Bakers Pride OvenメーカーVH1828Gの使用説明書/サービス説明書
ページ先へ移動 of 32
INST ALLA TION AND OPERA TING INSTRUCTIONS INTENDED FOR OTHER THAN HOUSEHOLD USE Model: VH1828G RET AIN THIS MANUAL FOR FUTURE REFERENC E OVEN MUST BE KEPT CLEAR OF COMBUSTIBLES A T ALL TIMES P/N U417.
T ABLE OF CONTENTS SECTION ITEM P AGE 1 Safety Precautions 3 2 General Information 3 3 Receiving 5 4 Location & Minimum Clearances 6 5 Installation 6 6 Stacking 7 7 Electrical Connections 7 8 Gas .
! W ARNING: This symbol refers to a potential hazard or unsafe practice, which could result in serious injury or death. ! ! ! DANGER: This symbol warns of imminent hazard which will result in serious injury or death.
! ! W ARNING: Never clean any electrical unit by immersing it in water . T urn off before cleaning surface. ! ! W ARNING: An earthing cable must connect the appliance to all other units in the complete installation and from there to an independent earth connection.
! ! NOTICE: Instructions to be followed if anyone smells gas should be posted in a prominent place. These may be obtained from the gas supplier . ! ! W ARNING: Post in a prominent location instructions to be followed in the event you smell gas. Obtain these instructions from your local gas supplier .
6 4. LOCA TION AND MINIMUM CLEARANCES Adequate air space must be provided for the proper venting of the rear exhaust air and provision made for venting of cooking vapors. The Conveyor Oven must be installed in a well-ventilated area. NOTE: Attached rear rubber bumpers must not be removed and can contact a rear wall if present.
Y our conveyor oven(s) can be stacked up to (3) high. Each unit is built exactly the same, so it does not matter in which order they are stacked. For stacking of (2) units, remove the legs from the second (upper) unit prior to mounting on top of the bottom unit.
8. GAS CONNECTIONS The 1828G conveyor oven can be ordered either as Natural Gas or Liquid Propane Gas. A) Only a qualified gas appliance installer should make gas connections.
.
ADJUS TABLE BAFFLE LOWER COVER (L E F TS I D E) HN G E R P I N S (A T T A C H E DT O UPPER COVER ) A UPPER COVER ( RIG HT SIDE ) LOWER COVER ( RI GHT SIDE ) UPPER COVER (L E F TS I D E) ADJUS TABLE BA.
.
.
.
.
.
GAS CONTROL BOX WI TH M AIN ON/OFF S WI TCH HINGE D FRO NT DOOR PROD UCT FLOW POWER CONTROL BOX 4 10.
E. Using a black marking pen, mark any belt link near the outer edge. Using a stopwatch, check the time it takes for this link to move between the timing marks. Repeat this procedure several times until the distance is traveled in 90 seconds (recommended calibration interval), which equals a 6- minute cook time.
19. TROUBLESHOOTING GUIDE THE PROBLEM THE CAUSE THE SOLUTION 18.
THE PROBLEM THE CAUSE THE SOLUTION CAUTION: THE FOLLOWING TESTS 1- 5 ARE PERFORMED WITH LIVE POWER WITH CONTROL BOX OPEN, OR REAR MOTOR COVER REMOVED. THESE TESTS TO BE PERFORMED ONL Y BY AN AUTHORIZED SERVICE AGENT . No air or not enough air coming from blower(s) 19 CAUTION: THE FOLLOWING TESTS ARE PERFORMED WITH LIVE POWER WITH CONTROL BOX OPEN.
THE PROBLEM THE CAUSE THE SOLUTION 20.
THE PROBLEM THE CAUSE THE SOLUTION 21.
20. TEMPERA TURE CONTROL CONVERSION CHART - OHMS TO DEGREES The temperature sensor (probe) that is supplied with this conveyor oven is an RTD type, which yields an output based on Ohms of resistance.
VH 1828G ELECTRICAL SCHEMA TIC 1 15V AC, 50/60Hz, 1 Phase 21. ELECTRICAL SCHEMA TIC & WIRING DIAGRAM 23 U4182Q F1 10 A MP 18 GA WHITE. 18 GA. BLACK F1 UPPE R T EMP CO NTROL LOWER T EMP CON TROL CO.
VH 1828G WIRING DIAGRAM 1 15V AC, 50/60Hz, 1 Phase U4182Q 4 5 2 1 3 11 10 9 8 7 6 19 13 19 11 18 14 16 12 41 39 46 44 + 42 20 23 38 15 - G2 25 G2 G4 17 G3 25 34 10 G1 9 5 86 4 G 19 G 4 5 2 1 3 11 10 9.
Item P/N Description Quan Item P/N Description Quan 22. P ARTS LISTS & EXPLODED VIEWS Figure “A” External Covers Figure “B” Conveyor Assembly 1 2 3 8 9 10 8 8 8 9 10 7 6 5 4 3 2 1 1 2 5 6 .
Figure “E” VH Series Ovens Only Figure “C” Blower Motor Cover Assembly Figure “F” Plenum “Finger” Assembly Figure “D” Blower Assembly Item P/N Description Quan Item P/N Description.
3 - P I E C E A S S E M B L Y 1 2 3 4 11 17 18 19 21 20 23 24 25 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 1 1 1 2 1 1 1 1 1 1 1 1 1 1 1 1 1 2 1 1 1 1 1 1 1 1 M1385A B6086U .
3-PIE CE ASS EMBLY 1 2 3 4 6 8 9 10 11 13 14 15 16 17 19 21 22 25 12 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 1 1 1 2 2 1 2 1 2 1 1 1 1 1 1 1 1 1 1 1 1 2 1 1 3 2 MAIN GAS B.
1 2 1 2 2 2 M1518A TEMPERA TURE SENSOR PROBE M1534A COOL-DOWN THERMOST A T 2 3 6 7 8 9 1 2 3 4 5 6 7 8 9 1 1 1 1 1 1 1 1 1 B6318U L5106A N5876A R3224P R3245P N3084A M1 167A B6318K M2140A BURNER ASSY ,.
SE E FIGURE "L" 1 2 1 2 1 1 R5877A R5878A UPPER GAS MANIFOLD TUBE LOWER GAS MANIFOLD TUBE 1 2 3 4.
31 WHA T IS COVERED This warranty covers defects in material and workmanship under normal use, and applies only to the original purchaser providing that: * The equipment has not been accidentally or i.
F. BAKERS PRIDE.
デバイスBakers Pride Oven VH1828Gの購入後に（又は購入する前であっても）重要なポイントは、説明書をよく読むことです。その単純な理由はいくつかあります：
Bakers Pride Oven VH1828Gをまだ購入していないなら、この製品の基本情報を理解する良い機会です。まずは上にある説明書の最初のページをご覧ください。そこにはBakers Pride Oven VH1828Gの技術情報の概要が記載されているはずです。デバイスがあなたのニーズを満たすかどうかは、ここで確認しましょう。Bakers Pride Oven VH1828Gの取扱説明書の次のページをよく読むことにより、製品の全機能やその取り扱いに関する情報を知ることができます。Bakers Pride Oven VH1828Gで得られた情報は、きっとあなたの購入の決断を手助けしてくれることでしょう。
Bakers Pride Oven VH1828Gを既にお持ちだが、まだ読んでいない場合は、上記の理由によりそれを行うべきです。そうすることにより機能を適切に使用しているか、又はBakers Pride Oven VH1828Gの不適切な取り扱いによりその寿命を短くする危険を犯していないかどうかを知ることができます。
ですが、ユーザガイドが果たす重要な役割の一つは、Bakers Pride Oven VH1828Gに関する問題の解決を支援することです。そこにはほとんどの場合、トラブルシューティング、すなわちBakers Pride Oven VH1828Gデバイスで最もよく起こりうる故障・不良とそれらの対処法についてのアドバイスを見つけることができるはずです。たとえ問題を解決できなかった場合でも、説明書にはカスタマー・サービスセンター又は最寄りのサービスセンターへの問い合わせ先等、次の対処法についての指示があるはずです。
