Cal FlameメーカーBarbeque Grillの使用説明書/サービス説明書
ページ先へ移動 of 32
L TR20071038, Rev . B 1/4/07.
Copyright 2006-2007 California Acrylic Industries, Inc. All rights reserved. Duplication without written consent is strictly prohibited. Cal Spas™ and Cal Flame™ are registered trademarks. Due to continuous improvement programs, all models, operation, and/or specications are subject to change without prior notice.
T able of Contents 2007 Barbecue Grill and Cart Owner ’s Manual Page 1 L TR20071038, Rev . B W ARNING If the information in this manual is not followed exactly , a re or explosion may result causing property damage, personal injury or loss of life.
Page 2 2007 Barbecue Grill and Cart Owner ’s Manual L TR20071038, Rev . B Safety Instructions Placement and Location Cal Flame™ grills and carts are designed for outdoor use only . Never locate this appliance in an enclosed room, under a sealed overhead structure, or in any type of enclosed area such as a garage, shed, or breezeway .
Safety Instructions 2007 Barbecue Grill and Cart Owner ’s Manual Page 3 L TR20071038, Rev . B blocked. Fresh air must be able to pass though installed vents to safeguard against residual gas accumulation. Failure to allow proper ventilation may cause re or explosion.
Page 4 2007 Barbecue Grill and Cart Owner ’s Manual L TR20071038, Rev . B Installation / Assembly Installation / Assembly Most cities and counties require permits for exterior construction and electrical circuits.
Installation / Assembly 2007 Barbecue Grill and Cart Owner ’s Manual Page 5 L TR20071038, Rev . B Model Number Description Width Depth Height Cut-out for drop in accessories BBQ07852P Drop In Standa.
Page 6 2007 Barbecue Grill and Cart Owner ’s Manual L TR20071038, Rev . B Installation / Assembly Model Number Description Width Depth Height Cut-out for refrigerators, cocktail centers and access doors BBQ07863P 3 Pull Out Drawer , SS Refr .
Installation / Assembly 2007 Barbecue Grill and Cart Owner ’s Manual Page 7 L TR20071038, Rev . B Gas Requirements and Connection IMPORT ANT : Cal Flame™ grills are manufactured to operate on either liquid propane (LP) or natural gas (NG) and cannot be converted.
Page 8 2007 Barbecue Grill and Cart Owner ’s Manual L TR20071038, Rev . B Installation / Assembly One side of the enclosure shall be completely open. Enclosures that have four sides, complete with a top and bottom: At least two ventilation openings at cylinder valve level shall be provided in the sidewall, equally sized, spaced at 180º (3.
Installation / Assembly 2007 Barbecue Grill and Cart Owner ’s Manual Page 9 L TR20071038, Rev . B Natural Gas Requirements Always check the rating plate to make sure the gas supply you are hooking up to is the gas type the grill is manufactured for .
Page 10 2007 Barbecue Grill and Cart Owner ’s Manual L TR20071038, Rev . B Installation / Assembly Installing and Replacing Infrared Burners Disconnect or shut off the liquid propane or natural gas line connect to the grill. W ait until the burners cool down.
Installation / Assembly 2007 Barbecue Grill and Cart Owner ’s Manual Page 1 1 L TR20071038, Rev . B Installing the T ransformer All grills with electrical components such as lights or a convection fan will require the transformer to be installed and plugged in before you can use it.
Page 12 2007 Barbecue Grill and Cart Owner ’s Manual L TR20071038, Rev . B Installation / Assembly Installing Grills in Modular Carts Y ou will need a second person to help you to avoid damaging the grill, the transformer , or your barbecue island. Keep ngers away from where the grill will be supported on the cart.
Installation / Assembly 2007 Barbecue Grill and Cart Owner ’s Manual Page 13 L TR20071038, Rev . B Installing Barbecue Cart End Shelves Prepare the installation of handle: 2 hex screws, 2 washers Use nger to thread the hex screws and washers into the threads on both ends of the handle.
Page 14 2007 Barbecue Grill and Cart Owner ’s Manual L TR20071038, Rev . B Installation / Assembly Installing Side Burners Assemble a 3/8” pipe nipple to the 3/8” pipe tee using T eon tape or pipe sealant. Use only sealant that is approved for use on LP gas.
Operating Y our Barbecue 2007 Barbecue Grill and Cart Owner ’s Manual Page 15 L TR20071038, Rev . B Light Switch Grill Grill Grill Infrared Burner BBQ07873 - 3 Burner Grill CR3000 - 3 Burner Cart Li.
Page 16 2007 Barbecue Grill and Cart Owner ’s Manual L TR20071038, Rev . B Operating Y our Barbecue Each time you light the grill, check the following: Inspect the hose before using the grill. If there is excessive abrasion or wear , or if the hose is cut, it must be replaced prior to using the grill.
Operating Y our Barbecue 2007 Barbecue Grill and Cart Owner ’s Manual Page 17 L TR20071038, Rev . B Basic Grill Operation Before lighting, make sure all burner controls are off. Do not attempt to light the burners if the smell of gas is present. Check the connection with a soap and water solution after attaching the hose.
Page 18 2007 Barbecue Grill and Cart Owner ’s Manual L TR20071038, Rev . B Operating Y our Barbecue Cooking with a Convection Grill A convection grill has an internal fan that circulates heated air evenly throughout the grilling area when the hood is closed.
Operating Y our Barbecue 2007 Barbecue Grill and Cart Owner ’s Manual Page 19 L TR20071038, Rev . B Charcoal Grill Lighting Instructions NEVER use ammable materials and uids such as gasoline, kerosene, butane or propane, diesel fuel, or alcohol to light or re-light res.
Page 20 2007 Barbecue Grill and Cart Owner ’s Manual L TR20071038, Rev . B Operating Y our Barbecue Griddle When sliding the griddle out of the enclosure, always do it slowly as the heavy weight may cause you to suddenly drop the griddle. Lift the griddle out of the enclosure instead of sliding it all the way out.
Operating Y our Barbecue 2007 Barbecue Grill and Cart Owner ’s Manual Page 21 L TR20071038, Rev . B High 210ºF – 230ºF Medium 190ºF – 210ºF Low 175ºF – 190ºF If you use the tray , preheat it while preheating the warming drawer . Preheat any empty serving dishes to be used while preheating the drawer .
Page 22 2007 Barbecue Grill and Cart Owner ’s Manual L TR20071038, Rev . B Cleaning and Maintenance Cleaning and Maintenance T o ensure safe and proper maintenance, we recommend you follow these directions carefully . Clean internal parts of the grill regularly as determined by the amount of use and foods cooked.
Cleaning and Maintenance 2007 Barbecue Grill and Cart Owner ’s Manual Page 23 L TR20071038, Rev . B Island Cabinets Be sure to unplug the electrical supply before cleaning any part of your Cal Flame barbecue. Spray cabinet area with a soap and water solution.
Page 24 2007 Barbecue Grill and Cart Owner ’s Manual L TR20071038, Rev . B Cleaning and Maintenance Use only clean sponges, soft cloths, paper towels, plastic or non-metal soap pads for cleaning or scouring, as recommended in this section. Be sure to rinse thoroughly and to wipe dry to avoid watermarks.
Appendix 2007 Barbecue Grill and Cart Owner ’s Manual Page 25 L TR20071038, Rev . B Appendix T roubleshooting Problem: Smell of gas is present Solution: Check for loose connections in the gas line. Perform a leak test following the procedure described in this manual.
Page 26 2007 Barbecue Grill and Cart Owner ’s Manual L TR20071038, Rev . B Appendix Problem: Plugged orice Solution: Unplug the orice as follows: Remove cooking grills, ame tamer and grease tray .
Appendix 2007 Barbecue Grill and Cart Owner ’s Manual Page 27 L TR20071038, Rev . B Replacement Covers Cal Flame Drop-Ins BBQ010 COVER, GRILL, SMALL, 3 BURNER BBQ01 1 COVER, GRILL, MEDIUM, 4 BURNER .
Page 28 2007 Barbecue Grill and Cart Owner ’s Manual L TR20071038, Rev . B.
.
Locating the product serial number The serial number of your Cal Flame grill is located on the back and is visible when the hood is down (see page 24). Y ou will need this number to properly register your grill or cart and activate coverage. Write this information in the space provided below .
デバイスCal Flame Barbeque Grillの購入後に（又は購入する前であっても）重要なポイントは、説明書をよく読むことです。その単純な理由はいくつかあります：
Cal Flame Barbeque Grillをまだ購入していないなら、この製品の基本情報を理解する良い機会です。まずは上にある説明書の最初のページをご覧ください。そこにはCal Flame Barbeque Grillの技術情報の概要が記載されているはずです。デバイスがあなたのニーズを満たすかどうかは、ここで確認しましょう。Cal Flame Barbeque Grillの取扱説明書の次のページをよく読むことにより、製品の全機能やその取り扱いに関する情報を知ることができます。Cal Flame Barbeque Grillで得られた情報は、きっとあなたの購入の決断を手助けしてくれることでしょう。
Cal Flame Barbeque Grillを既にお持ちだが、まだ読んでいない場合は、上記の理由によりそれを行うべきです。そうすることにより機能を適切に使用しているか、又はCal Flame Barbeque Grillの不適切な取り扱いによりその寿命を短くする危険を犯していないかどうかを知ることができます。
ですが、ユーザガイドが果たす重要な役割の一つは、Cal Flame Barbeque Grillに関する問題の解決を支援することです。そこにはほとんどの場合、トラブルシューティング、すなわちCal Flame Barbeque Grillデバイスで最もよく起こりうる故障・不良とそれらの対処法についてのアドバイスを見つけることができるはずです。たとえ問題を解決できなかった場合でも、説明書にはカスタマー・サービスセンター又は最寄りのサービスセンターへの問い合わせ先等、次の対処法についての指示があるはずです。
