Cal FlameメーカーLTR20091006の使用説明書/サービス説明書
ページ先へ移動 of 32
.
Copyright 2008-2009 LMS, Inc. All rights re- served. Duplication without writ ten consent is strictly prohibited. Cal Flame ® is a registered trademark. Due to continuous improvement programs, all models, operation, and/or specications are subject to change without prior notice.
Safety Instructions 1 2009 Fireplaces and Firepits L TR20091006, Rev . B w w w . c a l s p a s . c o m Most cities and counties require permits for exteri- or construction and electrical circuits.
2 Safety Instructions 2009 Fireplaces and Firepits L TR20091006, Rev . B w w w . c a l s p a s . c o m Do not block the vents located near the base of your repit or • replace as gas may build up in case of leak and cause serious damage.
Safety Instructions 3 2009 Fireplaces and Firepits L TR20091006, Rev . B w w w . c a l s p a s . c o m K eep all electrical supply cords away from the heated areas of the • replace or repit. Never use the replace or repit in windy conditions.
4 Safety Instructions 2009 Fireplaces and Firepits L TR20091006, Rev . B w w w . c a l s p a s . c o m More frequent cleaning ma y be required as necessary . It is imper a- • tive the control compartment, burner and circulation air passage- ways of the appliance be k ept clean and free.
Installation / Assembl y 5 2009 Fireplaces and Firepits L TR20091006, Rev . B w w w . c a l s p a s . c o m Installation must conform with local building and/or re codes, or in the absence of local codes: National Fuel Gas Code ANSI Z223.1 / INFPA 54 (for installation in • the United States) CSA B149.
6 Installation / Assembl y 2009 Fireplaces and Firepits L TR20091006, Rev . B w w w . c a l s p a s . c o m Leak Testing Procedure Perf orm a leak test at least once a year whether the gas supply cylinder has been disconnected or not.
Installation / Assembl y 7 2009 Fireplaces and Firepits L TR20091006, Rev . B w w w . c a l s p a s . c o m Liquid Propane (LP) Requirements The 20 lb LP gas supply cylinder used wi th LP models must be con- structed and marked in accordance with the specications for LP-gas cylinders as required by the U.
8 Installation / Assembl y 2009 Fireplaces and Firepits L TR20091006, Rev . B w w w . c a l s p a s . c o m 2) Having at least two ventilation openings at cylinder valve level in the side wall, equally sized, spaced at 180 degrees (3.14 rad), and unobstructed.
Installation / Assembl y 9 2009 Fireplaces and Firepits L TR20091006, Rev . B w w w . c a l s p a s . c o m Connection Inspect the hose shipped with the unit for damage. Never attempt to use damaged or plugged equipment. See your local LP gas dealer for repairs.
10 Installation / Assembl y 2009 Fireplaces and Firepits L TR20091006, Rev . B w w w . c a l s p a s . c o m Natural Gas The appliance and its individual shut off v alve must be disconnected from the gas supply piping system during any pressure testing of the system at test pressures in excess of ½ psig (3.
Installation / Assembl y 11 2009 Fireplaces and Firepits L TR20091006, Rev . B w w w . c a l s p a s . c o m Fireplace Burner Installation This procedure describes how to access the gas lines for installation. Gas ins talla tion sho uld b e pe rfor med by a qual ied cont ract or.
12 Installation / Assembl y 2009 Fireplaces and Firepits L TR20091006, Rev . B w w w . c a l s p a s . c o m While holding the burner in 4. place, extend the wire from the burner to the sparker switch located on the right side of the replace. Con - nect the wire to the electric sparker .
Installation / Assembl y 13 2009 Fireplaces and Firepits L TR20091006, Rev . B w w w . c a l s p a s . c o m Fire Pit Burner Installation The log set and crushed lava rock are shipped together on applicable models. R emove the log set and un-pack all components.
14 Installation / Assembl y 2009 Fireplaces and Firepits L TR20091006, Rev . B w w w . c a l s p a s . c o m Set the burner in the center of the pit. Place the rocks on top of and around the burner .
Installation / Assembl y 15 2009 Fireplaces and Firepits L TR20091006, Rev . B w w w . c a l s p a s . c o m Fireplace Log Set Placement The log set, log grate and crushed lav a rock are shipped together on applicable models. Remove the log set and un-pack al l components.
16 Installation / Assembl y 2009 Fireplaces and Firepits L TR20091006, Rev . B w w w . c a l s p a s . c o m “Fire on Ice” Glass Placement Some re pit owners have the “Fire on Ice” option which uses decora - tive glass chips instead of lava rocks and a log set.
Installation / Assembl y 17 2009 Fireplaces and Firepits L TR20091006, Rev . B w w w . c a l s p a s . c o m High Elevation Installation Y our replace or re pit is approved for elevations up to 4500 feet in the US and Canada.
18 Installation / Assembl y 2009 Fireplaces and Firepits L TR20091006, Rev . B w w w . c a l s p a s . c o m low a controlled amount of air ow through the screen and into the fuel supply tube.
Using Y our Grill 19 2009 Fireplaces and Firepits L TR20091006, Rev . B w w w . c a l s p a s . c o m WARNING: DO NOT use solid fuel, such as wood or charcoal, in gas fueled replaces or re pits. Upon completing the gas line connection, a small amount of air will be in the lines.
20 Using Y our Grill 2009 Fireplaces and Firepits L TR20091006, Rev . B w w w . c a l s p a s . c o m Do not use this appliance if any part has been under water . Imme- • diately call a qualied service technician to inspect the appliance and replace any part of the control system and any gas control which has been under water .
Using Y our Grill 21 2009 Fireplaces and Firepits L TR20091006, Rev . B w w w . c a l s p a s . c o m To Turn Off Gas T urn the ON/OFF valv e to the off position at the unit for natural gas unit. F or LP unit, turn the ON/OFF v alve to the OFF position at the unit and then turn the valv e on the LP tank to the OFF position clockwise.
22 Using Y our Grill 2009 Fireplaces and Firepits L TR20091006, Rev . B w w w . c a l s p a s . c o m Lighting Your Wood Burning Fireplace Y our wood burning replace is designed to use a grate to hold the wood to be burned approximately 2”-3” off the base.
Cleaning and Maintenance 23 2009 Fireplaces and Firepits L TR20091006, Rev . B w w w . c a l s p a s . c o m Inspect the appliance before initial use. Clean the appliance at least annually and have it inspected by a qualied eld service person. Periodically remov e the logs and examine the burner .
24 Appendix 2009 Fireplaces and Firepits L TR20091006, Rev . B w w w . c a l s p a s . c o m Replacement Parts Call 1-800-CAL-SPAS for any replacement parts not listed below.
Appendix 25 2009 Fireplaces and Firepits L TR20091006, Rev . B w w w . c a l s p a s . c o m Firepit Parts NG Orice .125 BBQ04100077 Propane Orice #43 BBQ04100078 Replacement Crushed La va Rock .
26 Appendix 2009 Fireplaces and Firepits L TR20091006, Rev . B w w w . c a l s p a s . c o m Specications Fireplace Specications LP Gas Natural Gas Max.
Appendix 27 2009 Fireplaces and Firepits L TR20091006, Rev . B w w w . c a l s p a s . c o m See your Cal Flame dealer f or a copy of the applicable w arranty , details and any questions you may hav e regarding the warr anty cover age on your re pit or replace.
28 Appendix 2009 Fireplaces and Firepits L TR20091006, Rev . B w w w . c a l s p a s . c o m Neglect • The use of components not supplied with the appliance • The use of fuel other than those spec.
Appendix 29 2009 Fireplaces and Firepits L TR20091006, Rev . B w w w . c a l s p a s . c o m.
L TR20091006, Rev . B 3/30/09 CONTACT INFORMATION For customer service, please contact your authorized dealer immediately . If you need additional information and/or assistance, please contact: Customer Service Department 1462 East Ninth Street Pomona, CA 91766 T oll Free: 1-800-CAL -SPAS F ax: 1-909-629-3890 www.
デバイスCal Flame LTR20091006の購入後に（又は購入する前であっても）重要なポイントは、説明書をよく読むことです。その単純な理由はいくつかあります：
Cal Flame LTR20091006をまだ購入していないなら、この製品の基本情報を理解する良い機会です。まずは上にある説明書の最初のページをご覧ください。そこにはCal Flame LTR20091006の技術情報の概要が記載されているはずです。デバイスがあなたのニーズを満たすかどうかは、ここで確認しましょう。Cal Flame LTR20091006の取扱説明書の次のページをよく読むことにより、製品の全機能やその取り扱いに関する情報を知ることができます。Cal Flame LTR20091006で得られた情報は、きっとあなたの購入の決断を手助けしてくれることでしょう。
Cal Flame LTR20091006を既にお持ちだが、まだ読んでいない場合は、上記の理由によりそれを行うべきです。そうすることにより機能を適切に使用しているか、又はCal Flame LTR20091006の不適切な取り扱いによりその寿命を短くする危険を犯していないかどうかを知ることができます。
ですが、ユーザガイドが果たす重要な役割の一つは、Cal Flame LTR20091006に関する問題の解決を支援することです。そこにはほとんどの場合、トラブルシューティング、すなわちCal Flame LTR20091006デバイスで最もよく起こりうる故障・不良とそれらの対処法についてのアドバイスを見つけることができるはずです。たとえ問題を解決できなかった場合でも、説明書にはカスタマー・サービスセンター又は最寄りのサービスセンターへの問い合わせ先等、次の対処法についての指示があるはずです。
