MakitaメーカーER2650LHの使用説明書/サービス説明書
ページ先へ移動 of 14
Model ER2650LH is a petrol string trimmer equipped with 25.4cm³ 4-stroke engine in compliance with all known exhaust emission regulations. Nylon cutting heads [Bump & feed 4, Ultra Auto 4] Dimensions: mm (") 310 (12-1/4) Width (W) Height (H) Length (L) 1,621 (64) 479 (18-7/8) PRODUCT P 1/ 1 4 ER2650LH Models No.
R epair CAUTION: Repair the machine in accordance with “Instruction manual” or “Safety instructions”. [4] DISASSEMBLY/ASSEMBLY [4]-1. Attention Follow the instructions below during repairing . • Wear glove to avoid injury. • Cool down the engine enough before repairing to avoid skin burn.
R epair [4] DISASSEMBLY/ASSEMBLY [4]-2. Engine and Shaft DISASSEMBLING ASSEMBLING (1) Disconnect lead wire and grounding wire by removing each connector after Air cleaner cover is removed. ( Fig. 1 ) (2) Remove Control cable from Insulator by loosening nuts of the adjust screw and disconnecting inner cable from Swivel of Carburetor.
[4] DISASSEMBL Y/ASSEMBL Y [4]-3. Shaft pipe complete DISASSEMBLING ASSEMBLING (1) Loosen two M5x25 Hex socket head bolts and remove Clamp cover B and Loop handle. ( Fig. 7 ) (2) Remove 4x18 Tapping screws (4pcs) and M5x14 Hex socket head bolts, then separate Lever case R and L.
Grind these edges. DISASSEMBLING ASSEMBLING (2) Disaasemble Cutter shaft and Ball bearings from Head case complete. ( Fig. 10 ) (1) Take reverse step of the disassembly. ( Fig. 10, 11 ) Note: • Pay attention to the assembly direction of Washer and Bearing washer .
[4] DISASSEMBL Y/ASSEMBL Y [4]-5. Clutch DISASSEMBLING DISASSEMBLING ASSEMBLING Disassemble Clutch by removing Shoulder hex bolt M6x25 (2pcs) with Cordless impact driver using 13mm Socket bit. ( Fig. 12 ) (1) Remove Clutch case section from the engine by unscrewing H.
[4] DISASSEMBL Y/ASSEMBL Y [4]-7. Ignition (1) Remove Plug cap from Spark plug and test the continuity between Plug cap spring in Plug cap and Earth terminal of Ignition coil.
1R364 a set of M6 bolts (components of 1R364) [4] DISASSEMBL Y/ASSEMBL Y [4]-8. Flywheel ASSEMBLING Insert Woodruff key 3 in the groove on Crankshaft and mount Flywheel, then tighten Flywheel with M8 Flange nut clockwise. Note: Wipe off grease and oil on Crankshaft to fit Flywheel tightly.
[4] DISASSEMBL Y/ASSEMBL Y [4]-9. Recoil starter ASSEMBLING Fig. 22 Fig. 23 DISASSEMBLING U-notch of Reel Inner hooked end of Spiral spring Outer hooked end of Spiral spring Reel M5x12 T apping screw .
[4] DISASSEMBL Y/ASSEMBL Y [4]-10. Carburetor DISASSEMBLING CLEANING / MAINTENANCE (1) Remove Air cleaner cover and disassemble Air cleaner. ( Fig. 24 ) (2) Remove H.S. button head bolt M5x60 (2pcs) completely, then disassemble Carburetor and Cleaner plate assembly from Insulator.
[4] DISASSEMBLY/ASSEMBLY [4]-10. Carburetor (cont.) Carefully assemble each part in right direction and order. ( Fig. 25 ) (1) Assemble Cleaner plate assembly, Carburetor and Gasket to Insulator with two M5x60 Hex socket head bolts.
MAINTENANCE DISASSEMBLY Fig. 31 Spark arrester Exhaust muffler [4] DISASSEMBLY/ASSEMBLY [4]-13. Spark arrester (1) Remove Cylinder cover. (2) Remove Exhaust Muffler. (3) Remove Spark arrester from Exhaust muffler and sweep it if dirt or soot is on Spark arrester.
[4] DISASSEMBLY/ASSEMBLY [4]-14. Engine block (cont.) Fig. 33 Fig. 34 ASSEMBLING Piston ring (top) 34 (1) Assemble Piston to Rod of Crankshaft. (Fig. 33) (2) Assemble Cylinder block assembly by fastening it with screws in crisscross pattern.
[4] DISASSEMBL Y/ASSEMBL Y [4]-14. Engine block (cont.) (3) Adjust the valve clearance by following the steps in Fig. 35 . Fig. 35 ASSEMBLY Marking on Ignition coil Marking on Flywheel Marking on Cam gear assembly Marking on Cylinder block 1R366 (0.1mm Feeler gauge) Offset wrench Hex wrench 2.
デバイスMakita ER2650LHの購入後に(又は購入する前であっても)重要なポイントは、説明書をよく読むことです。その単純な理由はいくつかあります:
Makita ER2650LHをまだ購入していないなら、この製品の基本情報を理解する良い機会です。まずは上にある説明書の最初のページをご覧ください。そこにはMakita ER2650LHの技術情報の概要が記載されているはずです。デバイスがあなたのニーズを満たすかどうかは、ここで確認しましょう。Makita ER2650LHの取扱説明書の次のページをよく読むことにより、製品の全機能やその取り扱いに関する情報を知ることができます。Makita ER2650LHで得られた情報は、きっとあなたの購入の決断を手助けしてくれることでしょう。
Makita ER2650LHを既にお持ちだが、まだ読んでいない場合は、上記の理由によりそれを行うべきです。そうすることにより機能を適切に使用しているか、又はMakita ER2650LHの不適切な取り扱いによりその寿命を短くする危険を犯していないかどうかを知ることができます。
ですが、ユーザガイドが果たす重要な役割の一つは、Makita ER2650LHに関する問題の解決を支援することです。そこにはほとんどの場合、トラブルシューティング、すなわちMakita ER2650LHデバイスで最もよく起こりうる故障・不良とそれらの対処法についてのアドバイスを見つけることができるはずです。たとえ問題を解決できなかった場合でも、説明書にはカスタマー・サービスセンター又は最寄りのサービスセンターへの問い合わせ先等、次の対処法についての指示があるはずです。