BrinkmannメーカーProSeries 4495の使用説明書/サービス説明書
ページ先へ移動 of 36
D E S I G N C E R T I F I E D ™ OWNER’S MANUAL W ARNING HAZARDOUS EXPLOSION MA Y RESUL T IF THESE W ARNINGS AND INSTRUCTIONS ARE IGNORED. READ AND FOLLOW ALL W ARNINGS AND INSTRUCTIONS IN THIS MANUAL T O A VOID PERSONAL INJUR Y , INCLUDING DEA TH OR PROPERTY DAMAGE.
1 WE W ANT YOU TO ASSEMBLE AND USE YOUR GRILL AS SAFEL Y AS POSSIBLE. THE PURPOSE OF THIS SAFETY ALERT SYMBOL IS TO A TTRACT YOUR A TTENTION TO POSSIBLE HAZARDS AS YOU ASSEMBLE AND USE YOUR GRILL.
2 General W arnings . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 Installation and LP Cylinder Specifications and Safe Use . . . . . . . . . . . . . . 4–6 Connecting LP Cylinder and Hose / Regulator to Grill .
3 W ARNING • Never use natural gas in a unit designed for liquid propane gas. • Never use charcoal briquets or lighter fluid in a gas grill. • Leak test all connections before first use, even if grill was purchased fully assembled and after each tank refill.
4 W ARNING W ARNING LP GAS CYLINDER (NOT SUPPLIED WITH THIS GRILL) The LP cylinder is available for purchase at the same location the grill was purchased. The LP (Liquid Propane) gas cylinder specifically designed to be used with this grill must have a 20 lb.
5 The cylinder must also be equipped with: • A shut-off valve terminating in a T ype 1 gas cylinder valve outlet. • A T ype 1 valve that prevents gas flow until a positive seal is obtained. • An arrangement for vapor withdrawal. • A collar to protect the cylinder shut-off valve.
FILLING THE LP GAS CYLINDER: • Allow only qualified LP gas dealers to properly fill or repair your LP gas cylinder . • New tanks should be purged prior to filling; inform LP gas dealer if you are using a new tank. • DO NOT allow the cylinder to be filled beyond 80% capacity .
7 W ARNING • Never use your grill without leak testing all gas connections and hoses. See the section on "Leak T esting" in this manual for proper procedures. The pressure regulator and hose assembly supplied with your gas grill must be used.
LEAK TESTING: T o prevent fire or explosion hazard: • DO NOT smoke or permit ignition sources in the area while conducting a leak test. • Perform test OUTDOORS only in a well ventilated area. • Never perform a leak test with a match or open flame.
W ARNING 9 6. Check each place listed (A – H) for growing bubbles which indicates a leak. 7. T urn off gas supply at cylinder valve. 8. T urn on control knobs to release gas pressure in hose. 9. T urn control knobs to "OFF" position. 10. T ighten any leaking connections.
LIGHTING INSTRUCTIONS: Follow the instructions exactly . 1. OPEN THE GRILL LID before attempting to light a burner so that fumes do not accumulate inside the grill. An explosion could occur if grill lid is down. 2. Check that all burner control knobs and the cylinder valve are turned to the "OFF" position.
LIGHTING THE ROTISSERIE BURNER: 1. Open grill hood before lighting rotisserie burner . 2. Make sure control knob is in the "OFF" position. 3. Push and turn the control knob of that burner to the "HIGH" position. Continue to push in control knob while pressing electronic igniter for 3 – 5 seconds.
12 MA TCH LIGHTING THE SIDE BURNER: 1. Open the lid to the side burner before lighting. 2. Make sure control knob is in the "OFF" position. 3. Strike and carefully place a match approximately 1/2" (1 to 2 cm) from the burner . 4. T urn the side burner control knob to the "HIGH" position.
13 OPERA TING THE GRILL: Never use Charcoal or Lighter Fluid inside your Gas Grill. Read and follow all warnings and instructions contained in the preceding sections of this manual. BREAKING IN YOUR GRILL: • In manufacturing and preserving the components of your grill, oil residue may be present on the burner and cooking surfaces of your grill.
ROTISSERIE COOKING: • This grill has pre-drilled mounting holes for a rotisserie (rotisserie may or may not be included with your grill depending on the model purchased). Do not use a rotisserie not specifically manufactured for this grill. • Read and follow all warnings and instructions in the owner ’s manual provided with the rotisserie.
15 GRILL COOKING TIPS CLEANLINESS • Always wash hands thoroughly with soap and hot water prior to handling food and after handling raw meat, uncooked poultry or seafood.
BURNER ASSEMBL Y/MAINTENANCE • Although your burners are constructed of brass, they may corrode as a result of the extreme heat and acids from cooking foods. Regularly inspect the burners for cracks, abnormal holes, and other signs of corrosion damage.
17 TRANSPORTING AND STORAGE: • Never move a grill when it is hot or when objects are on the cooking surfaces. • Make sure that cylinder valve is shut off. After moving the grill check that all gas connections are free of leaks. Refer to instructions for Leak T esting.
TROUBLE SHOOTING Problem: Possible Causes: 1. Check LP cylinder fuel level. 2. Bad electrode spark. Check to see if the grill will match light. Electrode or collector may need adjustment. 3. Burner may not be properly seated. 4. Burner may be obstructed.
Y our grill's serial number and model number , and the contact information for Brinkmann Customer Service, are listed on a silver label found on the back of the grill or on the grill body side, under the side shelf. These questions and answers are for your general knowledge, and may not be applicable to your model grill.
Cleaning Stainless Steel Cooking Grills: W ash grills with a mild detergent and rinse with hot water before initial use and as needed. DO NOT use a commercial oven cleaner . For stubborn food residue, use a degreaser and fiber or brass cleaning brush.
ASSEMBL Y INSTRUCTIONS READ ALL SAFETY W ARNINGS & ASSEMBL Y INSTRUCTIONS CAREFULL Y BEFORE ASSEMBLING OR OPERA TING YOUR GRILL. WE RECOMMEND TWO PEOPLE WORK TOGETHER WHEN ASSEMBLING THIS UNIT . The estimated time of assembly for this grill is approximately 45 minutes.
(Proof of purchase will be required.) Inspect contents of the box to ensure all parts are included and undamaged. FOR MISSING P ARTS, PLEASE CALL CUSTOMER SERVICE A T 800-527-0717.
23 P AR TS BAG CONTENTS 1 Screwdriver 1 Hex nut wrench 1 AA/1.5V Alkaline battery 10 M5 X 10mm round head bolts 6 M6 X 12mm flat head bolts 8 M6 x 12mm round head bolts 16 M6 x 14mm hex head bolts 18 .
Choose a good, cleared assembly area and get a friend to help you put your grill together . Lay cardboard down to protect grill finish and assembly area.
Step 3 Attach back panel using six M6 x 50mm flat head bolts and four M6 x 12mm flat head bolts. NOTE: With the help of a friend, turn the cart assembly over . T ry to minimize the stress to the legs. Step 4 Attach two locking steel casters to the bottom of the right side caster bracket using four M6 x 14mm hex head bolts and star washers.
Step 6 Attach the door bracket (type “B”) to the bottom left leg tube using two M5 x 10mm round head bolts. Step 7 Attach the door bracket (type “A”) to the bottom of the right leg tube using two M5 x 10mm round head bolts. NOTE: With the help of a friend, turn the cart to its upright position.
Step 10 Place tank tray assembly over vent holes on bottom cart panel and secure using four M6 x 12mm round head bolts. T ank tray should slide in and out of cart freely . Step 1 1 Attach the door bracket to the side cart panels using four M6 X 50 mm flat head bolts.
Step 13 Insert right side door over lower hole on bottom of right cart panel then align door with cart frame. Depress spring pin located on top edge of door and slide door toward side cart panel until spring pin locks into hole in door bracket.
29 NOTE: When performing Step 15, lift grill body from front and rear panels to avoid injury to hands and fingers. Step 15 With the help of a friend, place grill body assembly on the assembled cart frame. Step 16 Align bolt holes located on the outside of the grill body assembly .
30 Step 17 Attach the side table assembly to left side grill body assembly by inserting two M6 x 12mm round head bolts through the top holes of the grill body assembly . Step 18 Place table over bolts, slide downward, then insert two M6 X12mm round head bolts into bottom holes of the side table assembly and into holes of grill body assembly .
Step 19 Place the heat tents on lower level of grill assembly directly above burners. Make sure the heat tents are in place of the slot by slide the back end to the slot. Step 20 Place stainless steel cooking grills on support ribs directly above heat tents.
Step 23 Slide basket into slots located on inside of left door . NOTE: Before sliding grease trays in place, pull out the regulator which is located under the side burner . Step 24 Slide the two grease trays into open front side under the control panel.
ProSeries 4495 (Assembled) 33 Step 25 T o install battery , unscrew igniter button cap. Insert battery with positive end towards button. Replace igniter button cap.
34 LOOK FOR THESE AND OTHER BRINKMANN ACCESSORIES A T YOUR LOCAL RET AILER WHERE SMOKERS ARE SOLD, OR ORDER DIRECT BY CALLING 800-468-5252. PROFESSIONAL SHISH-KABOB SKEWERS These heavy-duty , 18" shish-kabob skewers are extra-long for fabulous restaurant style kabobs.
140-4495-0 1/05, 4/05 Owner ’s Manual for Model 810-4495-0 The Brinkmann Corporation warrants to the original purchaser that the Brinkmann ProSeries™ 4495 is free from defects due to workmanship o.
デバイスBrinkmann ProSeries 4495の購入後に（又は購入する前であっても）重要なポイントは、説明書をよく読むことです。その単純な理由はいくつかあります：
Brinkmann ProSeries 4495をまだ購入していないなら、この製品の基本情報を理解する良い機会です。まずは上にある説明書の最初のページをご覧ください。そこにはBrinkmann ProSeries 4495の技術情報の概要が記載されているはずです。デバイスがあなたのニーズを満たすかどうかは、ここで確認しましょう。Brinkmann ProSeries 4495の取扱説明書の次のページをよく読むことにより、製品の全機能やその取り扱いに関する情報を知ることができます。Brinkmann ProSeries 4495で得られた情報は、きっとあなたの購入の決断を手助けしてくれることでしょう。
Brinkmann ProSeries 4495を既にお持ちだが、まだ読んでいない場合は、上記の理由によりそれを行うべきです。そうすることにより機能を適切に使用しているか、又はBrinkmann ProSeries 4495の不適切な取り扱いによりその寿命を短くする危険を犯していないかどうかを知ることができます。
ですが、ユーザガイドが果たす重要な役割の一つは、Brinkmann ProSeries 4495に関する問題の解決を支援することです。そこにはほとんどの場合、トラブルシューティング、すなわちBrinkmann ProSeries 4495デバイスで最もよく起こりうる故障・不良とそれらの対処法についてのアドバイスを見つけることができるはずです。たとえ問題を解決できなかった場合でも、説明書にはカスタマー・サービスセンター又は最寄りのサービスセンターへの問い合わせ先等、次の対処法についての指示があるはずです。
