Cal SpasメーカーSaunasの使用説明書/サービス説明書
ページ先へ移動 of 48
L TR20091007 , Rev . A 12/16/08.
Copyright 2009 LMS, Inc. All rights reserved. Duplication without written consent is strictly prohibited. Cal Spas™ and Cal Heat™ are registered tr ademarks. Due to continuous improvement progr ams, all models, operation, and/or specications are subject to change without prior notice.
2009 Saunas L TR20091007 , Rev . A Safety Instructions 3 When installing and using this electrical • equipment, basic safety precautions should always be f ollowed. T o reduce the risk of injury , do not allow children • to use this equipment unless they ar e supervised at all times.
2009 Saunas L TR20091007 , Rev . A Pr eparing F or Y our New Sauna 4 Most cities and counties requir e permits for exterior construction and electrical circuits.
2009 Saunas L TR20091007 , Rev . A Pr eparing F or Y our New Sauna 5 Preparing a Good Foundation Y our retailer has a wealth of information and experience about how to get the most out of your sauna. Y our sauna retailer also has a full line of accessories that are designed to complement your sauna.
2009 Saunas L TR20091007 , Rev . A Pr eparing F or Y our New Sauna 6 Custom Sauna Dimensions Model Depth Width Height CU-210 4’ 6’ 7’ CU-300 6’ 6’ 7’ CU-400 7’ 7’ 7’.
2009 Saunas L TR20091007 , Rev . A Pr eparing F or Y our New Sauna 7 IMPORTANT: When instal led in the United States, the electrical wiring of this sauna must meet the requirements of the National Electric Code (NEC) and any applicable state or local codes.
2009 Saunas L TR20091007 , Rev . A Assembling Y our Sauna 8 CU-210 Sauna Assembly Remo ve the packaging panel marked “OPEN THIS END” rst to access the contents. Once the panel is removed, unscrew the cross-member support f rom inside the crate.
2009 Saunas L TR20091007 , Rev . A Assembling Y our Sauna 9 Figure 1. Bench assembly Figure 2. Bench and heater installation.
2009 Saunas L TR20091007 , Rev . A Assembling Y our Sauna 10 Figure 3. Attaching the rear and side wall.
2009 Saunas L TR20091007 , Rev . A Assembling Y our Sauna 11 Figure 4. Attaching the front and side wall.
2009 Saunas L TR20091007 , Rev . A Assembling Y our Sauna 12 Figure 5. Installing the heater guard and roof trim.
2009 Saunas L TR20091007 , Rev . A Assembling Y our Sauna 13 Figure 6. Attaching the roof and exterior framing.
2009 Saunas L TR20091007 , Rev . A Assembling Y our Sauna 14 CU-300 Sauna Assembly Remo ve the packaging panel marked “OPEN THIS END” rst to access the contents. Once the panel is removed, unscrew the cross-member support f rom inside the crate.
2009 Saunas L TR20091007 , Rev . A Assembling Y our Sauna 15 Figure 2. Bench and heater installation Figure 1. Bench assembly.
2009 Saunas L TR20091007 , Rev . A Assembling Y our Sauna 16 Figure 3. Attaching the rear walls and back support.
2009 Saunas L TR20091007 , Rev . A Assembling Y our Sauna 17 Figure 4. Attaching the side walls.
2009 Saunas L TR20091007 , Rev . A Assembling Y our Sauna 18 Figure 5. Attaching the front wall with door.
2009 Saunas L TR20091007 , Rev . A Assembling Y our Sauna 19 Figure 6. Attaching the roof and exterior framing.
2009 Saunas L TR20091007 , Rev . A Assembling Y our Sauna 20 Figure 7. Attaching roof trim and heater protector.
2009 Saunas L TR20091007 , Rev . A Assembling Y our Sauna 21 CU-400 Sauna Assembly Remov e the packaging panel marked “OPEN THIS END” rst to access the contents. Once the panel is removed, unscrew the cross-member support f rom inside the crate.
2009 Saunas L TR20091007 , Rev . A Assembling Y our Sauna 22 Figure 1. Bench assembly.
2009 Saunas L TR20091007 , Rev . A Assembling Y our Sauna 23 Figure 2. Bench and oor attachment.
2009 Saunas L TR20091007 , Rev . A Assembling Y our Sauna 24 Figure 3. Attaching the rear walls and back support.
2009 Saunas L TR20091007 , Rev . A Assembling Y our Sauna 25 Figure 4. Attaching side walls.
2009 Saunas L TR20091007 , Rev . A Assembling Y our Sauna 26 Figure 5. Attaching the front wall with door.
2009 Saunas L TR20091007 , Rev . A Assembling Y our Sauna 27 Figure 6. Attaching the roof and heater protector.
2009 Saunas L TR20091007 , Rev . A Assembling Y our Sauna 28 The assembly of this sauna will require at least three people. The panels, roof top and roof assembly are heavy and difcult to lift by only one person. Assemble the bench. Screw the legs into the underside cross-support of the bench.
2009 Saunas L TR20091007 , Rev . A Assembling Y our Sauna 29 Place roof top panel onto the wall panel assembly . Place the 1” x 2” roof supports, inside the sauna, up 4. against the roof top. Place the outside trim piece(s) ush with top of the roof .
2009 Saunas L TR20091007 , Rev . A Assembling Y our Sauna 30 WARNING: IT WILL T AKE TWO OR MORE PEOPLE T O INST ALL THE ROOF T OP . DO NO T A T TEMPT T O LIF T IT BY YOURSELF . T ake each roof section and place side-by-side. Make sure the cross-beams are exposed and facing each 7 .
2009 Saunas L TR20091007 , Rev . A Assembling Y our Sauna 31 OD-200 Assembly Remov e the packaging panel marked “OPEN THIS END” rst to access the contents. Once the panel is removed, unscrew the cross-member support f rom inside the crate. R emove the contents from the cr ate and assemble in a place with adequate room.
2009 Saunas L TR20091007 , Rev . A Assembling Y our Sauna 32 Place roof top panel onto the wall panel assembly . Place the 1” x 2” roof supports, inside the sauna, up 4. against the roof top. Place the outside trim piece(s) ush with top of the roof .
2009 Saunas L TR20091007 , Rev . A Assembling Y our Sauna 33 WARNING: IT WILL T AKE TWO OR MORE PEOPLE T O INST ALL THE ROOF T OP . DO NO T A T TEMPT T O LIF T IT BY YOURSELF . T ake each roof section and place side-by-side. Make sure the cross-beams are exposed and facing each 7 .
2009 Saunas L TR20091007 , Rev . A Assembling Y our Sauna 34 Light Installation (Inside and Outside) NOTE: It is advised that all electrical connections be made by a licensed electrician. Use the decorativ e light for the outside. Attach the black wires to each other and attach the white wires to each other .
2009 Saunas L TR20091007 , Rev . A Assembling Y our Sauna 35 Heater Electrical Installation The electrical heater is UL approved for permanent installations and electrical connections. Built with splash proof construction, the conducting parts are protected against water .
2009 Saunas L TR20091007 , Rev . A Operating Y our Sauna 36 Safety Precautions Review all the health and safet y instructions. If in doubt as to the advisability of using your sauna, consult your physician. If you feel light-headed or heat-exhausted during a session, exit the sauna immediately .
2009 Saunas L TR20091007 , Rev . A Operating Y our Sauna 37 How to Take a Sauna When taking a sauna, allow for time to relax. • Remo ve clothing and jewelry . If required, wear • a towel loosely . After 10 minutes or when perspiration begins, • leave the sauna and relaxe in the dressing area.
2009 Saunas L TR20091007 , Rev . A Ster eo System 38 Spas equipped with the marine grade audio system use the Aquatic stereo receiver , amplier and CD player . Each sauna equipped with this audio system is delivered with the manufacturer’ s operating instructions.
2009 Saunas L TR20091007 , Rev . A Ster eo System 39 Mounting the Speaker and Speaker Box T o mount the speaker box, place the L -bracket on the underside of the main bench and attach the 1. L -bracket using the provided scr ews. Slide the speak er box up between the L -brackets and attach them with four screws through the sides of 2.
2009 Saunas L TR20091007 , Rev . A Appendix 40 Cleaning and Maintenance A sauna requires little care and virtually no maintenance at all. When nished using the sauna, propping the door open wi ll allow good air ow to dry out all of the wood surfaces.
2009 Saunas L TR20091007 , Rev . A Appendix 41 Troubleshooting Guide PROBLEM : SOLUTION : There is no power. Make sure that both ends of the power cord are securely plugged in to their r espective power 1. outlets. Make sure that the circuit break er has not been tripped.
2009 Saunas L TR20091007 , Rev . A Appendix 42 Accessories The following is a list of all the accessories that you can use wi th your Cal Sauna. If you wish to order an accessory , f eel fr ee to contact your dealer with the desired part name and part number , or visit www .
2009 Saunas L TR20091007 , Rev . A Appendix 43 CU300 CU400 Standard electrical rating two power source: One for heater and one for light Optional Options Electrical Ratings Service 1 Heater ratings CD player ratings Phase 1 Phase 1 V oltage 240 V AC V oltage 120 V AC Amperage 33.
2009 Saunas L TR20091007 , Rev . A Appendix 44 Replacement Parts The following section contains the part numbers that will be needed for your reference in the event that parts need to be ordered.
2009 Saunas L TR20091007 , Rev . A Appendix 45 OD-100 Description Part Number Quantity FRONT P ANEL, 69”x83”, ASPEN W0027100201 1 SAUNA LIGHT (PURCHASED COMPLETE) LIT16000020 1 DOOR P ANEL, 69”x.
2009 Saunas L TR20091007 , Rev . A Appendix 46 5 Year Structural (Outdoor Saunas) LMS warr ants its Outdoor Saunas exterior siding against defects in materials and workmanship for a period of v e years from the original date of purchase.
2009 Saunas L TR20091007 , Rev . A Appendix 47 Warranty Exclusions The Limited W arranty is void if the sauna has been subject to negligence, alteration, misuse, abuse, repairs by non-LMS authorized repr esentatives, incorrect electrical installation, acts of God and an y other cases beyond the control of LMS.
Locating the product serial number The serial number of your Cal Heat sauna is located on a metal plate attached to the lower side of the sauna.Y ou will need this number to properly register your sauna and activate cover age. W rite this information in the space provided below .
デバイスCal Spas Saunasの購入後に（又は購入する前であっても）重要なポイントは、説明書をよく読むことです。その単純な理由はいくつかあります：
Cal Spas Saunasをまだ購入していないなら、この製品の基本情報を理解する良い機会です。まずは上にある説明書の最初のページをご覧ください。そこにはCal Spas Saunasの技術情報の概要が記載されているはずです。デバイスがあなたのニーズを満たすかどうかは、ここで確認しましょう。Cal Spas Saunasの取扱説明書の次のページをよく読むことにより、製品の全機能やその取り扱いに関する情報を知ることができます。Cal Spas Saunasで得られた情報は、きっとあなたの購入の決断を手助けしてくれることでしょう。
Cal Spas Saunasを既にお持ちだが、まだ読んでいない場合は、上記の理由によりそれを行うべきです。そうすることにより機能を適切に使用しているか、又はCal Spas Saunasの不適切な取り扱いによりその寿命を短くする危険を犯していないかどうかを知ることができます。
ですが、ユーザガイドが果たす重要な役割の一つは、Cal Spas Saunasに関する問題の解決を支援することです。そこにはほとんどの場合、トラブルシューティング、すなわちCal Spas Saunasデバイスで最もよく起こりうる故障・不良とそれらの対処法についてのアドバイスを見つけることができるはずです。たとえ問題を解決できなかった場合でも、説明書にはカスタマー・サービスセンター又は最寄りのサービスセンターへの問い合わせ先等、次の対処法についての指示があるはずです。
