StoeltingメーカーSC118の使用説明書/サービス説明書
ページ先へ移動 of 33
SC1 18 - S towaway Slush/Cocktail OWNER’S MANUAL Manual No. 513556 Jan., 2001 Rev . 0.
.
Need Part s or Service? We stock the parts you need. Our Technicians are factory trained and are certified in the Stoelting Technicare program. Model No.: _______________________ Serial No.: _______________________ Purchase Date: ____________________ Start-Up Date:____________________ CALL Distributor: _________________________ Phone No.
.
OWNER'S MANUAL FOR MODEL SC118 STOELTING COUNTER MODEL FREEZER This manual provides basic information about the freezer. Instructions and suggestions are given covering its operation and care. The illustrations and specifications are not binding in detail.
.
SECTION DESCRIPTION PAGE 1. Introduction ................................................................................................................ . 1 2. Installation Instruction 2.1 Safety Precautions ..........................................
FIGURE TITLE PAGE 1 Model SC118 ......................................................................................................... 1 2 Specifications ..............................................................................................
1 The Stowaway is a countertop profit machine. This compact unit fits onto any crowded bar, yet its high capacity means it will turn out more than seven gallons every hour. And the Stowaway is as versatile as it is fast, dispensing frozen, pre-mixed or ready-to-serve blends all with the same smooth consistency.
2 Figure 2. Specifications Specifications 12 running amps 1 15/60/1 15-amp fuse 2.5 gallon (9.5 liter) hopper capacity 5.5 quart (5.2 liter) barrel capacity 1/3 horsepower drive motor UL & C-UL ap.
3 SECTION 2 INSTALLATION INSTRUCTIONS 2.1 SAFETY PRECAUTIONS Do not attempt to operate the freezer until the safety precautions and operating instructions in this manual are read completely and are thoroughly understood. Take notice of all warning labels on the freezer.
4 D. Connect the power cord. The plug is designed for 115 volt/15 amp duty. The unit must be connected to a properly grounded receptacle. The electrical cord fur- nished as part of the freezer has a three prong ground- ing type plug. The use of an extension cord is not recommended.
5 SECTION 3 INITIAL SETUP AND OPERATION 3.1 OPERATOR'S SAFETY PRECAUTIONS SAFE OPERA TION IS NO ACCIDENT ; Observe these rules: A. Know the freezer . Read and understand the Operating Instructions. B. Notice all warning labels on the freezer . C.
6 Figure 7. Front Door and Auger Assembly T o disassemble the freezer , refer to the following steps: A . Remove the front door by removing the upper and lower plastic shrouds then turn off the knobs, and pull the front door off the studs. B . Remove the spigot body from the spout by pulling the horse shoe clip up and out.
7 C. Lubricate the drive end of the agitator (rear) shaft with a small amout of white socket lubricant. A small container of socket lubrication is shipped with the freezer. D. Install the two plastic agitator blades onto the agitator. Install front agitator bearing.
8 CAUTION PROLONGED CONT ACT OF SANITIZER WITH FREEZER MA Y CAUSE CORROSION OF ST AIN- LESS STEEL P ARTS. In general, sanitizing may be conducted as follows: A . Prepare 2 gallons (7.5 liters) of sanitizing solution following manufacturer's instructions.
9 SECTION 4 BULB REPLACEMENT 4.1 LIGHT BULB REPLACEMENT 1. Remove the upper plastic shroud. 2. Remove the four retaining screws from the electrical panel and tip forward. 3. Grasp faulty bulb and pull out. 4. Push in replacement bulb until it snaps into place.
10.
11 SECTION 5 SEQUENCE OF OPERATIONS 5.1 LIGHTS On/Off light switch is independent of all other switches. When on, the light transformer is operational and the lights illuminate.
12.
13 PR OBL E M: CA US E CO RR ECTION High Pressure Cuto ut Sw itch T ripped. Dirty c o ndense r. Clea n conde nse r Drive moto r overl oad tri ps. (Freezer shuts down when runni ng) I m p r o per B r ix readi ng . Re f ill wit h prod uct that ha s Brix r e a ding b e twee n 11 and 1 3.
14.
15.
16.
17.
18.
19.
20.
21.
22.
23.
24.
W ARRANTY MIX TRANSFER PUMPS / COCKT AIL / SLUSH 1. Scope: Stoelting LLC warrants to the first user (the “Buyer”) that the evaporator assembly and compressor (if applicable) of Stoelting mix trans.
デバイスStoelting SC118の購入後に（又は購入する前であっても）重要なポイントは、説明書をよく読むことです。その単純な理由はいくつかあります：
Stoelting SC118をまだ購入していないなら、この製品の基本情報を理解する良い機会です。まずは上にある説明書の最初のページをご覧ください。そこにはStoelting SC118の技術情報の概要が記載されているはずです。デバイスがあなたのニーズを満たすかどうかは、ここで確認しましょう。Stoelting SC118の取扱説明書の次のページをよく読むことにより、製品の全機能やその取り扱いに関する情報を知ることができます。Stoelting SC118で得られた情報は、きっとあなたの購入の決断を手助けしてくれることでしょう。
Stoelting SC118を既にお持ちだが、まだ読んでいない場合は、上記の理由によりそれを行うべきです。そうすることにより機能を適切に使用しているか、又はStoelting SC118の不適切な取り扱いによりその寿命を短くする危険を犯していないかどうかを知ることができます。
ですが、ユーザガイドが果たす重要な役割の一つは、Stoelting SC118に関する問題の解決を支援することです。そこにはほとんどの場合、トラブルシューティング、すなわちStoelting SC118デバイスで最もよく起こりうる故障・不良とそれらの対処法についてのアドバイスを見つけることができるはずです。たとえ問題を解決できなかった場合でも、説明書にはカスタマー・サービスセンター又は最寄りのサービスセンターへの問い合わせ先等、次の対処法についての指示があるはずです。
