Searsメーカー917.255741の使用説明書/サービス説明書
ページ先へ移動 of 44
OWNERS MANUAL MODE L NO, 917_255741 Caution: Read Rules for Safe Operation and Instructions Carefully 12 H.P. 38" RIDING LAWN TRAC ELECTRIC TOR START Assembly Installation Operation Repair Parts .
CONGRATULATIONS on your purchase of a Sears Lawn Tractor It has been designed, engineered and manufactured to give you the best possible dependability and performance.
FOR SAFE OPERAT O NARNING: This unit is equipped with an internal combustion engine and should not be used on or near any unimproved forest- covere6, brush,covered or grass-covered land unless the engine's exhaust system is equipped with a spark arrestor meeting applicable Local or statelaws(if any) Ifasparkarrester is used.
To assemble your Tractor you will need: two 7/16" wrenches, two 9/16" wrenches, two 1/2" wrenches, a 3/4" wrench and a utility knife NOTE: RIGHT HAND (R,H) AND LEFT HAND (LH.
BATTERY ONSTALLATDON WEAR EYE AND FACE SHIELD.. WASH HANDS OR CLOTHING IMMEDI- ATELY tF ACCIDENTALLY IN CONTACT WITH ELECTROLYTE° DO NOT SMOKE, FUMES FROM CHARG- ED ELECTROLYTE ARE EXPLOSIVE. 1. Fill and charge Battery (before installing), NOTE: SEE DETAILED iNSTRUCTIONS PACKAGED WITH BAT- TERY.
WING INTERNAL/ EXTERNAL LOCKWASHER BATTERY BOLT FIGURE 6A WING NUT INTERNALIEXTERNAL LOCKWASHE R TERMINAL GUARD 4, Install Battery using: two Int./Ext Lockwashers,,two Wing Nuts (shown full size below} and q=D 0 two Battery Bolts and one Terminal Guard found in Bag of Parts.
INaTIAL SERVnCE NOTE: BE CAREFUL NOT TO ALLOW DiRT TO ENTER THE ENGINE WHEN CHECKING OR ADDING OIL OR FUEL I., Open Hood. 2. Check Engine Oil Leve! with Tractor on level ground Re- move and wipe Dipst.
CHOKE FAST MOWERBLADE CLUTCH"ENGAGED'_ POSITION HEADLIGHT THROTTLE _CONTROL LEVER "DISENGAGE D" POSITION PARKING BRAKE "tON "DISENGAGED" POSITION _I _= CLUTCH!BRAKE "CLUTCH" POSIT,ON "C LUTCH/BRAK E" POSITION FIGURE 10 _"_ _.
MOWER INSTALL.ATnO_ Your 38" Mower installs without the use of tools Raise Lift Lever (Fig° 11) to its highest position. Turn Depth Adjust- ment Knob to lowest position (Fig 14) !o Instal! Front Hinge Pin through Axle and Parallel Link (Fig. 12).
LIFT PLUNGER LIFT LEVER TOP OF FLANGE A FIGURE 15 SIDE-TO.SIDE ADJUSTMENT TRUNNION FIGURE 16 i_REAR /FLANGE REAR SUSPENSION ARM REAR SUSPENSION TRUNNION LIFT BRACKET FIGURE 17 SI DE-TO-SI DE :3JUSTMENT TOP OF FLANGE A D FRONT FLANGE LEVEL MOWER FROM SIDE TO SiDE SEE MOWER ADJUSTMENT, PAGE 9.
OPERATUO = MOWER READ THE "RULES FOR SAFE OPERA- TION" CAREFULLY BEFORE OPERAT- ING YOUR MOWER, THE MOWER MUST BE ADJUSTED PROPERLY FROM FRONT TO REAR AND LEVELED FROM SIDE TO StDE BEFORE OPERATING,, THtS IS NECESSARY FOR LEVEL AND EFFICIENT MOWING REFER TO PAGE 10 1.
MANDREL ASSEMBLY __i FLANGES LOCKWASHER _ _ .Ex eOLT / FIGURE 21 J ! I CENTER I | ' HOLE t ........... / ......... i FIGURE 22 MAINTENANCE = MOWER FOR ANY ADJUSTMENTS, INSPECTION OR MAINTENANCE: PUSH TRACTOR CLUTCH=BRAKE PED- AL COMPLETELY INTO BRAKE POSI- TION, PLACE PARKING BRAKE IN "ENGAGED" POSITION.
TRACTOR OPERATION 1, Depress Lift Lever Plunger at top of Mower Lift Lever and move Lever rearward to its "HIGHEST" position (Fig 23). 2, With engine running and warm, place Throttle Control.
STARTING YOUR TRACTOR WtTN A LOW BATTERY if your" Battery is too tow to start the engine, it should be recharged, If "Jumper Cables" are used for emergency starting follow this procedure NOTE: YOUR TRACTOR IS EQUIP.
4, CHECK BRAKE OPERATION This tractor is equipped with an adjustable brake system mounted on the right side of the transaxle (Fig., 27). tF TRACTOR REQUIRES MORE THAN SIX FEET STOPPING DISTANCE tN HIGHEST GEAR, THEN BRAKE MUST BE ADJUSTED,, NOTE: PARKING BRAKE MUST BE DISENGAGE D AND GEAR SHIFT LEVER IN NEUTRAL WHILE MAKING ADJ USTM ENT.
AIR CLEANER COVER _"_ --__ SCREW _, k BLOWER HOUSING SCREW% SCREW COOLING HEX HD FINS SCR EW CYLINDER HEAD N COVER HEX HD SCREW 3. CLEAN ENGINE COOLING FINS Keep Engine Cooling Fins free of dust, dirt and oil to pre- vent Engine damage from overheating.
ASNEEDED 1. CARBURETOR ADJUSTMENT DO NOT MAKE UNNECESSARYADJUSTMENTS FAC- TORY SETTINGS ARE SATISFACTORY FOR MOST APPLICATIONS AND CONDITIONS. tF ADJUSTMENTS ARE NEEDED, PROCEED AS FOLLOWS: a, Make sure Air Cleaner is clean (see page 15), b,, With engine not running, place Throttle at "FAST" * f' i' .
fl RETAINER SPRING FIGURE 32 FIGURE 33 TRANSAXLE PULLEY BELT GUIDE BRACKET BELT RETAINER SPRING SHIFT GATE REPLACE TRACTOR MOTION DRIVE BELT The tractor Drive Belt may be replaced without tools, Park the tractor on level area, Engage Parking Brake, NOTE: BELT INSTALLATION DECAL UNDER LEFT FOOT- REST.
5. TIRE CARE a. Maintain tire pressure in front tires at 14 PSi and rear tires at 12 PSi b Keep tires free of gasoline, oil. or insect control chemio cals which can destroy rubber c Avoid stumps, stones, deep ruts and other hazards that may cause tire damage d.
L_H, MAN[ ENGINE IDLER PULLEY _- " • IDLER BELT GUIDE ROCK SHAFT R_H. _MANDREL COTTER PIN FIGURE 38 SPRING LOWER HOLE (ORIGINAL POSITION) UPPER HOLE _1_ R.
OuBLE SNOOTS G POSSIBLE CAUSE POSSIBLE REMEDY WILL NOT START Foot Pedal not depressed Mower Blade Clutch Lever engaged No gasoline in Fuel Tank, clogged Fuel Line, or Fuel Filter Bfown Fuse Dead Batte.
LUBRICATION CHART AXLE PIVOT (_ (_ SPINDLE / SPINDLE BEARING _ ....... ,_ :_,4._ v-- =_ .... -----------FRONT WHEEL BEARING (_ N---L. (_ TIE ROD "I-'_" ,.
SCHEMATIC; 12 H.P° 38" RIDING LAWN TRACTOR--MODEL NUMBER 917o255741 RED RED 30 AMP IGNITION SWITCH STD365402 POSITION CIRCUIT OFF M-G ON B*L START B_ WHITE NEUTRAL ATTACH STARTER % WHITE IGNITIO.
REPAHR PARTS 12 H.P. 38" RIDING LAWN TRACTOR-MODEL NUMBER 917.255741 ELECTRICAL 9 % 17 29 20 !1 18.
REPAIR PARTS ELECTR ICAL 12 H.P. 38" RIDING LAWN TRACTOR--MODEL NUMBER 917.255741 KEY NO. ! 2 3 4 5 6 7 8 9 10 11 12 13 14 t5 16 PART DESCRIPTION KEY PART DESCRIPTION NO.
REPAIR PARTS 12 H,P. 38" RIDING LAWN TRACTOR--MODEL NUMBER 917.255741 ENCLOSURE L, 49 54 4O 55 29 G_ 21 G 37_ 29 20 33 35 52.
REPAIR PARTS ENCLOSURE '12 H.P. 38" RIDING LAWN TRACTOR-MODEL NUMBER 917.255741 "M KEY NO. t 2 3 4 5 6 7 8 9 10 1! 12 13 14 16 17 18 19 20 21 22 24 25 26 27 28 29 3O 31 32 PART NO.
REPAIR PARTS 12 H.P. 38" RIDING LAWN TRACTOR--MODEL NUMBER 917.255741 DRIVE 7O =--58 _r_ ' _59 61 16 61 90 OPTIONAL EQUIPMENT Spark Arrester Screen Assembly 677V1.
; EPAU$ :)RIVE PARTS 12 H.P. 38" RIDING LAWN TRACTOR--MODEL NUMBER 917.255741 KEY NO 2 3 4 5 6 0 1 13 15 16 17 19 20 21 22 23 24 25 26 27 28 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 PART DESCRIPTION KEY PART DESCRIPTION NO NO.
_EPAaR PARTS 12 H,P, 38" RIDING LAWN TRACTOR--MODEL NUMBER 917.255741 STEERING AND FRONT AXLE 55 - 30- 63 ,/--66 75 67 ,68.
REPAaR PARTS 12 H.P, 38" RIDING LAWN TRACTOR_-MODEL NUMBER 917.255741 STEERING AND FRONT AXLE KEY ,PAR T DESCRIPTION KEY PART DESCRIPTION NO NO NO.
REPAIIR PARTS 12 HoP. 38" RIDING LAWN TRACTOR-.MODEL NUMBER 917,255741, LIFT ADJUSTMENT 25 2O 9 C A 41 22 34 4O A 5! - 32 -.
REPAIR PARTS 12 H.P. 38" RIDING LAWN TRACTOR--MODEL NUMBER 917.255741 LIFT ADJUSTMENT KEY PART DESCRIPTION KEY PART DESCRIPTION NO NO NO NO 1 t06448X Lever.
12 H,P,38" RIDING LAWN TRACTOR--MODEL NUMBER 917.255741 38" MOWER -"-- t CC 55 I 56 56 _61 J 12 _ll FF-- REAR BAGGER ATTACHMENT IS BEING I USED, REFER TO REAR BAGGER OWNERS [MANUAL FOR .
RSPAUR PARTS 12 H.P. 38" RIDING LAWN TRACTOR--MODEL NUMBER 917.255741 38" MOWER KEY PART DESCRIPTION KEY PART DESCRfPTION NO NQ NO NO t 106085X V-Belt 39 2 105689X Housing 40 3 8417J Runner, R H 41 4 73680600 Nut, Lock, 3/8.
REPAIR PARTS 12 H.P. 38" RIDING LAWN TRACTOR--MODEL NUMBER 917.255741 TRANSAXLE--MODEL NUMBER 143.920-002 75 10 35 8 / 31 29 29 _(_- _ 32 6 62 35 <f _f18 34 _ 60 69 26 .
REPAIR PARTS; 12 H.P. 38" RIDING LAWN TRACTOR_-MODEL NUMBER 917.255741 TRANSAXLE--MODEL NUMBER 143o920-002 KEY NO. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 2O 21 22 23 24 25 26 27 28 29 3O 31 32 33 34 35 36 37 PART DESCRIPTION KEY PART NO,.
R_PAIR PARTS 12 H.P. 38" RIDING LAWN TRACTOR--MODEL NUMBER 917.255741 ENGINE-+MODEL NUMBER 143,366202 ENGINE 62 ,,.,,.. 58 13 82 - 38 +.
REPAIR ENGINE KEY NO. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 2O 21 22 23 24 25 26 27 28 28A 29 30 31 32 33 34 35 36 37 38 39 4O 41 42 43 44 45 45A 46 47 49 5O 51 52 53 54 55 56 57 58 59 6O 6OA 6t 62 63 64 PARTS 12 H.P. 38" RIDING LAWN "I-RACTOR°-MODEL NUMBER 917o255741 ENGINE--MODEL NUMBER 143.
REPAIR PAR TS ENGINE 12 H.P. 38" RIDING LAWN TRACTOR--MODEL NUMBER 917.255741 ENGINE-oMODEL NUMBER 143,366202 40 -.
REPAIR PARTS 12 H.P. 38" RIDING LAWN TRACTOR--MODEL NUMBER 917.255741 ENGINE--MODEL NUMBER 143,366202 ENGINE KEY PART DESCRIPTION KEY PART DESCRIPTION NOo NO.
$111PAIII PAIIT$ 12 H.P. 38" RIDING LAWN TRACTOR-MODEL NUMBER 917.255741 ENGINE--MODEL NUMBER 143.366202 CARBURETOR NO. 632413 KEY PART 1 _...4_ 7 /_ NO NO.. -_" 632413 t , -" _ _ 1 632243 2-._ i '__ _17 _ I _ 15 2 632244 ',' @.
SUGGESTED GUIDE FOR SUGHTING SLOPES FOR SAFE OPERATUON SIGHTING .GUIDE ONLY RiDE UP AND DOWN HiLL NOT ACROSS HILL SIGHT AND HOLD THiS LEVEL WiTH SKY LINE OR TREE t5 ° MAX. Operate your Tractor up and down the face of slopes (not greater than 15°); never across the face.
OWNERS MANUAL MODEL NO. 917.255741 HOW TO ORDER REPAIR PARTS 12 H.P. 38" RID JNG LAWN TRACTOR ELECTRIC START The Model Number will be found on the Model Plate attached to the Fender,, Always mention the Model Number when requesting service or parts for' your Lawn Tractor.
デバイスSears 917.255741の購入後に（又は購入する前であっても）重要なポイントは、説明書をよく読むことです。その単純な理由はいくつかあります：
Sears 917.255741をまだ購入していないなら、この製品の基本情報を理解する良い機会です。まずは上にある説明書の最初のページをご覧ください。そこにはSears 917.255741の技術情報の概要が記載されているはずです。デバイスがあなたのニーズを満たすかどうかは、ここで確認しましょう。Sears 917.255741の取扱説明書の次のページをよく読むことにより、製品の全機能やその取り扱いに関する情報を知ることができます。Sears 917.255741で得られた情報は、きっとあなたの購入の決断を手助けしてくれることでしょう。
Sears 917.255741を既にお持ちだが、まだ読んでいない場合は、上記の理由によりそれを行うべきです。そうすることにより機能を適切に使用しているか、又はSears 917.255741の不適切な取り扱いによりその寿命を短くする危険を犯していないかどうかを知ることができます。
ですが、ユーザガイドが果たす重要な役割の一つは、Sears 917.255741に関する問題の解決を支援することです。そこにはほとんどの場合、トラブルシューティング、すなわちSears 917.255741デバイスで最もよく起こりうる故障・不良とそれらの対処法についてのアドバイスを見つけることができるはずです。たとえ問題を解決できなかった場合でも、説明書にはカスタマー・サービスセンター又は最寄りのサービスセンターへの問い合わせ先等、次の対処法についての指示があるはずです。
