MaytagメーカーHE3966Tの使用説明書/サービス説明書
ページ先へ移動 of 36
l VLYI : AG Series Nine ELECTRIC WATE R H EATE R USER'S GUIDE Model Numbers HE2930T HE3930T HE2940L H E 3940 L HE2940S HE3940S HE2 940T HE3940T H E 2950S H E 3950S HE2950T HE3950T HE2966T HE3966T.
Safety In str u ctions _ WARNING A WARNING Improper installation, adjustment, alteration, service At the tim e of manufacture this water heater was pro- o r m a inte n a n ce can ca us e DEA TH , SE RIO US BO DILY v ided with a combi na tion temperature - p re ss u re s reli e f INJURY , O R PR O PERTY DAMAGE.
Safety Instructions (cont ' d) A WARNING WATER HEA T ERS EQUIPPED FOR ONE VOLTAGE O NLY: This water heater is equipped for one type voltage only. Check the rating plate near the bot- tom access panel for the correct voltage. DO N O T use this water heater with any volta g e other than the one shown on the model rating plate.
Table of Contents Safety Instructions ..................................................................................................................................... 2-3 Table of Contents .........................................................
Customer Information T ha n kYou f or purchasing a Maytag water he a ter. • The installation must conform with the instructions in this manual; electric company rules; and Local Co d es , or in the Properly installe d and maintained , it should give you years of absence of Local Codes , with the latest edition of the tr o uble free service.
Product Specifications Mode l HE29 3 0T HE29 4 0L HE29 4 0S HE29 4 0T HE 3 9 3 0T HE 3 9 4 0L HE 3 9 4 0S HE 3 9 4 0T Tank C apacity In G al lons 3 0 40 4 0 40 E l ement Upper 3800 3800 38 0 0 3800 W at ta ge et_ ovo k _wer 3800 I _500 3800 1_500 3800 I 55® 3800 I _500 Recove ry R ate Upp e r 1 7.
Accesso r ies and Tools Needed Accessories To simplif y the install a tion M a ytag h as av a il ab le the installa- tion pa r ts shown below. You ma y or ma y not need all of these accessories depending o n your type of irtstaUation. Call Maytag Customer Service at 1-800-788-8899 for an autho- rized installer.
In st r uctio n s for I nstallatio n Removing the O ld Water Heater QTurn "OFF" electrical supply to the water heater. (' _ a. If you have piping to the water heater, the two copper copper water pipes can be cut with a hacksaw approxi- m a tely four inches away from where they connect to the water he a ter.
Instructions for Installation (cont'd) Locating The New Water A CAUTIO N Heater WATER HEATERS EVENTUALLY LEAK: Installation of the water heater must be accomplished in such a manner that if the t.
Instructions for Instal l ation (cont ' d) The Convertible Lower Element The Up per E l ement , is a con v e nt i on a l 3800 wat t e l e m en t which o nly o p era t e s a t i t s ra t ed wa t tage on 24 0 v ol t s. ( See ra t - i n g p la t e on wa t e r h e a t e r) .
Instr u ctions for In sta l lation (cont ' d) Water Piping A WARNING [ 2 . Look at the top cover of the water heater . The cold water H o I"rER WATER CAN S CA LD: Water h eaters are inlet is marked cold. Connect the cold water pipe to the I intended to produce h o t water.
Instructions for Installation (cont'd) Temperature-Pressure Relief Valve •,WARNING _ ,WARNING I At th e time of m anufacture th is water heater was provid- The temperature-p _ lv e must be m anu - ed with a combination temperature-pressuresrelief valv e ally operated at l e ast onc e a year.
Instructions for Installation (cont'd) Filling t he W a t er Hea t er To fi l l the water heater with water: A W A R NING 1. C l o s e t he wate r heate r drain valve b y tu r ning the handle to Bef o re ma kin g t h e c on versi o n t o 55 00 watt s, c h ec k the right (clockwise).
I nstr u ctio n s for Installatio n (cont'd) Converting the Lower Element (cont'd) 1. Befo r e beginning t h e c o nve rs i o n t u rn "OF F " e l ect ri c 4 . L i ft ou t the tab a s s h o wn to uncfi p t h e termin al cov e r fr om power s upply t o t he wa t er hea t e r , t he t he r mo st a t .
Instructions for Installation (cont ' d) Converting the Lower Element (cont'd) 7 . T h e wir e r e mov ed from t er minal 2 h as a loo p ed end . It 11. R eplace the access p anel . must rem ai n looped and now be placed (as shown) on top of the buss bar, o v er the opening of terminal 2 , and sec u red usin g the remaining sc rew .
Instructions for Installation (cont'd) Wiring Diagr a ms T o ELE R , C POWERSUPPLY STANDARD WIRING FOR 2 WIR E LEAD WATER HEATERS BLACK [ NON - SIMULTAN E OUS OPERATI O N , , _ , 240 V O LT D O UBLE ELEMENT D r" UPPER E .
Instructions for Installation (cont'd) Wiring A CAUTI O N C. Flexible metal co n duit or 3 metallic tubing shall be p e rmit- Never use this water heater unless it is completely ted f o r gr o unding ifaU the follo w ing conditions aremet: full of water.
Instructions for Installation (cont'd) Installation Checklist COLD HOT 1. Whether or not the element conversion is made, the model rating plate must be marked. Using a hard point ink pen , check the appropriate block within the model rating plate, which is located adjacent to the lower access panel.
Service and Maintenance T emperature Regulation _ WARNING H O TTER WATER CAN SCALD: Water heaters a re intended t o produce hot water. Water heated to a temp e rature which will satisfy clothes washing , dish washing, and other sanitiz i ng needs can scald and permanently injure you upon contact.
Service and Maintenance (cont'd) Thermostat Adjustments Temperatur e-Pr e ssu r e Relief Valve Operation If the upper thermostat is adjusted above the factory preset point of 1 2 0°F (Hot), it cannot be set higher than the lower The temperature-pressure relief valve must be manually oper- thermostat setting.
Service and Maintenance (cont'd) Draining Element Cleaning / I _ . _ 1 Th e water h e ater sh o uld be drained if being shut down during nep, acement free z ing tem p eratures.
Service and Maintenance (cont ' d) 3. Attach a h o s e to the water heate r d r ain valve and put the 6 . Lift out the tab as shown to unclip the terminal cover from other end in a floor drain or outdoo r s. Open the wa t er the thermostat. The terminal c o ver can now be removed heater drain valve.
Service and Maintenance (cont ' d) Element Cleaning / Replacement (cont'd) 10. A new gasket should be used in all cases to prevent a pos- 1 5 . Reconnect the two wires to the element and then check slble water leak. (See Element Gasket in the Repair Parts to make sure the thermostat remains firmly against the Chart) .
Service and Maintenance (cont'd) Drain Valve Washer Replacement 18. R ep l ace a cc ess panel. N O TE : F o r replacement, u se a 17 / _" x l y e" x 1 / s" thick wash e r ava il able at y our nearest har d ware st o re. For o r d ering a 1 9 .
Troubleshooting Start Up Conditions THERMAL EXPANSION S me lly w a t er m a y b e e li m i n a te d o r re duc e d i n s om e w a t e r heate r mode l s b y rep lac ing th e a node(s) w i t h one o f .
Troubleshooting (cont ' d) 1. Before beginnin g , turn "OFF" elect r ical power suppl y to NOT ENOUGH O R NO HOT WATER t he wa t er hea t e r. 1 . In a new in st a l lation, t he wat e r hea t er m ay n o t be p r oper- _ " l y c on n ecte d .
Troubleshooting (cont ' d) Leakage Checkpoints Use this guide to check a "Leaking" water heater. Many sus- [ A CAUTIO N ] pected "Leakers" are not leakin g ta n ks. Often the sou r c e of I Read this manual_ efore checking the I the wat e r can be foun d and co r recte d .
Repair Parts List MAY'I'AG ELECTRIC WATER HEATERS MODEL NUMBERS HE2930T 30 GALL O N HE3930T 30 GALLON HE2940S 40 GALL O N HE3940S 40 GALLON HE2940T 40 GALLON HE394 0 T 40 GALL O N NOTE : U PP ER ELEMENT: Th ese wa ter hea ter s a r e e quipp e d w i t h 38 00 w at t e l emen ts .
Repair Parts List (cont'd) MAYTAG E LECTRICWATER HEATERS M O DEL NUMBERS HE2 9 30T 30 GALL O N HE3 9 30T 30 GALLON HE2940S 40 GALL O N HE3940S 40 GALL O N HE2 9 40T 40 GALLON HE3940T 40 GALLON M O DEL NUMBERS KEY PART HE293OT HE3930T HE2940S HE3940S HE2940T HE3940T N O .
Repair Parts List (cont'd) MAY ' rAG ELECTRICWATER HEA TE RS MODEL NUMBERS HE2940L 40 GALLON HE3940L 40 GALL O N NOTE: UPPER ELEMENT: These water heaters are equipped with 3800 watt d ements. LOWER ELEMENT: These water heaters are equipped with factory installe d convertible elements, which can be operated at 3800 wat t s or 5500 wa tts.
R e pair Parts List (cont'd) MAYTAG ELECTRIC WATER HEATERS M O DEL NUMBERS HE2940L 40 GALL O N HE3940L 40 GALL O N MODEL NUMBERS KEY PART HE2940L HE3940L N O .
Repair Parts List (cont'd) MAYTAG ELECTRIC WATER HEATERS M O DEL NUMBERS HE2950S 50 GALLON HE3950S 50 GALLON HE2950T 50 GALLON HE3950T 50 GALL O N HE2966T 66 GALLON HE3966T 66 GALL O N NOTE : U P PER ELEME NT : These water he a t er s are e q uippe d w it h 3 8 00 wa t t e l e m ents.
Repair Parts List (cont'd) MAYTAG ELECTRIC WATER HEATERS M O DEL NUMBERS HE2950S 50 GALL O N HE3950S 50 GALL O N HE29SOT 50 GALLON HE3950T 50 GALLON HE2966T 66 GALL O N HE3966T 66 GALL O N MODEL NUMBERS KEY PART HE2950S HE3950S HE2950T HE3950T HE2966T HE3966T NO.
Repair Parts L ist (cont ' d) MAYTAG ELECTRIC WAT ER HEATERS MAYTAG / STATE PARTNUMBER C O NVERSI O N KEY MAYTAG STATE 66001007 9002437 66001008 9002436 66 00 1 0 09 90 0 24 3 5 66001010 9002403 .
Notes 35.
Warranty FULL O NE YEAR WARRAN T Y F o r One Yea r f ro m t h e date of O r iginal R etail Purc h ase , any par t wh ic h fail s in nor m al h ome u s e w ill b e r ep air ed or replaced free of charge. If a leak occurs in the Tank , a new water heater of the closest capacity and quality then available, will be replaced free of charge.
デバイスMaytag HE3966Tの購入後に（又は購入する前であっても）重要なポイントは、説明書をよく読むことです。その単純な理由はいくつかあります：
Maytag HE3966Tをまだ購入していないなら、この製品の基本情報を理解する良い機会です。まずは上にある説明書の最初のページをご覧ください。そこにはMaytag HE3966Tの技術情報の概要が記載されているはずです。デバイスがあなたのニーズを満たすかどうかは、ここで確認しましょう。Maytag HE3966Tの取扱説明書の次のページをよく読むことにより、製品の全機能やその取り扱いに関する情報を知ることができます。Maytag HE3966Tで得られた情報は、きっとあなたの購入の決断を手助けしてくれることでしょう。
Maytag HE3966Tを既にお持ちだが、まだ読んでいない場合は、上記の理由によりそれを行うべきです。そうすることにより機能を適切に使用しているか、又はMaytag HE3966Tの不適切な取り扱いによりその寿命を短くする危険を犯していないかどうかを知ることができます。
ですが、ユーザガイドが果たす重要な役割の一つは、Maytag HE3966Tに関する問題の解決を支援することです。そこにはほとんどの場合、トラブルシューティング、すなわちMaytag HE3966Tデバイスで最もよく起こりうる故障・不良とそれらの対処法についてのアドバイスを見つけることができるはずです。たとえ問題を解決できなかった場合でも、説明書にはカスタマー・サービスセンター又は最寄りのサービスセンターへの問い合わせ先等、次の対処法についての指示があるはずです。
