HobartメーカーUW50 ML-27838の使用説明書/サービス説明書
ページ先へ移動 of 16
701 S. RIDGE A VENUE TROY , OHIO 45374-0001 937 332-3000 www .hobartcorp.com FORM 18241 Rev . G (Aug. 2007) UW50 UTENSIL WASHER MODEL UW50 ML-27838.
– 2 – ©HOBART , 2007 T ABLE OF CONTENTS GENERAL ....................................................................................................................... ....................................... 3 INST ALLA TION .....................
– 3 – INST ALLA TION, OPERA TION AND CARE OF MODEL UW50 UTENSIL W ASHER SA VE THESE INSTRUCTIONS GENERAL The UW50 Utensil W asher is the answer to volume utensil washing problems in your kitchen, bakery or supermarket operation.
– 4 – UW50 with 10KW Electric T ank Heat with or without 14KW Electric Booster – Installation Diagram: D-812969 sheet 1.
– 5 – UW50 with Steam T ank Heat (Injector or Coil) with or without 14KW Electric Booster – Installation Diagram: D-812969 sheet 2.
– 6 – UW50 with Gas T ank Heat with or without 14KW Electric Booster – Installation Diagram: D-812969 sheet 3.
– 7 – PLUMBING CONNECTIONS Plumbing connections must comply with applicable sanitary , safety and plumbing codes. W ater Supply Connection W ater must be proper hardness. Recommended water hardness is 1 grain or less. Higher hardness may cause excessive formation of lime scale.
– 8 – VENTING REQUIRED WITH GAS HEA T (OPTIONAL WITH STEAM OR ELECTRIC HEA T) The Hobart UW50 Utensil W asher , equipped for gas tank heat, is not provided with a fl ue collar and is not intended to have the fl ue directly connected to a ventilation system.
– 9 – RA TE OF EXHAUST FLOW CALCULA TIONS (FIG. 2) Based on the International Mechanical Code (latest edition). Fig. 2 Canopy size and location The inside lower edge of canopy-type T ype I and II .
– 10 – DETERGENT FEEDER (OPTIONAL BY OTHERS) If installing a detergent feeder (by others), remove cap to expose 7 / 8 " diameter hole at rear of machine.
– 1 1 – Fig. 3 OPERA TION CONTROLS (FIG. 3) PL-56351 OFF START POWER CYCLE 2 4 6 SELECTOR SWITCH FILL NOTE: Opening the door during cycles will cause cycle to start over at the beginning. DRAIN LEVER (Fig. 4) Drain lever is located inside the wash chamber (middle front with door open).
– 12 – GENERAL OPERA TING INSTRUCTIONS Keep the utensil washer clean to provide best results. Do not allow foreign objects to enter the unit, especially metallic contaminants. Do not wash aluminum utensils in the utensil washer . The caustic detergent and high water temperature will cause aluminum oxide formation (black).
– 13 – DOS AND DON'TS FOR YOUR NEW HOBART UTENSIL W ASHER DO ensure proper water hardness (1 grain or less). T otal Dissolved Solids (TDS) must be 50 ppm or greater . Chlorides must not exceed 50 ppm. DO pre-scrap dishes thoroughly . DO use only detergents recommended by your chemical professional.
– 14 – MAINTENANCE Disconnect electrical power supply and follow lockout / tagout procedures. MOTOR The motor has permanently sealed bearings and requires no lubrication. W ASH AND RINSE ARMS All wash arms and rinse arms should turn freely and continue turning for a few seconds after being whirled by hand.
– 15 – TROUBLESHOOTING SYMPTOM POSSIBLE CAUSE Utensils spotted or not clean Overloaded rack. Low water level. W ater conditions: — Incorrect rinse water temperature. Refer to W A TER SUPPL Y CONNECTION, page 7. — Excessive water hardness may indicate that a water softener is needed.
– 16 – FORM 18241 Rev G (Aug. 2007) PRINTED IN U.S.A. SERVICE In the event a gas ori fi ce fi tting shall be adjusted or replaced, have it serviced by quali fi ed personnel. Contact your Hobart service of fi ce for any repairs or adjustments needed on this equipment.
デバイスHobart UW50 ML-27838の購入後に(又は購入する前であっても)重要なポイントは、説明書をよく読むことです。その単純な理由はいくつかあります:
Hobart UW50 ML-27838をまだ購入していないなら、この製品の基本情報を理解する良い機会です。まずは上にある説明書の最初のページをご覧ください。そこにはHobart UW50 ML-27838の技術情報の概要が記載されているはずです。デバイスがあなたのニーズを満たすかどうかは、ここで確認しましょう。Hobart UW50 ML-27838の取扱説明書の次のページをよく読むことにより、製品の全機能やその取り扱いに関する情報を知ることができます。Hobart UW50 ML-27838で得られた情報は、きっとあなたの購入の決断を手助けしてくれることでしょう。
Hobart UW50 ML-27838を既にお持ちだが、まだ読んでいない場合は、上記の理由によりそれを行うべきです。そうすることにより機能を適切に使用しているか、又はHobart UW50 ML-27838の不適切な取り扱いによりその寿命を短くする危険を犯していないかどうかを知ることができます。
ですが、ユーザガイドが果たす重要な役割の一つは、Hobart UW50 ML-27838に関する問題の解決を支援することです。そこにはほとんどの場合、トラブルシューティング、すなわちHobart UW50 ML-27838デバイスで最もよく起こりうる故障・不良とそれらの対処法についてのアドバイスを見つけることができるはずです。たとえ問題を解決できなかった場合でも、説明書にはカスタマー・サービスセンター又は最寄りのサービスセンターへの問い合わせ先等、次の対処法についての指示があるはずです。