YamahaメーカーTDM900(R) 5PS1-AE2の使用説明書/サービス説明書
ページ先へ移動 of 28
.
.
FOREWORD This Supplementary Service Manual has been prepared to introduce new service and data for the TDM900 (R) 2003. For complete service information procedures it is necessary to use this Supple- mentary Service Manual together with the following manual.
NOTE: W ARNING CAUTION: EAS00002 NOTICE This manual was produced by the Y amaha Motor Company , Ltd. primarily for use by Y amaha dealers and their qualified mechanics.
1 2 4 5 7 8 6 3 EAS00007 HOW T O USE THIS MANUAL This manual is intended as a handy , easy-to-read reference book for the mechanic. Comprehensive explanations of all installation, removal, disassembly , assembly , repair and check procedures are laid out with the individual steps in sequential order .
22 1 3 5 7 9 2 4 8 6 24 25 23 21 19 20 18 16 17 15 14 13 11 12 10 GEN INFO SPEC ENG FI ELEC COOL CHK ADJ TRBL SHTG CHAS EAS00008 SYMBOLS The following symbols are not relevant to every vehicle.
CONTENTS SPECIFICA TIONS GENERAL SPECIFICA TIONS 1 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ENGINE SPECIFICA TIONS 1 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . CHASSIS SPECIFICA TIONS 1 . . .
.
–1– GENERAL SPECIFICA TIONS / ENGINE SPECIFICA TIONS / CHASSIS SPECIFICA TIONS SPEC SPECIFICA TIONS GENERAL SPECIFICA TIONS Item Standard Limit Model code 5PS4 (EUR) 5PS5 (OCE) SSS SSS ENGINE SPEC.
–2– 1 Main switch 2 Horn switch 3 Pass switch 4 Dimmer switch 5 Hazard switch 6 T urn signal switch 7 Clutch switch 8 Engine stop switch 9 Start switch 10 Front brake light switch 11 Neutral switc.
–3– ELECTRIC ST ARTING SYSTEM ELEC EAS00755 ELECTRIC ST ARTING SYSTEM CIRCUIT DIAGRAM.
–4– ELECTRIC ST ARTING SYSTEM ELEC 4 Main fuse 5 Battery 7 Starter relay 8 Starter motor 9 Main switch 12 Starting circuit cut-off relay 13 Sidestand switch 14 Neutral switch 49 Clutch switch 59 E.
–5– ELECTRIC ST ARTING SYSTEM ELEC EAS00756 ST ARTING CIRCUIT CUT -OFF SYSTEM OPERA TION If the engine stop switch is set to “ ” and the main switch is set to “ON” (both switches are close.
–6– EAS00739 2. Battery S Check the condition of the battery . Refer to “CHECKING AND CHARGING THE BA TTERY” in chapter 3. (Manual No.: 5PS1-AE1) YES NO S Clean the battery terminals. S Recharge or re- place the battery . Minimum open-circuit voltage 12.
–7– 4. Starting circuit cut-off relay S Disconnect the starting circuit cut-off relay from the wire harness. S Connect the pocket tester ( Ω 1) and bat- tery (12 V) to the starting circuit cut-off relay terminals as shown. YES NO Replace the starting circuit cut-off relay .
–8– 6. Starter relay S Disconnect the starter relay from the cou- pler . S Connect the pocket tester ( Ω 1) and bat- tery (12 V) to the starter relay terminals as shown.
–9– ELECTRIC ST ARTING SYSTEM ELEC 12. Start switch S Check the start switch for continuity . Refer to “CHECKING THE SWITCHES”. S Is the start switch OK? YES NO Replace the right handlebar switch. EAS00764 13. Wiring S Check the entire starting system’s wiring.
–10– LIGHTING SYSTEM ELEC EAS00780 LIGHTING SYSTEM CIRCUIT DIAGRAM.
–1 1– LIGHTING SYSTEM ELEC 4 Main fuse 5 Battery 9 Main switch 23 ECU 37 High beam indicator light 40 Meter light 45 Pass switch 46 Dimmer switch 55 Headlight 56 Headlight relay 62 Headlight fuse .
–12– YES NO 2. Battery S Check the condition of the battery . Refer to “CHECKING AND CHARGING THE BA TTERY” in chapter 3. (Manual No.: 5PS1-AE1) S Clean the battery terminals. S Recharge or re- place the battery . EAS00739 Minimum open-circuit voltage 12.
–13– LIGHTING SYSTEM ELEC EAS00784 YES NO 5. Dimmer switch S Check the dimmer switch for continuity . Refer to “CHECKING THE SWITCHES”. S Is the dimmer switch OK? The dimmer switch is faulty . Replace the left handlebar switch. EAS00786 YES NO 6.
–14– F AUL TY LIGHTING SYSTEM TRBL SHTG EAS00866 TROUBLESHOOTING F AUL TY LIGHTING SYSTEM HEADLIGHT DOES NOT COME ON S Wrong headlight bulb S T oo many electrical accessories S Hard charging S Inc.
62 Headlight fuse 63 Hazard fuse 64 Signaling system fuse 65 Radiator fan motor fuse 66 Rear brake light switch 67 T ail / brake light 68 Radiator fan relay 69 Radiator fan motor 70 Auxiliary light COLOR CODE B Black . . . . . . . Br Brown . . . . . .
62 Radiator fan motor fuse 63 Radiator fan relay 64 Radiator fan motor 65 Auxiliary light 66 Rear brake light switch 67 T ail / brake light COLOR CODE B Black . . . . . . . Br Brown . . . . . . Ch Chocolate . . . . . Dg Dark green . . . . . G Green . .
.
.
R B Dg Lg Br B Y Ch G L ON OFF P R L/Y OFF ON OFF ON HI LO OFF ON R N L Y L B YB B B B B B B B B B B/Y L/Y OFF RUN OFF ON B L Gy G/W G/W L/Y L/W R/W L/B L/R Dg Lg Br BY C h G L L/B L/R Y/L B/W R/G L/B.
R L/W R/L R/B L/W G/R B/R B/W L/W R/W L/Y L/Y L/G Sb B/Y Lg R/Y L/B Ch B/Y Br L/Y Br/W YD g B R/Y L/B Ch B/Y Br L/Y Br/W Y Dg B WIRE HARNESS HEADLIGHT SUB-WIRE HARNESS 2 WIRE HARNESS WIRE HARNESS WIRE.
デバイスYamaha TDM900(R) 5PS1-AE2の購入後に（又は購入する前であっても）重要なポイントは、説明書をよく読むことです。その単純な理由はいくつかあります：
Yamaha TDM900(R) 5PS1-AE2をまだ購入していないなら、この製品の基本情報を理解する良い機会です。まずは上にある説明書の最初のページをご覧ください。そこにはYamaha TDM900(R) 5PS1-AE2の技術情報の概要が記載されているはずです。デバイスがあなたのニーズを満たすかどうかは、ここで確認しましょう。Yamaha TDM900(R) 5PS1-AE2の取扱説明書の次のページをよく読むことにより、製品の全機能やその取り扱いに関する情報を知ることができます。Yamaha TDM900(R) 5PS1-AE2で得られた情報は、きっとあなたの購入の決断を手助けしてくれることでしょう。
Yamaha TDM900(R) 5PS1-AE2を既にお持ちだが、まだ読んでいない場合は、上記の理由によりそれを行うべきです。そうすることにより機能を適切に使用しているか、又はYamaha TDM900(R) 5PS1-AE2の不適切な取り扱いによりその寿命を短くする危険を犯していないかどうかを知ることができます。
ですが、ユーザガイドが果たす重要な役割の一つは、Yamaha TDM900(R) 5PS1-AE2に関する問題の解決を支援することです。そこにはほとんどの場合、トラブルシューティング、すなわちYamaha TDM900(R) 5PS1-AE2デバイスで最もよく起こりうる故障・不良とそれらの対処法についてのアドバイスを見つけることができるはずです。たとえ問題を解決できなかった場合でも、説明書にはカスタマー・サービスセンター又は最寄りのサービスセンターへの問い合わせ先等、次の対処法についての指示があるはずです。
