DesaメーカーCGFP28PTの使用説明書/サービス説明書
ページ先へ移動 of 34
Shown with optional cabinet mantel and hearth base. ® WARNING: If the information in this manual is not followed exactly, a fire or explosion may result caus- ing property damage, personal injury, or loss of life. — Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance.
2 103414 UNVENTED PROP ANE/LP GAS FIREPLACE CGFP28P and CGFP28PT 1. This appliance is only for use with the type of gas indicated on the rating plate. This appliance is not con vertible for use with other gases. 2. Do not place propane supply tank(s) inside any structure.
3 103414 OWNER’S MANUAL PRODUCT IDENTIFICA TION Figure 1 - Log Base Assembly Figure 2 - Fireplace LOCAL CODES Install and use fireplace with care. Follow all local codes. In the absence of local codes, use the latest edition of The National Fuel Gas Code ANS Z223 , also known as NFPA 54*.
4 103414 UNVENTED PROP ANE/LP GAS FIREPLACE CGFP28P and CGFP28PT AIR FOR COMBUSTION AND VENTILA TION Today’s homes are built more energy effi- cient than ever. New materials, increased insulation, and new construction methods help reduce heat loss in homes.
5 103414 OWNER’S MANUAL AIR FOR COMBUSTION AND VENTILA TION Continued DETERMINING FRESH-AIR FLOW FOR FIREPLACE LOCATION Determining if You Have a Confined or Unconfined Space Use this work sheet to determine if you have a confined or unconfined space.
6 103414 UNVENTED PROP ANE/LP GAS FIREPLACE CGFP28P and CGFP28PT Outlet Air Ventilated Attic Outlet Air Inlet Air Inlet Air Ventilated Crawl Space To Crawl Space To Attic Or Remove Door into Adjoining.
7 103414 OWNER’S MANUAL INST ALLA TION Continued CAUTION: This fireplace cre- ates warm air currents. These cur- rents move heat to wall surfaces next to fireplace.
8 103414 UNVENTED PROP ANE/LP GAS FIREPLACE CGFP28P and CGFP28PT INST ALLA TION Continued INSTALLING GA3650T BLOWER ACCESSORY (For CGFP28P Model Only) 1. Remove fireplace screen (see Figure 7 ). Figure 8 - Removing Log Base from Fire- place NOTICE: Shut-off gas supply and disconnect heater from gas sup- ply.
9 103414 OWNER’S MANUAL INST ALLA TION Continued Figure 12 - Wire Attachment Figure 13 - Installing Bushings Bushing Location for Recessed Installation Bushing Location for Freestanding Installation Note: To prevent short circuit, white wire MUST be connected to motor.
10 103414 UNVENTED PROP ANE/LP GAS FIREPLACE CGFP28P and CGFP28PT INST ALLA TION Continued INSTALLING GA3650T BLOWER ACCESSORY (For CGFP28PT Model Only) 1. Remove fireplace screen (see Figure 15). NOTICE: Shut-off gas supply and disconnect heater from gas sup- ply.
11 103414 OWNER’S MANUAL WARNING: Never touch the blower wheel while in operation. Variable Fan Switch White White Black Green On 110/115 V.A.C. Blower Motor Black Black Black Off V ariable Fan S w itch W hite W hite B lack G reen O n 110/115 V .A .
12 103414 UNVENTED PROP ANE/LP GAS FIREPLACE CGFP28P and CGFP28PT 42" 16" Figure 23 - Placing Hearth Base Acces- sory Against Wall Figure 22 - Location of Nailing Flanges Nailing Flanges INST ALLA TION Continued INSTALLATION CLEARANCES Note: Clearances are the same if using optional cabinet mantel or built- in installation.
13 103414 OWNER’S MANUAL 34 3/4" 17 3/4" 33" 39 3/8" 27 7/8" 55 5/8" 34 3/4" INST ALLA TION Continued 9. If using an optional blower , install it no w . Follow instructions provided with the blo wer . 10. Connect fireplace to gas supply (see Connecting F ireplace T o Gas Supply , page 15).
14 103414 UNVENTED PROP ANE/LP GAS FIREPLACE CGFP28P and CGFP28PT 20" 24 1 /2 " 27 1 /2 " 30" 2 1 /2 " 6" 8" 10" Propane Supply Tank External Regulator Vent Pointing Down Figure 30 - External Regulator With Vent Pointing Down CAUTION: Use only new, black iron or steel pipe.
15 103414 OWNER’S MANUAL INST ALLA TION Continued Continued * Purchase the optional A.G.A. design-cer- tified manual shutoff valve from your dealer. See Accessories , page 32.
16 103414 UNVENTED PROP ANE/LP GAS FIREPLACE CGFP28P and CGFP28PT ON POSITION OFF POSITION INST ALLA TION Continued Test Pressures Equal To or Less Than 1/2 PSIG 1. Close manual shutoff v alve (see Fig- ure 34). 2. Pressurize supply piping system by ei- ther using compressed air or opening propane supply tank valv e.
17 103414 OWNER’S MANUAL 3 2 4 4 INST ALLA TION Continued INSTALLING LOGS WARNING: Failure to position the parts in accordance with these diagrams or failure to use only parts specifically approved with this heater may result in property damage or personal injury.
18 103414 UNVENTED PROP ANE/LP GAS FIREPLACE CGFP28P and CGFP28PT CAUTION: Do not try to adjust heating levels by using the manual shutoff valve. TO TURN OFF GAS TO APPLIANCE Shutting Off Fireplace Turn control knob clockwise to the OFF position. Shutting Off Burners Only (pilot stays lit) Turn control knob clockwise to the PILOT position.
19 103414 OWNER’S MANUAL IGNITOR Continued OPERA TING FIREPLACE Continued THERMOSTAT CONTROL OPERATION 1. Follow steps 1 thr ough 5 under Light- ing Instructions , page 18. 2. Depress contr ol knob and light pilot with match. 3. Keep contr ol knob pressed in f or 30 seconds after lighting pilot.
20 103414 UNVENTED PROP ANE/LP GAS FIREPLACE CGFP28P and CGFP28PT INSPECTING BURNERS Check pilot flame pattern and burner flame patterns often. PILOT FLAME PATTERN Figure 45 shows a correct pilot flame pattern. Figure 46 shows an incorrect pilot flame pattern.
21 103414 OWNER’S MANUAL CLEANING AND MAINTENANCE WARNING: Turn off fireplace and let cool before cleaning. CAUTION: You must keep control areas, burners, and cir- culating air passageways of fire- place clean. Inspect these areas of fireplace before each use.
22 103414 UNVENTED PROP ANE/LP GAS FIREPLACE CGFP28P and CGFP28PT OBSERVED PROBLEM When ignitor button is pressed, there is no spark at ODS/pilot When ignitor button is pressed, there is spark at ODS/.
23 103414 OWNER’S MANUAL OBSERVED PROBLEM One or both burners do not light after ODS/ pilot is lit Delayed ignition of one or both burners Burner backfiring during combustion Yellow flame in front b.
24 103414 UNVENTED PROP ANE/LP GAS FIREPLACE CGFP28P and CGFP28PT TROUBLESHOOTING Continued WARNING If you smell gas • Shut off gas supply. • Do not try to light any appliance. • Do not touch any electrical switch; do not use any phone in your building.
25 103414 OWNER’S MANUAL SER VICE HINTS When Gas Pressure Is Too Low • pilot will not stay lit • burners will ha ve delayed ignition • fire place will not produce specif ied heat When Gas Qual.
26 103414 UNVENTED PROP ANE/LP GAS FIREPLACE CGFP28P and CGFP28PT ILLUSTRA TED PA R T S BREAKDOWN LOG BASE ASSEMBLY VARIABLE MANUALLY- CONTROLLED MODEL CGFP28P 27 8 9 8 8 19 13 12 8 6 3 4 1 2 7 7-1 7-.
27 103414 OWNER’S MANUAL This list contains replaceable parts used in your fireplace. When ordering parts, follow the instructions listed under Replacement Parts on page 32 of this manual.
28 103414 UNVENTED PROP ANE/LP GAS FIREPLACE CGFP28P and CGFP28PT ILLUSTRA TED PA R T S BREAKDOWN LOG BASE ASSEMBLY THERMOSTAT- CONTROLLED MODEL CGFP28PT 18 6 27 8 9 8 8 19 13 12 3 4 1 2 7 7-1 7-2 10 .
29 103414 OWNER’S MANUAL P AR TS LIST LOG BASE ASSEMBLY THERMOSTAT- CONTROLLED MODEL This list contains replaceable parts used in your fireplace. When ordering parts, follow the instructions listed under Replacement Parts on page 32 of this manual. KEY NO.
30 103414 UNVENTED PROP ANE/LP GAS FIREPLACE CGFP28P and CGFP28PT ILLUSTRA TED PA R T S BREAKDOWN FIREPLACE 1 2 3 4 15 10 11 9 18 6 17 12 16 16 16 7 8 16 16 5 14 16 13 13 13 CGFP28P CGFP28PT.
31 103414 OWNER’S MANUAL P AR TS LIST FIREPLACE This list contains replaceable parts used in your fireplace. When ordering parts, follow the instructions listed under Replacement Parts on page 32 of this manual. CGFP28P CGFP28PT KEY NO. PART NUMBER DESCRIPTION QTY.
32 103414 UNVENTED PROP ANE/LP GAS FIREPLACE CGFP28P and CGFP28PT MANUAL SHUTOFF VALVE - GA5010 For all models. Manual shutoff valve with 1/8" NPT tap. Fits 1/2" NPT pipe. BLOWER ACCESSORIES- Increase air circulation to maximize heat distribution.
33 103414 OWNER’S MANUAL NOTES _______________________________________________________________________________________________ _______________________________________________________________________.
LIMITED WARRANTY COMFORT GLOW VENT-FREE PROPANE/LP GAS FIREPLACE DESA International warrants this product to be free from defects in materials and components for two (2) years from the date of first purchase, provided that the product has been properly installed, operated and maintained in accordance with all applicable instructions.
デバイスDesa CGFP28PTの購入後に（又は購入する前であっても）重要なポイントは、説明書をよく読むことです。その単純な理由はいくつかあります：
Desa CGFP28PTをまだ購入していないなら、この製品の基本情報を理解する良い機会です。まずは上にある説明書の最初のページをご覧ください。そこにはDesa CGFP28PTの技術情報の概要が記載されているはずです。デバイスがあなたのニーズを満たすかどうかは、ここで確認しましょう。Desa CGFP28PTの取扱説明書の次のページをよく読むことにより、製品の全機能やその取り扱いに関する情報を知ることができます。Desa CGFP28PTで得られた情報は、きっとあなたの購入の決断を手助けしてくれることでしょう。
Desa CGFP28PTを既にお持ちだが、まだ読んでいない場合は、上記の理由によりそれを行うべきです。そうすることにより機能を適切に使用しているか、又はDesa CGFP28PTの不適切な取り扱いによりその寿命を短くする危険を犯していないかどうかを知ることができます。
ですが、ユーザガイドが果たす重要な役割の一つは、Desa CGFP28PTに関する問題の解決を支援することです。そこにはほとんどの場合、トラブルシューティング、すなわちDesa CGFP28PTデバイスで最もよく起こりうる故障・不良とそれらの対処法についてのアドバイスを見つけることができるはずです。たとえ問題を解決できなかった場合でも、説明書にはカスタマー・サービスセンター又は最寄りのサービスセンターへの問い合わせ先等、次の対処法についての指示があるはずです。
