Hearth and Home Technologiesメーカー823-0170 - MBKの使用説明書/サービス説明書
ページ先へ移動 of 40
www .quadrafi re.com Isle Royale Non-Catalytic, T op-load, W ood Heater 250-5763E Models: 823-0170 - MBK 823-0290 - PMH O-T L Te s ted and Listed by Portland Oregon USA OMNI-T est Laborator ies, Inc. C US DO NOT DISCARD THIS MANUAL CAUTION • Important operating a n d m a i n t e n a n c e instructions included.
R Page 2 November 22, 201 1 Isle Royale W ood Stove 250-5763E and Welcome to the Quadra-Fire Family ! Hearth & Home T echnologies welcomes you to our tradi- tion of excellence! In choosing a Quadra-Fire appliance, you have our assurance of commitment to quality , durabil- ity , and performance.
Page 3 Isle Royale W ood Stove R 250-5763E November 22, 201 1 Section 1: Listing and Code Approvals A. Appliance Certifi cations ...................... 4 B. Mobile Home Approved ...................... 4 C. Glass Specifi cations .....................
R Page 4 November 22, 201 1 Isle Royale W ood Stove 250-5763E The Quadra-Fire Isle Royale Wood Stove meets the U.S. Environmental Protection Agency’s 1990 particulate emis- sion standards. A. Appliance Certifi cation C. Glass Specifi cations D. BTU & Effi ciency Specifi cations This stove is equipped with 5mm ceramic glass.
Page 5 Isle Royale W ood Stove R 250-5763E November 22, 201 1 2 Getting Started A . Design, Installation & Location Consider ations Consideration must be given to: • Safety • Convenience • T.
R Page 6 November 22, 201 1 Isle Royale W ood Stove 250-5763E Marginal Location: • Below peak Location NOT recommended: • Not the highest point of the roof • Wind loading possible Multi-level Ro.
Page 7 Isle Royale W ood Stove R 250-5763E November 22, 201 1 Ex te ri or co nd iti on s s uc h a s ro of li ne , s urr ou nd in g tr ee s, p r e v a i l i n g w i n d s a n d n e a r b y h i l l s c a n i n f l u e n c e s t o v e pe rf or ma nce.
R Page 8 November 22, 201 1 Isle Royale W ood Stove 250-5763E Floor Protector Chi mney Co nne ctor Insulated " T " Flashing Lis ted Term inat ion C ap T r im C olla r on Ins ide Wa ll Listed.
Page 9 Isle Royale W ood Stove R 250-5763E November 22, 201 1 29" (737mm) 28-3/4" (730mm) 30" (762mm) C L 8-1/4" (210mm) 16-1/2" (419mm) 24-5/8" (625mm) 26-7/16" (570mm) 30" (762mm) 22-3/4" (578mm) 16-3/4" (425mm) 3 Dimensions and Clearances A.
R Page 10 November 22, 201 1 Isle Royale W ood Stove 250-5763E B A C D B. Clearances T o Combustibles (UL And ULC) G H Ceiling I E E F F I** C L J* 8 in.
Page 1 1 Isle Royale W ood Stove R 250-5763E November 22, 201 1 CANADA 203mm (8") 203mm (8") 203mm (8") 457mm (18") 1219mm (48") Minimum 11 37mm (44-3/4") Minimum 16".
R Page 12 November 22, 201 1 Isle Royale W ood Stove 250-5763E B. Reversible Flue Collar The fl ue collar is reversible for either a top or rear venting installation. The unit is shipped with the fl ue collar in the top vent position. Converting Collar For Rear V ent Installation 1.
Page 13 Isle Royale W ood Stove R 250-5763E November 22, 201 1 OUTSIDE AIR TERMINA TION CAP (contains rodent screen) FLEX FLANGE 1 . Remove all materials from packing box. 2. Mount the fl ex fl ange (with pipe fi tting extending out), over the intake air opening at the rear of stove using the four mounting screws supplied with kit.
R Page 14 November 22, 201 1 Isle Royale W ood Stove 250-5763E NOTE: I n Canada when using a factory-built chimney it must be safety listed, Type UL103 HT (2100 o F) CLASS “A” or conforming to CAN/ULC-S629M, STANDARD FOR 650 o C FACTORY-BUILT CHIMNEYS.
Page 15 Isle Royale W ood Stove R 250-5763E November 22, 201 1 Thimble Site constructed for masonry chimney installation: Components • A minimum length of 12 inches [305mm] (longer for thicker walls) of solid insulated factory-built chimney length constructed to UL 103 T ype HT 6 inch (152mm) inside diameter .
R Page 16 November 22, 201 1 Isle Royale W ood Stove 250-5763E Chimney Height / Rise and Run T hi s p r od uc t wa s d e si gn ed f or a nd t es te d on a 6 in c h (152mm) chimney , 12 to 14 feet (420-480cm) high, (includes stove height) measured from the base of the appliance to the t he to p o f the ch imn ey (n ot inc lud ing c himn ey ca p).
Page 17 Isle Royale W ood Stove R 250-5763E November 22, 201 1 C. Installing Chimney Components Chimney Connector Single wall connector or stove pipe. This must be at least 24 gauge mild steel or 26 gauge blue steel. The sections must be attached to the appliance and to each other with the crimped (male) end pointing toward the stove.
R Page 18 November 22, 201 1 Isle Royale W ood Stove 250-5763E D. Chimney T ermination Requirements Follow manufacturer ’s instructions for clearance, securing fl ashing and terminating the chimney .
Page 19 Isle Royale W ood Stove R 250-5763E November 22, 201 1 6 Mobile Home Installation 10. Burn w ood only . Other t ypes of fuels may generate poisonous gases (e.g., carbon monoxide). 1 1. I f unit burns poo rly while an exh aust blower is o n in home, (i.
R Page 20 November 22, 201 1 Isle Royale W ood Stove 250-5763E 7 Appliance Set-Up Locknut Door Cross Section Latch Cam Spacing W ashers Square Key Handle T eflon W asher DO NOT REMOVE Included in Kit .
Page 21 Isle Royale W ood Stove R 250-5763E November 22, 201 1 Do not over-fi re. Over-fi ring may ignite creosote or will damage the stove and chimney .
R Page 22 November 22, 201 1 Isle Royale W ood Stove 250-5763E Moisture Seasoned Wood • Cut logs to size • Split to 6 inches (152 mm) or less in diameter • Air dry to a moisture content of not m.
Page 23 Isle Royale W ood Stove R 250-5763E November 22, 201 1 Primary Air Slide Control Start-Up Air Control Start-Up Air System The combustion air enters at the rear of the fi rebox through the rear air tubes. This air supply is controlled by the Start- up Air Control.
R Page 24 November 22, 201 1 Isle Royale W ood Stove 250-5763E F . Operating The T op Loading Option 1. Using a 7/16 wrench, remove the 2 sh ipping bolt s under- neath the griddle before lifting the griddle off of stove. 2. Open by-pass door by moving the side handle towards rear of stove.
Page 25 Isle Royale W ood Stove R 250-5763E November 22, 201 1 There are many ways to build a fi re. The basic principle is to light easily-ignitable tinder or paper , which ignites the fast burning kindling, which in turn ignites the slow-burning fi rewood.
R Page 26 November 22, 201 1 Isle Royale W ood Stove 250-5763E 1. Initial (cold) start-up : Leav e blower off until your stove is hot and a good coalbed is established. The blower may be turned on approxi mate ly 30 m inutes after a good coalbed is established.
Page 27 Isle Royale W ood Stove R 250-5763E November 22, 201 1 A. General Maintenance Inspection: Inspect the sy stem at the appliance connec tion and at the chimney top. Cooler surfaces tend to build creosote deposits quicker , so it is important to check the chimney from the top as well as from the bottom.
R Page 28 November 22, 201 1 Isle Royale W ood Stove 250-5763E 4. Cleaning Plated Surfaces • Frequency: Prior to first burn and then as desired • By: Homeowner Clean all the fi ngerprints and oils from plated surfaces BEFORE fi ring the appliance for the fi rst time.
Page 29 Isle Royale W ood Stove R 250-5763E November 22, 201 1 D. Glass Replacement 1 . Ensure that the fi re is out and the appliance is cool to the touch. 2. Protect a table or counter top with padding or towels. Protect your hands and wear gloves to pr event i njury .
R Page 30 November 22, 201 1 Isle Royale W ood Stove 250-5763E Note: These are generic drawings and may not represent your specifi c model. CAUTION! Allow the appliance to completely cool down before performing any cleaning or maintenance.
Page 31 Isle Royale W ood Stove R 250-5763E November 22, 201 1 With proper installation, operation, and maintenance your woodstove will provide years of trouble-free service. If you do experience a problem, this troubleshooting guide will assist you or a qualifi ed service person in the diagnosis of a problem and the corrective action to be taken.
Page 32 250-5763E November 22, 201 1 A. Exploded Drawing Service Parts 1 2 3 4 5 6 7 8 9 13 14 15 16 17 18 19 12 10 1 1 Non -Ca talyt ic, T op-L oad, W ood St ove Isle Royale Part number list on following page.
Page 33 250-5763E November 22, 201 1 B. Service Parts and Accessories Service Parts IMPORT ANT : THIS IS DA TED INFORMA TION. When requesting service or replacement parts for your appliance please provide model number and serial number . All parts listed in this manual may be ordered from an authorized dealer .
Page 34 250-5763E November 22, 201 1 Service Parts IMPORT ANT : THIS IS DA TED INFORMA TION. When requesting service or replacement parts for your appliance please provide model number and serial number . All parts listed in this manual may be ordered from an authorized dealer .
Page 35 250-5763E November 22, 201 1 Service Parts IMPORT ANT : THIS IS DA TED INFORMA TION. When requesting service or replacement parts for your appliance please provide model number and serial number . All parts listed in this manual may be ordered from an authorized dealer .
Page 36 250-5763E November 22, 201 1 Service Parts IMPORT ANT : THIS IS DA TED INFORMA TION. When requesting service or replacement parts for your appliance please provide model number and serial n umber . All parts listed in this manual may be ordered from an authorized dealer .
Page 37 Isle Royale W ood Stove R 250-5763E November 22, 201 1 Date of Service Performed By Description of Service C. Service And Maintenance Log.
R Page 38 November 22, 201 1 Isle Royale W ood Stove 250-5763E D. W arranty Policy.
Page 39 Isle Royale W ood Stove R 250-5763E November 22, 201 1.
R Page 40 This product may be covered by one or more of the following patents: (United States) 5341794, 5263471, 6688302, 7216645, 7047962 or other U.S. and foreign patents pending. Hearth & Home T echnologies 1445 North Highway Colville, W A 991 14 Division of HNI INDUSTRIES www .
デバイスHearth and Home Technologies 823-0170 - MBKの購入後に（又は購入する前であっても）重要なポイントは、説明書をよく読むことです。その単純な理由はいくつかあります：
Hearth and Home Technologies 823-0170 - MBKをまだ購入していないなら、この製品の基本情報を理解する良い機会です。まずは上にある説明書の最初のページをご覧ください。そこにはHearth and Home Technologies 823-0170 - MBKの技術情報の概要が記載されているはずです。デバイスがあなたのニーズを満たすかどうかは、ここで確認しましょう。Hearth and Home Technologies 823-0170 - MBKの取扱説明書の次のページをよく読むことにより、製品の全機能やその取り扱いに関する情報を知ることができます。Hearth and Home Technologies 823-0170 - MBKで得られた情報は、きっとあなたの購入の決断を手助けしてくれることでしょう。
Hearth and Home Technologies 823-0170 - MBKを既にお持ちだが、まだ読んでいない場合は、上記の理由によりそれを行うべきです。そうすることにより機能を適切に使用しているか、又はHearth and Home Technologies 823-0170 - MBKの不適切な取り扱いによりその寿命を短くする危険を犯していないかどうかを知ることができます。
ですが、ユーザガイドが果たす重要な役割の一つは、Hearth and Home Technologies 823-0170 - MBKに関する問題の解決を支援することです。そこにはほとんどの場合、トラブルシューティング、すなわちHearth and Home Technologies 823-0170 - MBKデバイスで最もよく起こりうる故障・不良とそれらの対処法についてのアドバイスを見つけることができるはずです。たとえ問題を解決できなかった場合でも、説明書にはカスタマー・サービスセンター又は最寄りのサービスセンターへの問い合わせ先等、次の対処法についての指示があるはずです。
