FMIメーカーBVC-36Yの使用説明書/サービス説明書
ページ先へ移動 of 44
FIREBO X MODELS BV C-36Y , BV C-42Y AND BVC-50Y NA TURAL GAS MODULE MODELS BBM-36N-TKA, BBM-42N-TKA AND BBM-50N-TKA PROP ANE/LP MODULE MODELS BBM-36P-TKA, BBM-42P-TKA AND BBM-50P-TKA SPLIT BRICK P ANE.
www .fmiproducts.com 122280-01E 2 - .
www .fmiproducts.com 122280-01E 3 SAFETY W ARNING: This product con - .
www .fmiproducts.com 122280-01E 4 1 1. Keep the area arou nd y our repl ace clear of combustible materials, gasoline and other ammable vapor and liquids. Do not run re place where t hese a re use d or st ored . Do not pl ace it ems su ch as clo thin g or decorations on or around replace.
www .fmiproducts.com 122280-01E 5 INTRODUCTION Models BBM-36(N,P)-TKA, BBM-42(N,P)- TKA and BBM-50(N,P)-TKA are vented gas appliances that use an electronic control valve and electronic ignition system.
www .fmiproducts.com 122280-01E 6 SPECIFICA TIONS GAS RA TING - NA TURAL BBM-36N-TKA BBM-42N-TKA BBM-50N-TKA Max. Input Rating: 52,000 Btu/Hr 56,000 Btu/Hr 60,000 Btu/Hr Manifold Pressure: 3.5" WC (.87 kPa) 3.5" WC (.87 kPa) 3.5" WC (.87 kPa) Min.
www .fmiproducts.com 122280-01E 7 29" 14 1 / 2 " 22 1 / 2 " 26 5 / 8 " 4 1 / 2 " 15 5 / 8 " 4 1 / 2 " 1" 58" 7 1 / 4 " 1 1 " 15 1 / 4 " 3 1 .
www .fmiproducts.com 122280-01E 8 PRODUCT DIMENSIONS Continued 22 3 / 4 " 30 1 / 2 " 29" 4 3 / 8 " 15 3 / 4 " 5/8" 17 5 / 8 " 67" 61" 49" 7" 1&qu.
www .fmiproducts.com 122280-01E 9 PRODUCT DIMENSIONS Continued 38 1 / 2 " 28 1 / 2 " 4 3 / 8 " 17 5 / 8 " 19 1 / 4 " 24" 49" 30" 1 1 " 61" 67" 58.
www .fmiproducts.com 122280-01E 10 Figure 6 - Rough Opening Dimensions for Installing in a Wall 59 1 / 4 " (50") 58 1 / 8 " 30 1 / 8 " (42", 50") 28 1 / 4 " (36".
www .fmiproducts.com 122280-01E 11 PREINST ALLA TION PREP ARA TION Continued 6. Using screws or nails, secure replace to framing through anges located on sides of replace.
www .fmiproducts.com 122280-01E 12 VENTING INST ALLA TION A FMI PRODUCTS, LLC or an 8" B-type vent - ing sys tem mus t be con nect ed to appli ance for venting to the outside of building. T ransition pipe model BTC-8 is required for use with B-type venting.
www .fmiproducts.com 122280-01E 13 Figure 12 - T ypical Residential Installations VENTING INST ALLA TION Continued VENTING INST ALLA TION USING FMI .
www .fmiproducts.com 122280-01E 14 VENTING INST ALLA TION Continued ASSEMBL Y AND INST ALLA TION OF DOUBLE W ALL CHIMNEY SYSTEM Each double wall chimney section consists of a galvanized outer pipe, a stainless steel in - ner ue pipe and a wire spacer .
www .fmiproducts.com 122280-01E 15 VENTING INST ALLA TION Continued Pitch Slope Opening Used Flashing Model No. Flat 0° 15" V6F-8DM 0-6/12 26.
www .fmiproducts.com 122280-01E 16 Fireplace system must be terminated with listed round top or chase terminations. In any case, refer to insta llation instructions supplied with termination.
www .fmiproducts.com 122280-01E 17 Check this area along entire top edge of replace opening. Smoke or ame should be drawn into appliance opening. Figure 21 - Checking for Spillage VENTING INST ALLA TION Continued FINISHING FIREPLACE Combustible materials, such as wallboard, gypsum board, sheet rock, drywall, plywood, etc.
www .fmiproducts.com 122280-01E 18 IN PI L O T IN OUT VENT TH TP TH TP INST ALLA TION Continued Figure 25 - Connecting Incoming Gas Line to Flex Gas Line Gas Shutoff V alve Flexible Gas Line Do NOT Ki.
www .fmiproducts.com 122280-01E 19 REMOVING AND INST ALLING SMOKE SHELF 1.
www .fmiproducts.com 122280-01E 20 INST ALLA TION Continued RED IVOR Y QTY FULL (1 12140-01) FULL (1 12140-05) 4* ASH BRICK (120848-01) ASH BRICK (120848-02) 1 F012R F012W 2 F036R F036W 2 F079R F079W 2 F104R F104W 2 F128R F128W 2 F140R F140W 2 S109R S109W 2 * Includes 2 extra bricks.
www .fmiproducts.com 122280-01E 21 INST ALLA TION Continued 36" SPLIT ST ACKED BRICK MA TRIX LEFT REFRACTOR Y RED IVOR Y QTY FULL (1 12140-02) FULL (1 12140-06) 16 S043R S043W 1 S044R S044W 1 S04.
www .fmiproducts.com 122280-01E 22 INST ALLA TION Continued 42" SPLIT ST ACKED BRICK MA TRIX LEFT REFRACTOR Y RED IVORY QTY FULL (1 12140-02) FULL (1 12140-06) 17 S045R S045W 1 S046R S046W 5 S050.
www .fmiproducts.com 122280-01E 23 INST ALLA TION Continued 50" SPLIT ST ACKED BRICK MA TRIX LEFT REFRACTOR Y RED IVORY QTY FULL (1 12140-02) FULL (1 12140-06) 16 S043R S043W 1 S045R S045W 1 S046.
www .fmiproducts.com 122280-01E 24 INST ALLA TION Continued 36" SPLIT HERRINGBONE BRICK MA TRIX LEFT REFRACTOR Y RED IVORY QTY FULL (1 12140-02) FULL (1 12140-06) 12 S001R S001W 1 S002R S002W 1 S.
www .fmiproducts.com 122280-01E 25 INST ALLA TION Continued 42" SPLIT HERRINGBONE BRICK MA TRIX LEFT REFRACTOR Y RED IVOR Y QTY FULL (1 12140-02) FULL (1 12140-06) 19 S001R S001W 2 S002R S002W 9 .
www .fmiproducts.com 122280-01E 26 INST ALLA TION Continued 50" SPLIT HERRINGBONE BRICK MA TRIX LEFT REFRACTOR Y RED IVOR Y QTY FULL (1 12140-02) FULL (1 12140-06) 18 S001R S001W 2 S002R S002W 1 .
www .fmiproducts.com 122280-01E 27 Figure 29 - Grouting Brick GROUTING INSTRUCTIONS Material provided: 1 or 2 - 10 lb. bags of cement (depending on model) 1 or 2 - 10 lb. bags of sand (depending on model) Material required: 1 - Piping bag 1 - Joints striker 1 - Heavy duty mixing bucket 1 - T rowel 1.
www .fmiproducts.com 122280-01E 28 INST ALLING MODULE Before installing module, make sure all bat - teries have been installed (see Installing Bat- teries in Wireless Hand-Held Remote Control and Receiver . See Removing and Installing Smoke Shelf on page 18 to reinstall limit switch and smoke shelf.
www .fmiproducts.com 122280-01E 29 INST ALLA TION Continued Figure 34 - Installing Fireplace Screen Ring Screen Push On Nut Screen Rod Bracket Smoke Shelf Screen Rod Fireplace Front CAUTION: Gloves sh.
www .fmiproducts.com 122280-01E 30 INST ALLA TION Continued Figure 37 - Installing Bi-Fold Doors Spring Clip Insert Pin into Spring Clip Pivot Hole Insert Bottom Pivot Pin into Hole Fold Door and Slid.
www .fmiproducts.com 122280-01E 31 OPERA TION FOR YOUR SAFETY READ BEFORE LIGHTING W ARNING: If you do not fol- .
www .fmiproducts.com 122280-01E 32 OPERA TION Continued COMBUSTION AIR KIT MODEL AK4 (OPTIONAL) The outside air kit lever is located at the left and right hand sides of replace (see Figure 40). The vent can be installed through any outside wall a minimum of three feet below replace termination cap.
www .fmiproducts.com 122280-01E 33 CLEANING AND MAINTENANCE W ARNING: Installation and - .
www .fmiproducts.com 122280-01E 34 REPLACEMENT P ARTS Note: Use only original replacement parts. This will protect your warranty coverage for parts replaced under warranty . Contact authorized dealers of this product. If they can’t supply original replacement part(s), call FMI PRODUCTS, LLC at 1-866-328-4537.
www .fmiproducts.com 122280-01E 35 CONTROL MODULE BA TTERY RELA Y BA TTER Y PACK REMOTE RECIEVER V A L V E THTP TP TH Red Bk Bn Bk "D" SIZE "D" SIZE Bn 4 "AA" SIZE BA TTE.
www .fmiproducts.com 122280-01E 36 TROUBLESHOO TING Note: Before troubleshooting the system, make sure the gas shutoff valve is ON. The two most common causes of a malfunctioning gas appliance are: 1.
www .fmiproducts.com 122280-01E 37 TROUBLESHOO TING Continued .
www .fmiproducts.com 122280-01E 38 P ARTS 1 22 27 21 6 7 10 9 1 1 12 13 15/16 14 8 26 25 2 3.
www .fmiproducts.com 122280-01E 39 P ARTS This list contains replaceable parts used in your heater . When ordering parts, follow the instructions listed under Replacement Parts on page 34 of this manual.
www .fmiproducts.com 122280-01E 40 P ARTS .
www .fmiproducts.com 122280-01E 41 P ARTS This list contains replaceable parts used in your heater . When ordering parts, follow the instructions listed under Replacement Parts on page 34 of this manual.
www .fmiproducts.com 122280-01E 42 P ARTS This list contains replaceable parts used in your heater . When ordering parts, follow the instructions listed under Replacement Parts on page 34 of this manual.
www .fmiproducts.com 122280-01E 43 _____________________________________________________ ______________________________________________________ ______________________________________________________ _.
122280-01 Rev . E 04/10 WARRANTY KEEP THIS WARRANTY FMI PRODUCTS, LL C LIMITED WARRANTIES Standard Warranty: F MI P RO D UC TS , LL C wa r ra nt s th is n ew p ro .
デバイスFMI BVC-36Yの購入後に（又は購入する前であっても）重要なポイントは、説明書をよく読むことです。その単純な理由はいくつかあります：
FMI BVC-36Yをまだ購入していないなら、この製品の基本情報を理解する良い機会です。まずは上にある説明書の最初のページをご覧ください。そこにはFMI BVC-36Yの技術情報の概要が記載されているはずです。デバイスがあなたのニーズを満たすかどうかは、ここで確認しましょう。FMI BVC-36Yの取扱説明書の次のページをよく読むことにより、製品の全機能やその取り扱いに関する情報を知ることができます。FMI BVC-36Yで得られた情報は、きっとあなたの購入の決断を手助けしてくれることでしょう。
FMI BVC-36Yを既にお持ちだが、まだ読んでいない場合は、上記の理由によりそれを行うべきです。そうすることにより機能を適切に使用しているか、又はFMI BVC-36Yの不適切な取り扱いによりその寿命を短くする危険を犯していないかどうかを知ることができます。
ですが、ユーザガイドが果たす重要な役割の一つは、FMI BVC-36Yに関する問題の解決を支援することです。そこにはほとんどの場合、トラブルシューティング、すなわちFMI BVC-36Yデバイスで最もよく起こりうる故障・不良とそれらの対処法についてのアドバイスを見つけることができるはずです。たとえ問題を解決できなかった場合でも、説明書にはカスタマー・サービスセンター又は最寄りのサービスセンターへの問い合わせ先等、次の対処法についての指示があるはずです。
