Craftsmanメーカー919.17673gの使用説明書/サービス説明書
ページ先へ移動 of 18
S_FA/RS OWNERS MANUAL MODEL NO. 919.17673g 919.17683 aMPORTANT: Read the Safety Guidelines and AH instructions Carefully Before Operating CRAFTSMAN AiR COMPRESSOR ASSEMBLY OPERATION MAINTENANCE REPAIR PARTS Record in the spaces provided. (1) The model number which can be found on the tabel on the rear of the air tank.
TABLE OF CONTENTS Page .................................................................. 3 SAFETY GU_DEUNES ........................................................ 3 WARNING CHART ............................................................. 3 SPECIFICATION CHART .
FULL ONE YEAR WARRANTY ON COMPRESSORS if this air compressor fans due to a defect in material or workmanship within one year from the date of purchase, return it to the nearest Sears Service Center/Department throughout the United States and Sears wiii repair it, free of charge.
WHAT TO LOOK FOR WHAT COULD HAPPEN NOW TO PREVENT }T Hot Parts The compressor head and tubes get hot when Never touch the air compressor head or tubes dar- the air compressor is running. If you touch them, ing or immediately after operation. you can be seriously burned.
SPEC_FICATION CHART Modem No. 919.176730 9t&176830 Horsepower 3 3 Displacement CFM 11.3 11.3 Bore 2%" 2%" Stroke 2" 2" Voltage-Single Phase !20/240"* 120/240"* Minimu.
ACCESSORIES FOR USE WiTH SEARS COMPRESSORS The following accessories are available through the current general sales catalog or at fuliqJne Sears stores. ,SPRAY GUNS °BLOW GUNS oAIR CAULKING GUNS oAIR POWERED WASHER GUNS ,SAND BLASTERS °AIR BRUSHES oAIR LINE FILTERS oTIRE AIR CHUCKS .
Pressure Switch: The pressure switch automatically starts the motor when the sir tank pressure drops below the factory set"cat-in" pressure, it stops the motor when the air tank pressure reaches the factory set "cut-out" pressure. Regumstor: The air pressure coming from the air tank is controlled by the regulator knob.
GUARD t Jt may be necessary to brace or support one end of the outfit when attaching the wheels because the air compressor will have a tendency to tip. mnstagJiag Rubber Foot Strip and Wheels t. Remove the protective paper strip from the adhesive- backed rubber foot strip.
Grounding _nstructions iMPROPER GROUNDING CAN RESULT tN ELECTRICAL SHOCK= IN THE EVENT OF A SHORT CIRCUIT, GROUNDING REDUCES THE RiSK OF SHOCK BY PROViDiNG AN ESCAPE WiRE FOR THE ELECTRIC CUR- RENT, THIS A_R COMPRESSOR MUST BE PROPERLY GROUNDED.
NOTE W'_TER WILL CONDENSE IN THE A_R TANK. mF NOT DRAtNED_ WATER W_LL CORRODE AND WEAKEN THE AR TANK; CAUSING A R_SK OF AIR TANK RUPTUREo 1!. With tank pressure at approximately 20 psi., open the drain cock (key 43, pg. 14) and atlow moisture to drain.
NOTE If the overload protector shuts the motor offfre- quently, check for a possible voltage problem Low voltage can alsobe suspected when: 1. the motor does not get up to fulI power or speed; 2. fuses blow out when the motor is started. 3. lights dim when motor is started, and remain dim while it is running.
TROUBLESHOOTING GUIDE (continued) PROBLEM CAUSE CORRECTION Air leaks at check valve Defective or dirty check valve. A defective check valve results in a constant air teak at the pressure reiease valve when there is pressure in the tank and the compressor is shut off.
PROBLEM Excessive belt wear (continued) CORRECTION Adjust tension. See Belt Replacement, pg, 11. Adjust tension. See Belt Replacement, pg. 11. Check for worn keyway or pulley bore. Also check for bent motor shaft. Replace parts if necessary. TROUBLESHOOTING GUIDE CAUSE Loose belt, Tight belt.
AIR COMPRESSOR DtAGRAM (view from back} 54 53 52 5O 48 2 55 "58 !8 34 I7 14 12 "43 51A _J 35 (Model No. shown here) 42 4! (See pg. 8, Step 2 for proper wheel placement and assembly) 14.
COMPRESSOR PUMP D_AGRAM 89 82 83 (od "Ill p ugl / / / _o_, dra,n plug} _5.
r PARTS LiST KEY NO PART NUMBER f CAC=322 2 CAC_323 3 SSF-8113-ZN 4 CAC-327 5 CACo4OG3-1 6 9=16279 7 265-18 8 SSF-935 9 LA-1779 10 STD575051 11 STD575050 12 CAC-317 13 TIA-4325 TIA-4125 14 C-GA-345 15.
55 C-BT-222 56 SSN°1619oZN 57 SSN=56=ZN 58 CAC-1011 59 SSFo6627 60 CAC-293 61 SSF-955 62 SS=8553 ($3 SSP=940t _/ 84 CAC=291 O 65 265-25 66 SSF-9821 67 CACo294 68 265=196 69 CA0-289 70 CAC-54_1 71 CAC.
OWNERS MANUAL SERVICE MODEL NO. 919.176730 919.176830 HOW TO ORDER REPAIR PARTS CRAFTSMAN AIR COMPRESSOR Now that you have purchased your Sears Air Compressor, should a need ever exist for repair parts or service, simply contact any Sears Service Center and most Sears, Roebuck and Co.
デバイスCraftsman 919.17673gの購入後に（又は購入する前であっても）重要なポイントは、説明書をよく読むことです。その単純な理由はいくつかあります：
Craftsman 919.17673gをまだ購入していないなら、この製品の基本情報を理解する良い機会です。まずは上にある説明書の最初のページをご覧ください。そこにはCraftsman 919.17673gの技術情報の概要が記載されているはずです。デバイスがあなたのニーズを満たすかどうかは、ここで確認しましょう。Craftsman 919.17673gの取扱説明書の次のページをよく読むことにより、製品の全機能やその取り扱いに関する情報を知ることができます。Craftsman 919.17673gで得られた情報は、きっとあなたの購入の決断を手助けしてくれることでしょう。
Craftsman 919.17673gを既にお持ちだが、まだ読んでいない場合は、上記の理由によりそれを行うべきです。そうすることにより機能を適切に使用しているか、又はCraftsman 919.17673gの不適切な取り扱いによりその寿命を短くする危険を犯していないかどうかを知ることができます。
ですが、ユーザガイドが果たす重要な役割の一つは、Craftsman 919.17673gに関する問題の解決を支援することです。そこにはほとんどの場合、トラブルシューティング、すなわちCraftsman 919.17673gデバイスで最もよく起こりうる故障・不良とそれらの対処法についてのアドバイスを見つけることができるはずです。たとえ問題を解決できなかった場合でも、説明書にはカスタマー・サービスセンター又は最寄りのサービスセンターへの問い合わせ先等、次の対処法についての指示があるはずです。
