Gravelyメーカー985114 - 16 HPの使用説明書/サービス説明書
ページ先へ移動 of 23
Owner/Oper ator Man ual Models 985114 - 16 HP 985115 - 8.5 HP 985117 - 13.5 HP 08468600E 6/00 Supersedes 08468600,A-D Printed in USA Pr of essional 2-Wheel T ractor.
2 ENGLISH 1. Direction Control Le ver 2. Steering Brake Handlebar 3. Gear Shift Le ver (Hi/Lo w Gear) 4. Operator Presence Control 5. PT O Control 6. Ignition Switch 7. Kick Stand 8. Throttle Control 9. Hourmeter 10. Brak e Handle Cross Bar 11. Range Shift Handle (T wo Speed Axle) 12.
3 Controls and Features . . . . . . . . . . . . . . . . . . . . . 2 Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 Safety . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 Assembl y . . . . . . . . . . . .
4 SAFETY ALERTS Look f or these symbols to point out impor tant safety precautions . The y mean: Attention! P ersonal Saf ety Is In volved! Become Alert! Obey The Message! The saf ety aler t symbol is used in decals on the unit and with proper operation procedures in this manual.
5 SAFETY DECALS AND LOCATIONS AL W A YS replace missing or damaged Saf ety Decals. Ref er to figure below f or Safety Decal locations. 1. D ANGER! T o av oid serious injur y or death.
6 2. Saf ety First 3. Saf ety First 4. CA UTION SAFETY RULES Preparation Improper use of this tractor can injure people and damage the equipment. P eople using or servicing this tractor must read and f ollow the instructions in this manual.
7 Operation Be cer tain that all shields, guards, and interlock s witches are in the correct position and operating properly . Bef ore star ting the engine, put the PT O le ver in the “ OFF ” position and the gear shift le v er in the neutr al “ N ” position.
8 TOOLS REQUIRED Phillips Screwdriv er , Needle Nose Pliers, Open-End Wrench: 3/8, 7/16, 9/16 & 3/4 and or Adjustable Wrench REMO VE UNIT FROM CAR T ON Remov e the unit and components from the shipping container . ASSEMBL Y P osition Handlebar 1. Disconnect Ignition Harness.
9 Assemble Steering Brakes (Optional) 1. Remov e nut and bolt from handle br ac kets . (Figure 4) Left Hand Rod: 2. Hook the rear of the left hand brak e rod into the left side of the brak e handle weldment. Bef ore installing on hitch, place the f orward end of the left hand brak e rod below m uf fl er brace .
10 CONTROLS AND FEATURES NO TE: Read the attachment(s) and tractor manuals bef ore operating the equipment. Operate the tractor only from the operator ’ s position, behind the handlebars. Ser vice the tractor and attachment bef ore operating. Ref er to Controls and F eatures f or the f ollo wing.
11 FILL FUEL T ANK Add fuel to the fuel tank as needed. See engine manual f or the correct type and gr ade of fuel. 1. Put the unit in an open area. 2. Stop the engine and lock the br ake . 3. Clean the fuel cap and the area around the fuel cap to pre v ent dir t from entering the fuel tank.
12 NO TE: One of the operator presence control le v ers must be held do wn at all times whene v er the transmission is in gear and/or the PT O lev er is in the “ ON ” position. 6. T o go forw ard, mov e the direction control le v er f orward until the le ver sta ys in the f orw ard position.
13 CHECK ENGINE OIL Check the engine oil daily , or before each use . Nev er operate the engine when the oil le v el is belo w the low mark on the dipstick. See the engine manual f or oil change schedule and detailed instructions. CHECK AIR CLEANER Check the air cleaner daily .
14 3. Clean the dipstick tube and the dipstic k (Figure 6). 4. Remov e the dipstic k, wipe it with a clean cloth or tow el and put it back in the tube . 5. Pull the dipstick out again and look at the oil. 6. If the oil le v el is below the lo w mark on the dipstick, add oil.
15 FORWARD-RE VER SE CLUTCH T o adjust the rev erse clutch (Figure 8) : 1. Loosen the jam nuts on the end of the control e xtension rod in the fwd-re v control rod. 2. Adjust the rear nut so that the direction control le v er stops 15 degrees past v er tical to the rear .
16 PT O BRAKE T o adjust the PTO br ake: 1. Remov e the attachment and lo wer the rear of the tractor to the ground. 2. Carefully clean the front of the transmission. Remov e the quic k hitch studs from the transmission. 3. Remov e the quic k hitch casting and PT O brake assembly (Figure 10).
17 SLIP CLUTCH T o adjust the slip clutch: 1. Remov e the attachment and lo wer the rear of the tractor to the ground. 2. Carefully clean the front of the transmission. 3. Remov e the quic k hitch studs from the transmission. 4. Remov e the quic k hitch PT O assembly and PT O brak e assembly .
18 Check each item in "Bef ore Storage" in the Maintenance Schedule. See Engine Manual f or detailed instructions on prepar ing the engine f or storage . When The T ractor Will Not Be Operated For T wo Months Or More: 1. Do the daily and 25-hour maintenance, b ut do not add gasoline.
19 Engine stops when PT O or Fwd-Rev is engaged. 1. Operator presence handle not pressed 2. Operator presence handle out of adjustment 3. F aulty switch 1. Press and hold at least one operator presence control. 2. Call your dealer . 3. Replace s witch.
20 ACCESSORIES See your authorized Gr av ely dealer to add these optional accessories. Mowing 78500600 30 ” Mo wer Drive (Short) 78500700 30 ” Mo wer Drive (Long) 78500800 40 ” Commercial Mo wer.
21 SER VICE P AR TS Be sure to alwa ys use gen uine Gra v ely par ts to keep your Sno-Thro running lik e new . P ar t no . Qty Description 03621100 1 Batter y (Robin Model) 04202200 1 Batter y (Briggs.
22 W ARRANTY 2 Y ear Limited W arranty Ariens Company hereby warrants to the original consumer purchaser that all Grav ely T wo-Wheel, Professional G, Pro , and ProMaster products will be free from defects in material and workmanship for a period of two (2) years from the date of purchase or 1000 hours, whiche v er comes first.
GRA VEL Y A Division of Ariens Company 655 West Ryan Str eet P .O. Box 157 Brillion, WI 54110-0157 920-756-2141 Fax 920-756-2407 www .gravely .com.
デバイスGravely 985114 - 16 HPの購入後に（又は購入する前であっても）重要なポイントは、説明書をよく読むことです。その単純な理由はいくつかあります：
Gravely 985114 - 16 HPをまだ購入していないなら、この製品の基本情報を理解する良い機会です。まずは上にある説明書の最初のページをご覧ください。そこにはGravely 985114 - 16 HPの技術情報の概要が記載されているはずです。デバイスがあなたのニーズを満たすかどうかは、ここで確認しましょう。Gravely 985114 - 16 HPの取扱説明書の次のページをよく読むことにより、製品の全機能やその取り扱いに関する情報を知ることができます。Gravely 985114 - 16 HPで得られた情報は、きっとあなたの購入の決断を手助けしてくれることでしょう。
Gravely 985114 - 16 HPを既にお持ちだが、まだ読んでいない場合は、上記の理由によりそれを行うべきです。そうすることにより機能を適切に使用しているか、又はGravely 985114 - 16 HPの不適切な取り扱いによりその寿命を短くする危険を犯していないかどうかを知ることができます。
ですが、ユーザガイドが果たす重要な役割の一つは、Gravely 985114 - 16 HPに関する問題の解決を支援することです。そこにはほとんどの場合、トラブルシューティング、すなわちGravely 985114 - 16 HPデバイスで最もよく起こりうる故障・不良とそれらの対処法についてのアドバイスを見つけることができるはずです。たとえ問題を解決できなかった場合でも、説明書にはカスタマー・サービスセンター又は最寄りのサービスセンターへの問い合わせ先等、次の対処法についての指示があるはずです。
