Lennox HearthメーカーVINの使用説明書/サービス説明書
ページ先へ移動 of 28
Report No. 50-S-1 1b-5 INST ALLA TION AND OPERA TION MANUAL W ARNINGS • Hot! Do not touch! The glass and surfaces of this appliance will be hot during operation and will retain heat for a while after shutting off the appliance. Severe burns may result.
2 FOR YOUR SAFETY do not install or operate your Vin- tage™ gas stove without first read ing and underst anding this manual. Any installation or operation of the appli- ance deviating from that which is stated in this manual WILL void the warranty and may be hazardous.
3 C ON GR A TU L A TI ON S O N TH E PU R CH AS E OF YO UR N EW G AS A PP LI A NC E MA NU F A CT UR ED B Y L EN N OX H EA R TH P RO DU CT S. When you purchased your new gas stove, you joined the ranks of thousands of individuals whose answer to their home heating needs reflect s their concern for efficiency and our environm ent.
4 ORIFICE SIZE/AL TITUDE ADJUSTMENT SMOKE DETECTORS CODES AND APPROV ALS THE VINT AGE™ STOVE Installation of these fireplaces are approved for installation in New Y ork City in the US state of New Y ork (MEA#: 138-07-E).
5 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. PRE-INST ALLA TION Pa nel Ki ts ( Re qu ire d) Ca t. No. Mo del De scr ipt ion 75 19 9 VI NT -C PS -B Ca st Ir on P an el Se t/ B la ck , Re ve .
6 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. Dimensions The gas line screws into the gas valve at the back of the stove 5” in from the right side of the stove and 4-3/16” up from the base of the unit. Preparing Y our Vintage™ Stove For Installation Read all instructions before beginning your installation.
7 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. Alcove Option 1 Alcove Option 3 Alcove Option 2 Carpet Leg 1-1/2” (38mm) Maximum Corner Installation Clearances to Combustibles Min imum clea ranc es to combus tibl e materi als sho wn here are in inch es (mi llim eter s).
8 Firebox Accessories / Parts Cat. No. Description H5861 Log Set H5863 Bag of Embers (volcanic stone) H5864 Bag of Rockwool (glowing embers) H5865 Bag of Steel Wool Log Installation Instructions If lo.
9 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. Side-Insert Installation Follow these steps to install the cast iron inserts or your own custom stone inserts in the Vintage™ gas stove: 1. Remove the cast iron top and set it aside. 2. Remove the cast iron upper piece A - see Figure 14.
10 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. Vent Installation V enting : The Vintage™ gas stove has been tested and listed as a direct vent heater system by OMNI-T est Laboratories, Beaverton, Oregon and is recommended for use with Security™ Secure Vent pipe*.
11 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. Vent Parts List Direct vent pipe Security™ Secure Vent™ * may be used with the Vintage™ gas stove. Please see the lists below to verify the components available from each dire ct vent pipe manufac turer .
12 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. Snorkel T erminations For installations requiring a vertical rise on the exterior of the building, 14-inch and 36-inch tall snorkel terminations are available. When us - ing a snorkel, the stove can be vented directly out the back.
13 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. A Flue Opening in the top of the firebox A Restrictor Restrictor Installed Over Flue Opening Figure 23 Figure 25 Figure 24 Flue Restrictors Th.
14 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. 8’ Max. Restrictor Position # 4 Restrictor Position # 3 Restrictor Position # 3 Restrictor Position # 2 No Restrictor 18” Section of Pipe Horizontal T erminations The shaded areas in the diagram below show all allowable combinations of vent configurations with horizontal terminations.
15 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. Exterior Horizontal Vent T ermination Clearance Requirements V V V V V F C B B A B H M I X V D V A A A V L B J X E V A G *18” 18” B C C C * S e e It e m D i n t h e T ex t Be lo w .
16 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. Gas Line Installation This stove must be connected to the gas line in accordance with local codes and/or the National Fuel Gas Code, ANSI Z223.1 (In Canada, the current CAN/CSA B149.1 installation code).
17 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. Operating Instructions Pre-Lighting Checklist Be sure to check these items before the initial lighting of the stove: c The stove gas label corresponds to the gas supply available - that is “natural gas” for natural gas or “LP gas” for LP gas.
18 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. W ARNINGS • Improper installation, adjustment, alteration, service or maintenance can cause injury or property damage. For assistance or additional infor mation , consult a qua lified inst aller , service agency or your gas supplier .
19 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. Optional Blower Wiring Diagram F AN SNAP SWITCH - N/O MAIN POWER CORD WIRE (BLACK) GROUND WIRE (GREEN) MAIN POWER CORD WIRE (WHITE) MAIN POWER .
20 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. Millivolt Control Schematic Thermopile ON/OFF Rocker Switch, Thermostat, or Remote Thermostat Piezo Igniter Thermocouple Pilot Gas Line Sparker.
21 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. Maintenance Checklist: The following should only be performed by a qualified ser vice technician. CAUTION: Label all wires prior to disconnection when ser vic- ing controls. Wiring errors can cause improper and dangerous operation.
22 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. Glass/Door Maintenance Cleaning: When cooled, the glass may be cleaned with a clean, soft cloth and a household glass cleaner . For cleaning white condensation from the interior glass use a gas stove glass cleaner available from your stove dealer .
23 TROUBLESHOOTING NOTE: When troubleshooting the gas control system, be sure the external gas shut off valve, located at the gas supply inlet is in the “ON” position. IMPORT ANT : Call your gas supplier or plumber for additional help with any gas control problem.
24 REPLACEMENT P ARTS Vi nta ge ™ M od el VI N Part Number Description H6031 Cassette Assembly , NG (if LP , also requires 75190 Conversion Kit) H5936 Burner Assembly H5947 Pilot Assembly NG H2830 P.
25 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. Pa nel Ki ts ( Re qu ire d) Ca t. No. Mo de l De scr ipt ion 75 19 9 VI NT -C PS -B C as t Ir on Pa ne l S et /B la ck , R ev er si bl e u H7 40 6 V I NT AG E-P K- BG Gal lo V en ez ia no St on e P an el s Ga s C onv ers i on K its Ca t.
26 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. VIN VENTED GAS FIREPLACE HEA TER - NOT FOR USE WITH SOLID FUEL MA Y BE INST ALLED IN RESIDENTIAL BEDROOMS AND MANUFACTURED (MOBILE) HOMES. TESTED TO ANSI Z21.88-2005/CSA 2.33-2005 “VENTED GAS FIREPLACE HEA TERS”, UL307b, CSA P .
27 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. LIGHTING LABEL CAUT ION: YOU R CO UNTR Y GAS APP LIAN CE MU ST AL W A YS BE OPER A TED WITH GLAS S DOO R IN PLAC E. STO P! R ead t he s afet y inf orma tion abov e bef ore proce edin g. 1. Open t he lo wer door .
28 Printed in U.S.A. © 2007 Lennox Hearth Products P/N 775,227M REV . D 11/2008 Lennox Hearth Products reser ves the right to make changes at any time, without notice, in design, materials, specifications, prices and also to discontinue colors, styles and products.
デバイスLennox Hearth VINの購入後に（又は購入する前であっても）重要なポイントは、説明書をよく読むことです。その単純な理由はいくつかあります：
Lennox Hearth VINをまだ購入していないなら、この製品の基本情報を理解する良い機会です。まずは上にある説明書の最初のページをご覧ください。そこにはLennox Hearth VINの技術情報の概要が記載されているはずです。デバイスがあなたのニーズを満たすかどうかは、ここで確認しましょう。Lennox Hearth VINの取扱説明書の次のページをよく読むことにより、製品の全機能やその取り扱いに関する情報を知ることができます。Lennox Hearth VINで得られた情報は、きっとあなたの購入の決断を手助けしてくれることでしょう。
Lennox Hearth VINを既にお持ちだが、まだ読んでいない場合は、上記の理由によりそれを行うべきです。そうすることにより機能を適切に使用しているか、又はLennox Hearth VINの不適切な取り扱いによりその寿命を短くする危険を犯していないかどうかを知ることができます。
ですが、ユーザガイドが果たす重要な役割の一つは、Lennox Hearth VINに関する問題の解決を支援することです。そこにはほとんどの場合、トラブルシューティング、すなわちLennox Hearth VINデバイスで最もよく起こりうる故障・不良とそれらの対処法についてのアドバイスを見つけることができるはずです。たとえ問題を解決できなかった場合でも、説明書にはカスタマー・サービスセンター又は最寄りのサービスセンターへの問い合わせ先等、次の対処法についての指示があるはずです。
