY), THROUGH ANY RedMax DEALER, WILL REPAIR OR REPLACE, FREE OF CHARGE, FOR THE ORIGINAL AND EACH SUBSEQUENT PURCHASER, ANY PART OR PARTS FOUND TO BE DEFECTIVE IN MATERIAL AND/OR WORKMANSHIP.
Pièces en rapport avec les émissions de gaz d'échappement : RedMax/ZENOAH AMERICA, INC., par l'intermédiaire de n'importe quel revendeur RedMax, réparera gratuitement ou remplacera.
.
ZENOAH AMERICA, INC. 1100 Laval Blvd. Suite 110 Lawrenceville, Georgia 30043.
デバイスZenoah EB4401の購入後に（又は購入する前であっても）重要なポイントは、説明書をよく読むことです。その単純な理由はいくつかあります：
Zenoah EB4401をまだ購入していないなら、この製品の基本情報を理解する良い機会です。まずは上にある説明書の最初のページをご覧ください。そこにはZenoah EB4401の技術情報の概要が記載されているはずです。デバイスがあなたのニーズを満たすかどうかは、ここで確認しましょう。Zenoah EB4401の取扱説明書の次のページをよく読むことにより、製品の全機能やその取り扱いに関する情報を知ることができます。Zenoah EB4401で得られた情報は、きっとあなたの購入の決断を手助けしてくれることでしょう。
Zenoah EB4401を既にお持ちだが、まだ読んでいない場合は、上記の理由によりそれを行うべきです。そうすることにより機能を適切に使用しているか、又はZenoah EB4401の不適切な取り扱いによりその寿命を短くする危険を犯していないかどうかを知ることができます。
ですが、ユーザガイドが果たす重要な役割の一つは、Zenoah EB4401に関する問題の解決を支援することです。そこにはほとんどの場合、トラブルシューティング、すなわちZenoah EB4401デバイスで最もよく起こりうる故障・不良とそれらの対処法についてのアドバイスを見つけることができるはずです。たとえ問題を解決できなかった場合でも、説明書にはカスタマー・サービスセンター又は最寄りのサービスセンターへの問い合わせ先等、次の対処法についての指示があるはずです。
