FrymasterメーカーSuper Cascade Filtration Systems CEの使用説明書/サービス説明書
ページ先へ移動 of 13
Frymaster, a member of the Commercial Food Equipment Service Association, recommends using CFESA Certified Technicians. Price: $6.00 24-Hour Service Hotline 1-800-551-8633 819-5726 10-99 Super Cascade.
.
1 SUPER CASCADE FILTRATION SYSTEM OPERATION MANUAL TABLE OF CONTENTS PAGE 1. PARTS ORDERING AND SERVICE INFORMATION 1 2. GENERAL 2 3. FILTER PREPARATION 2 4. FILTER OPERATIONS 3 5. FILTER TROUBLESHOOTING 5 6. WIRING DIAGRAM 10 1. PARTS ORDERING AND SERVICE INFORMATION 1.
2 2. GENERAL: a. The Flatbottom 24G (CE)/H250 Fryer System is equipped with the Super Cascade Filter Model 99. b. For consistent product quality, convenience and long-term savings, use a high-quality liquid frying compound. c. The frying compound should be filtered at least daily or even more frequently if cooking is heavy.
3 Hold down ring latched into position . 24G Drain Hole H250 Drain Hole Filter Pan Lid Drain Holes f. Unlatch and remove the hold down ring. Remove and discard old filter paper sheet from the filter pan. g. Clean out the filter pan. h. Place one sheet of filter paper in the bottom of the filter pan.
4 Air bubbles from the Oil Return Line 4. Open the oil return valve by turning the smaller red handle located under the control panel of the fryer. Move the handle left to right to open the oil return line.
5 Drain Valve Handle Oil Return Handle H250 Drain & Oil Return Handles Air bubbles from the Oil Return Line b. H250 Fryers: 1. Turn the lower red drain valve handle from left to right to open the drain valve. The photo below shows the drain valve in the open position.
6 5. FILTER TROUBLESHOOTING: The problems and possible solutions covered are those most commonly encountered. To troubleshoot, perform the test set-up at the beginning of each condition. Start at the top of the diagram. Arrows direct the troubleshooter through the sequence.
7 5.2 RATE OF OIL RETURN SLOWING? Blockage may be between the filter pan bottom and the oil return valve. No No Yes No Has the oil return rate improved? Go to the flowchart titled "Blockage between Filter Pan and the Oil Return Valve. Rate of oil return to the fryer is slowing.
8 5.3 BLOCKAGE BETWEEN FILTER PAN AND OIL RETURN VALVE? Does the pump motor run? Yes No Blockage has been determined to be between the filter pan bottom and the oil return valve. Disconnect oil line running from the filter pan to the pump at the pump end.
9 Plug is in the bottom of the filter pan or in the line from the filter to the pump. Disconnect the tubing from the filter pan to the motor. Make sure the pipe is cool. The line is clear. Reconnect hose to the pump inlet. Can you blow air through it? Yes No The line is clogged.
10 6. WIRING DIAGRAM (Super Cascade Filter (CE), 230VAC/50Hz) Block 810-0164 Power Cord 807-1697 230 VAC 24 VAC Connection from Fryer SCF24MCD Oil Return Transformer/Relay Assy Relay 24V DPDT 501-0058.
Frymaster, L.L.C., 8700 Line Avenue, PO Box 51000, Shreveport, Louisiana 71135-1000 Shipping Address : 8700 Line Avenue, Shreveport, Louisiana 71106 TEL 1-318-865-1711 FAX (Parts) 1-318-219-7140 (Tech Support) 1-318-219-7135 Price: $6.
デバイスFrymaster Super Cascade Filtration Systems CEの購入後に（又は購入する前であっても）重要なポイントは、説明書をよく読むことです。その単純な理由はいくつかあります：
Frymaster Super Cascade Filtration Systems CEをまだ購入していないなら、この製品の基本情報を理解する良い機会です。まずは上にある説明書の最初のページをご覧ください。そこにはFrymaster Super Cascade Filtration Systems CEの技術情報の概要が記載されているはずです。デバイスがあなたのニーズを満たすかどうかは、ここで確認しましょう。Frymaster Super Cascade Filtration Systems CEの取扱説明書の次のページをよく読むことにより、製品の全機能やその取り扱いに関する情報を知ることができます。Frymaster Super Cascade Filtration Systems CEで得られた情報は、きっとあなたの購入の決断を手助けしてくれることでしょう。
Frymaster Super Cascade Filtration Systems CEを既にお持ちだが、まだ読んでいない場合は、上記の理由によりそれを行うべきです。そうすることにより機能を適切に使用しているか、又はFrymaster Super Cascade Filtration Systems CEの不適切な取り扱いによりその寿命を短くする危険を犯していないかどうかを知ることができます。
ですが、ユーザガイドが果たす重要な役割の一つは、Frymaster Super Cascade Filtration Systems CEに関する問題の解決を支援することです。そこにはほとんどの場合、トラブルシューティング、すなわちFrymaster Super Cascade Filtration Systems CEデバイスで最もよく起こりうる故障・不良とそれらの対処法についてのアドバイスを見つけることができるはずです。たとえ問題を解決できなかった場合でも、説明書にはカスタマー・サービスセンター又は最寄りのサービスセンターへの問い合わせ先等、次の対処法についての指示があるはずです。
