Searsメーカー917.25597の使用説明書/サービス説明書
ページ先へ移動 of 56
® 917.255970 OWNER'S MANUAL o Assembly o Operation o Customer Responsibilities o Service o Adjustments • Repair Parts Caution: Read and Follow all Safety Rules and Instructions Before Operatin.
SAFETY RULES Safe Operation Practices for Ride-On Mowers IMPORTANT: THIS CUTTING MACHINE ISCAPABLE OF AMPUTATING HANDSAND FEETANDTHROWING OBJECTS° FAILURE TO OBSERVE THE FOLLOWING SAFETY INSTRUCTIONS COULD RESULT IN SERIOUS INJURY OR DEATH.
CONGRATULATIONS on your purchase of a Sears tractor. It has been designed, engineered and manufac- tured to give you the best possible dependability and performance.
LE OF CONTENTS SAFETY RULES ............................................................ 2 PRODUCT SPECIFICATIONS ....................................... 3 CUSTOMER RESPONSIBILITIES ...................... 3,15-18 WARRANTY .............................
AOOESSO IES AND ATTACH ENTS These accessories and attachments were available when the tractor was purchased.. They are also available at most Sears retail outlets, catalog and service centers.
CONTENTS OF HARDWARE PACK .............. : ii iil:ll i:lt ii Parts Bag contents shown full size (1) Shoulder Bolt 5/16-18 (1) Knob (1) Washer 17/32 x 1-3/16 x 12 Gauge _J (3) Retainer Springs (4) Reta.
You r new tractor has been assembled at the factory with the exception of those parts teft unassembled for shipping purposes. To ensure safe and proper operation of your tractor, all parts and hardwar.
ASS LY HOW TO SET UP YOUR TRACTOR PREPARE BATTERY (See Fig. 3) CAUTION: Wear eye and face shield. Wash hands or clothing immediately if accidentally in contact with battery acid. Do not smoke. Fumes from charged bat- tery acid are explosive. Read the instructions included with the battery vent caps.
ASSEMBLY ,,,1111111 .............. INSTALL MOWER AND DRIVE BELT (See Fig. 5 and 8) Be sure tractor is on level surface,, Engage parking brake. o Cut and remove tie down wire between anti-sway bar and Roll,, gauge wheel brackeL Swing anti-sway barto left side of mower deck, o Slide mower under tractor with discharge guard to right side of tractor.
INSTALL BATTERY (See Figs. 6 and 7) o o CAUTION: Do not short battery termi- nals. Before installing battery, remove A etal bracelets, wristwatch bands, rings, etc. Positive terminal must be connected first to prevent sparking from accidental grounding.
OPERATION iHl:: .............................. KNOW YOUR TRACTOR READ THIS OWNER'S MANUAL AND SAFETY RULES BEFORE OPERATING YOUR TRACTOR. Compare the illustrations with your tractor to familiarize yourself with the location of various controls and adjustments.
OPERATION The operation of any tractor can result i : i oreign objects thrown into the eyes, which can result in severe eye damage. Always wear safety, gtasses or eye shields while operating your tractor or performing any adjustments or repairs.
,u,,,,,i TO ADJUST GAUGE WHEELS (See Fig. 10 ) o Adjust mower to desired cutting height. ° Lower mower with lift control,. Remove rear retainer spring and clevis pin which secure each gauge wheel.. • Lower gauge wheels to ground. Raise gauge wheels slightly to align holes in bracket and gauge wheel bar and insert clevis pins.
:?:?:::::: ........... ,11 ii,llllu,i , OPERATUON ADD GASOLINE o FIll fuel tank. Use fresh, clean, regular unleaded gasoline.. (Use of leaded gasoline will increase carbon and lead oxide deposits and reduce valve life).
CUSTOM ESPONSmBIL ES MAINTENANCE SCHEDULE ___./_ _/__ FILL IN DATES ./'___,,_. _ AS YOU COMPLETE /__/_.O_ R+E.GULA._+R S ERVlC_ F _.£,_._"SERVICE DATE s Check Brake Operation _ _4 Check Tire Pressure ..... " _ ' ; _ ..............
CUSTOM TRACTOR Always observe safety rules when performing any mainte- nance_ BRAKE OPERATION If tractor requires more than six (6) feet stopping distance at high speed in highest gear, then brake must be adjusted.. (See "TO ADJUST BRAKE" in the Service and Adjust- ments section of this manual).
IUIII"IIIIIH HIIIIlU IIII IIIl'll'ln U l CUSTOM LINES BATTERY (See Fig. 17) Your unit has a batter,/charging system which is sufficient for normal user However, periodic charging of the.
CUSTOM ESPON$ CLEAN AIR SCREEN (See Fig. 20) The air screen must be kept free of dirt and chaff to prevent engine damage from overheating.. Clean with a wire brush or compressed air to remove dirt and stubborn dried gum fibers.. IMPORTANT: PETROLEUM SOLVENTS, SUCH AS KEROSENE, ARE NOT TO BE USED TO CLEAN THE CARTRIDGE.
SERVICE AND ADJUSTMENTS 'I""IHII'_'II' I'1 ........ :': '11 ........................ CAUTION: BEFORE PERFORMING ANY SERVICE OR ADJUSTMENTS: TRACTOR • Depress clutch/brake pedal fully and setparking brake.
SERVICE AND A JUSTMENTS FRONT-TO-BACK ADJUSTMENT (See Figs25 and 26) - IMPORTANT: DECK MUST BE LEVEL SIDE-TO-SIDE. I FTHE FOLLOWING" FRONT-TO-BACK ADJUSTMENT IS NECESSARY, BE SURE TO ADJUST BOTH FRONT LINKS EQUALLY SO MOWER WILL STAY LEVEL SIDE-TO-SIDE.
CE AND ADJUSTMENTS TO REPLACE MOWER BLADE DRIVE BELT (See Fig. 28) Park the tractor on level surface_ Engage parking brake. o Remove mower drive belt (See'q'O REPLACE MOWER DRIVE BELT" in this section of this manual). . Remove mower (See "TO REMOVE MOWER" in this section of this manual).
SERVICE AN TO REPLACE MOTION DRIVE BELT (See Fig. 31) Park the tractor on level surface_ Engage parking brake. For ease of service there is a belt installation guide decal on bottom of left footrest. It is not necessaryto remove mower. BELT REMOVAL - • Raise hood and disconnect BLACK (grounding) bat- tery cable.
/q iiUHII,IWql ,rqll,q ,111 $ERVUCE AN TO REMOVE WHEEL FOR REPAIRS FRONT WHEEL (See Fig_ 34) - • Block up axle secureiy_ • Remove axle cover, retaining ring and washers to allow wheel removal, = Repair tire and reassemble, - Replace washers and snap retaining ring securely in axle groove.
ill i ............................. illl ,,i,i ii ....................... TO REMOVE HOOD AND GRILL ASSEMBLY (See Fig. 38) • Raise hood,. • Unsnap headlight wire connector,. ° Stand in front of tractor, G rasp hood at sides, tilt toward engine and lift off of tractor.
$ERVRCE AND ADJUSTMENTS i ,,,= TO ADJUST CARBURETOR (See Figs. 41 and 42) The carburetor has been preset at the factory and adjust- ment should not be necessary° However, minor adjust- ment may be re.
STO AGE Immediately prepare your tractor for storage at the end of the season or if the tractor will not be used for 30 days or more.. CAUTION: Never store the tractor with gasoline in the tank inside a building where fumes may reach an open flame or spark.
.......................... iii1,,i,i, iii RVIC NOTES 27.
TROUIBLESHOOTmNG ,ul_uuJx: ......... POmNTS PROBLEM Will not start CAUSE CORRECTION 1 Out of fuel 2 Engine not "CHOKED" properly 3 Engine flooded 4.. Bad spark plug, 5 Dirty air filter 6, Dirty fuel filter. 7 Water in fuel 8 Loose or damaged wiring.
TF OUBLESHOOT NG POHNTS PROBLEM Engine continues to run when operator leaves seat with attachment clutch engaged Poor cut - uneven Mower blades will not rotate Poor grass discharge Headlight(s) not working (if so equipped) Battery will not charge Engine "'backfires" when turning engine "OFF" CAUSE I.
..... 18 HP44" TRACTOR - MODEL NUMBER 917.255970 SCHEMATIC m oilllllo BATTERY BLACK IGNITION BLACK SWITCH LIFT KIT WIRING 30 1 RELAY M IGNITION SWITCH POSITION CIRCUIT OFF M + G ON ] B+L START" B + S FUSE 3O AMP. RED l ! tC DJ t F CLUTCH / BRAKE I t I = I STARTER _ .
REPAIR PARTS 18 HP 44" TRACTOR -- MODEL NUMBER 917.255970 DECALS 13 18 3 78 19 5 8167 4 13 10 12 17 23 11 23 '14 KEY PART KEY PART NO. NO. DESCRIPTION NO.
REPAIR PARTS 18 HP 44" TRACTOR - MODEL NUMBER 917.255970 ELECTROCAL A B C _12 _14 _16 _13 t_J17 I 29 I 48 3 4 39 32.
REPAIR PARTS 18 HP 44" TRACTOR - MODEL NUMBER 917.255970 ELECTRBCAL KEY PART NO. NO. DESCRIPTION t 109310X Key, Ignition 2 4406R Switch, Ignition 3 123620X Cover, Switch Key 4 124211X Nut, igniti.
REPAIR PARTS 18 HP 44" TRACTOR - MODEL NUMBER 917.255970 CHASSIS AND ENCLOSURES 21 17 37 19 93 16 _ 79 20 ,,_ 76 91 4 86 85 36 18 97 22 49 25 !1 63 40 15 66 24 34.
REPAIR PARTS 18 HP 44" TRACTOR - MODEL NUMBER 917.255970 CHASSIS AND ENCLOSURES KEY PART KEY PART NO. NOw DESCRIPTION NO. NO. DESCRIPTION 1 138597 Rail, Frame RH 45 138460 2 7982J Drawbar, Gt 46 .
REPAIR PARTS 18 HP 44" TRACTOR GROUND DRIVE - MODEL NUMBER 917.255970 39 28 29 32 31 64 46 36 / 68 9 8 62 36.
REPAIR PARTS 18 HP 44" TRACTOR - MODEL NUMBER 917.255970 GROUND DRIVE KEY PART KEY PART NO. NO. DESCRIPTION NO. NO. DESCRIPTION 1 9858M1 Key, Woodruff 37 121749X 2 2228M Key, Woodruff 38 110895X .
REPAIR PARTS 18 HP 44" TRACTOR - MODEL NUMBER 917.255970 STEERING ASSEMBLY 26 24 1 _ 21 2O 34 33 32 6 27 19 27 6 / ,/ ./ 16 ,I 23 10 15' 14 35 t4 18 38.
REPAIR PARTS 18 HP 44" TRACTOR - MODEL NUMBER 917,255970 STEERING ASSEMBLY KEY PART NO, NO. DESCRIPTION 1 133741 2 674A243 3 6855M 4 136960 5 136959 6 6266H 7 121748X 8 12000029 9 121232X 10 7478.
REPAIR PARTS ....... 18 HP 44" TRACTOR - MODEL NUMBER 917.255970 ENGINE 6 1 1 1 i 1 f I t I i 17 18 37 ,o 43 9 12 19 11 41 31 30 35 30 35 36 34 16 28 40.
REPAIR ENGINE PARTS 18 HP 44" TRACTOR - MODEL NUMBER 917.255970 KEY PART NO. NO. 1 t38t61 2 139217 3 132403O0 4 13280328 5 13200300 6 138129 7 139211 8 12t361X 9 138559 10 !05432X 11 137'140.
REPAIR PARTS 18 HP 44" TRACTOR - MODEL NUMBER 917.255970 SEAT ASSEMBLY 28 KEY PART NO. NO. 1 127438X 2 126656X 5 275tR 6 73680600 7 124181X 8 174905O8 9 19131614 10 131454 11 121251X 12 121246X 13 121248X 14 72050411 15 134300 KEY PART DESCRIPTION NO.
REPAIR PARTS 18 HP 44" TRACTOR - MODEL NUMBER 917.255970 LiFT ASSEMBLY 35 17 34 33 31 7 9 .'_,?' / 23 X 21 19 20 X 15 t8 KEY NO. 1 2 3 4 5 6 7 8 9 10 !1 12 13 14 15 16 17 18 PART NO.
REPAIR PARTS 18 HP 44" TRACTOR - MODEL NUMBER 917.255970 44" MOWER DECK 55 59 52 48 38 5O 32 25 24 t 3 6 54 31 10 11 16 _ 8-_ 26 42 18 17 23 2 22 44.
REPARR PARTS 18 HP 44" TRACTOR - MODEL NUMBER 917.255970 44" MOWER DECK KEY PART KEY PART NO, NO, DESCRIPTION NO, NO, DESCRIPTION 1 136471 2 7380050O 3 72110506 4 7631J 5 138457 6 4939M 7 13.
REPAIIR PARTS 18 HP 44" TRACTOR - MODEL NUMBER 917.255970 TRANSAXLE 3 5 2 78 48 31 / 72 71 ,_97 9 92 93- @ f98 7 41 25 24 46.
REPAIR PARTS 18 HP 44" TRACTOR - MODEL NUMBER 9"17.255970 TRANSAXLE KEY PART KEY PART NO. NO. DESCRIPTION NO, NO. DESCRIPTION 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 t7 18 19 20 21 22 23 24 2.
REPAIR PARTS 18 HP 44" TRACTOR - MODEL NUMBER 917.255970 BRIGGS & STRATTON ENGINE - MODEL NUMBER 422707, TYPE NUMBER 1243-01 9 9 305 46( 2O "_ 305 18 219 * REQUIRES SPECIAL TOOLS TO INSTALL.
REPAIR PARTS 18 HP 44" TRACTOR - MODEL NUMBER 917.255970 BRIGGS & STRATTON ENGINE - MODEL NUMBER 422707, TYPE NUMBER 1243-01 2o6 358 GASKET SET] [861 PUMP REPAIR KIT I [121 CARBURETOR OVERHAU.
REPAIlR PARTS 18 HP 44" TRACTOR - MODEL NUMBER 917.255970 BRIGGS & STRATTON ENGINE - MODEL NUMBER 422707, TYPE NUMBER 1243-01 i 50.
REPAaR PARTS 18 HP 44" TRACTOR - MODEL NUMBER 917.255970 BRIGGS & STRATTON ENGINE - MODEL NUMBER 422707, TYPE NUMBER 1243-01 Reference Number Manufacturer Briogs & _ Housing Stratton ] Length _2v I..... 3-5,;8" "includes Brush Set 309 1 310 i 3"_ T s44 t Motor and I Thru Bolt I Brush _ Armature I Drive Ass'y.
RE:PAnR PARTS 18 PiP 44" TRACTOR - MODEL NUMBER 917.255970 BRIGGS & STRATTON ENGINE - MODEL NUMBER 422707, TYPE NUMBER 1243-01 KEY PART KEY PART NO.
REPAIR PARTS 18 HP 44" TRACTOR - MODEL NUMBER 917.255970 BRIGGS & STRATTON ENGINE - MODEL NUMBER 422707, TYPE NUMBER 1243-01 KEY PART KEY PART NO, NO.
54.
SUGGESTED GUIDE FOR SIGHTING SLOPES FOR SAFE OPERATRON SIGHTING GUIDE ONLY RIDE UP AND DOWN HILL, NOT ACROSS HILL SIGHT AND HOLD THIS LEVEL WITH SKY LINE OR TREE. ,,_,, ,,, , :_ ,, , , . _ ,,, ,,,,,,,, ,,,,,,,, ,,,,, ,,, _ A Operate your Tractor up and down the face of slopes (not i ! _ greater than 15°), never across the face.
OWNER'S MODEL NO. 917.255970 HOW TO ORDER REPAIR PARTS ® 18.0 HP TWIN CYLINDER ELECTRIC START 44" MOWER 6 SPEED TRANSAXLE GARDEN TRACTOR Each tractor has its own model number. Each engine has its own model number. The model number for your tractor will be found on the model plate located under the seat.
デバイスSears 917.25597の購入後に（又は購入する前であっても）重要なポイントは、説明書をよく読むことです。その単純な理由はいくつかあります：
Sears 917.25597をまだ購入していないなら、この製品の基本情報を理解する良い機会です。まずは上にある説明書の最初のページをご覧ください。そこにはSears 917.25597の技術情報の概要が記載されているはずです。デバイスがあなたのニーズを満たすかどうかは、ここで確認しましょう。Sears 917.25597の取扱説明書の次のページをよく読むことにより、製品の全機能やその取り扱いに関する情報を知ることができます。Sears 917.25597で得られた情報は、きっとあなたの購入の決断を手助けしてくれることでしょう。
Sears 917.25597を既にお持ちだが、まだ読んでいない場合は、上記の理由によりそれを行うべきです。そうすることにより機能を適切に使用しているか、又はSears 917.25597の不適切な取り扱いによりその寿命を短くする危険を犯していないかどうかを知ることができます。
ですが、ユーザガイドが果たす重要な役割の一つは、Sears 917.25597に関する問題の解決を支援することです。そこにはほとんどの場合、トラブルシューティング、すなわちSears 917.25597デバイスで最もよく起こりうる故障・不良とそれらの対処法についてのアドバイスを見つけることができるはずです。たとえ問題を解決できなかった場合でも、説明書にはカスタマー・サービスセンター又は最寄りのサービスセンターへの問い合わせ先等、次の対処法についての指示があるはずです。
