Hearth and Home TechnologiesメーカーGBI25の使用説明書/サービス説明書
ページ先へ移動 of 24
02-02 1 26678 Rev H THE GBi25 SERIES B-VENT GAS FIRED FIREPLACE INSERT ROOM HEA TER INST ALLA TION & OPERA TING INSTRUCTIONS This manual must be used for installation of the GBi25 series B-V ent Gas Fired Fireplace Insert and retained by the homeowner for operation and maintenance instructions.
26678 Rev H 2 02-02 GBI25 SERIES B-VENT GAS FIRED FIREPLACE INSERT CAUTION: Do not expose the appliance to the elements (such as rain, etc.) SAFETY PRECAUTIONS 1. Please read these installation instructions completely before beginning installation procedures.
02-02 3 26678 Rev H GBI25 SERIES B-VENT GAS FIRED FIREPLACE INSERT A. LISTINGS AND CODE APROV ALS U.S. AND CANADA CERTIFICA TION This appliance has been tested in accordance with ANSI Z21.1 1.1-1991, CAN/CGA 1-2.1-MB6 and applicable sections of ANSI Z21.
26678 Rev H 4 02-02 GBI25 SERIES B-VENT GAS FIRED FIREPLACE INSERT C. SYSTEM COMPONENTS The table below is a list of only those components which may be safely used with this gas-fired fireplace insert.
02-02 5 26678 Rev H GBI25 SERIES B-VENT GAS FIRED FIREPLACE INSERT E. PRE-INST ALLA TION PREP ARA TION Installation and repair should be done by a qualified service technician. The appliance should be inspected before use and at least annually by a qualified service technician.
26678 Rev H 6 02-02 GBI25 SERIES B-VENT GAS FIRED FIREPLACE INSERT F . STEP-BY -STEP INST ALLA TION OF THE SYSTEM WARNING! Before starting, do the following: 1. Wear gloves and safety glasses for protection. 2. Keep hand tools in good contition. Sharpen cutting edges and make sure tool handles are secure.
02-02 7 26678 Rev H GBI25 SERIES B-VENT GAS FIRED FIREPLACE INSERT Seal with high temperature silicone at the point where the gas line enters the existing fireplace to prevent cold air infiltration.
26678 Rev H 8 02-02 GBI25 SERIES B-VENT GAS FIRED FIREPLACE INSERT b . Installation of Appliance 1) The appliance should be set on a level surface. Located on the bottom pan of the appliance are two 5/16-18 nuts. Bolts (provided) may be used for leveling purposes.
02-02 9 26678 Rev H GBI25 SERIES B-VENT GAS FIRED FIREPLACE INSERT 7) DO NOT P ACK INSULA TION INSIDE THE SURROUND. 8) Remove the switch from wire assembly and feed wire through the brass trim. See Figure15. Re-install the switch to the wires and push into place.
26678 Rev H 10 02-02 GBI25 SERIES B-VENT GAS FIRED FIREPLACE INSERT d . Rock Wool Placement The log set is shipped in place. T ear the rock wool into pieces no larger than 1/2 diameter . Place the rock wool in front of the flange located in the middle of the burner .
02-02 11 26678 Rev H GBI25 SERIES B-VENT GAS FIRED FIREPLACE INSERT h . Firebox Bottom Removal 1) Shut off the gas to the appliance before removing. Remove the glass frame following instructions found in S tep 3a. on page 7. 2) Remove the two screws on the log assembly (Figure 20).
26678 Rev H 12 02-02 GBI25 SERIES B-VENT GAS FIRED FIREPLACE INSERT 4. WIRING a. A 1 10V AC outlet should be located close to the lower left side of the appliance to allow the fan to be plugged in. See Figure 24. Figure 24 - Wiring Diagram Note: This appliance REQUIRES a 1 10V AC supply for operation of the fan.
02-02 13 26678 Rev H GBI25 SERIES B-VENT GAS FIRED FIREPLACE INSERT Figure 25 - Wiring Diagram Note: The fan will not turn on until the appliance has reached its proper operating temperature. This is determined by a thermal disc in the fan assembly . Also, the fan will continue to run until the appliance has cooled sufficiently after shutdown.
26678 Rev H 14 02-02 GBI25 SERIES B-VENT GAS FIRED FIREPLACE INSERT G . OPERA TING INSTRUCTIONS 1. This gas appliance has a manual ignition device that lights the pilot. When lighting the pilot, follow these instructions exactly . 2. STOP! BEFORE READING FURTHER, smell around the appliance area for gas.
02-02 15 26678 Rev H GBI25 SERIES B-VENT GAS FIRED FIREPLACE INSERT 1 . OPERA TION PROCEDURE DURING REGULAR USE Turn the switch/thermostat to the ON position. This will ignite the main burner . 2. SHUTDOWN DURING REGULAR USE Simply turn the switch/thermotat to OFF .
26678 Rev H 16 02-02 GBI25 SERIES B-VENT GAS FIRED FIREPLACE INSERT H. MAINTENANCE INSTRUCTIONS 1. CLEANING THE BURNER AND CONTROL COMP ARTMENT Keep the burner and control compartment clean by using a clean, dry paint brush and vacuum at least once a year .
02-02 17 26678 Rev H GBI25 SERIES B-VENT GAS FIRED FIREPLACE INSERT I. TROUBLESHOOTING m e l b o r Pe s u a Cn o i t c A e v i t c e r r o C . 1t o l i p t h g i l t o n l l i w r o t i n g i k r a p S d e r f o g n i s s e r p d e t a e p e r r e t f a .
26678 Rev H 18 02-02 GBI25 SERIES B-VENT GAS FIRED FIREPLACE INSERT J. REPLACEMENT PARTS Replacement part s are available from your distributor/dealer , or through Heatilator T echnical Services Department, Hearth T echnologies Inc., 1915 W . Saunders Street, Mt.
02-02 19 26678 Rev H GBI25 SERIES B-VENT GAS FIRED FIREPLACE INSERT M E T I# T R A PN O I T P I R C S E D 13 5 6 6 2e l l i r G 23 2 5 6 2 9 0 5 6 2 2 7 6 6 2 y l b m e s s A e m a r F s s a l G e m a.
26678 Rev H 20 02-02 GBI25 SERIES B-VENT GAS FIRED FIREPLACE INSERT HOMEOWNERS NOTES.
02-02 21 26678 Rev H GBI25 SERIES B-VENT GAS FIRED FIREPLACE INSERT HOMEOWNERS NOTES.
26678 Rev H 22 02-02 GBI25 SERIES B-VENT GAS FIRED FIREPLACE INSERT HOMEOWNERS NOTES.
02-02 23 26678 Rev H GBI25 SERIES B-VENT GAS FIRED FIREPLACE INSERT Index A Air Shutter 15 Appliance Installation 7 B Baffle Removal 7 Brass Trim 9 Building Supplies 3 C Certification 3 Cleaning Burne.
26678 Rev H 24 02-02 Gas Appliance (Fireplace) Limited Lifetime W arranty HEARTH TECHNOLOGIES INC. (HTI) extends the following warranty for HEA TILA TOR â gas appliances installed in the United St ates of America or Canada (the Appliance).
デバイスHearth and Home Technologies GBI25の購入後に（又は購入する前であっても）重要なポイントは、説明書をよく読むことです。その単純な理由はいくつかあります：
Hearth and Home Technologies GBI25をまだ購入していないなら、この製品の基本情報を理解する良い機会です。まずは上にある説明書の最初のページをご覧ください。そこにはHearth and Home Technologies GBI25の技術情報の概要が記載されているはずです。デバイスがあなたのニーズを満たすかどうかは、ここで確認しましょう。Hearth and Home Technologies GBI25の取扱説明書の次のページをよく読むことにより、製品の全機能やその取り扱いに関する情報を知ることができます。Hearth and Home Technologies GBI25で得られた情報は、きっとあなたの購入の決断を手助けしてくれることでしょう。
Hearth and Home Technologies GBI25を既にお持ちだが、まだ読んでいない場合は、上記の理由によりそれを行うべきです。そうすることにより機能を適切に使用しているか、又はHearth and Home Technologies GBI25の不適切な取り扱いによりその寿命を短くする危険を犯していないかどうかを知ることができます。
ですが、ユーザガイドが果たす重要な役割の一つは、Hearth and Home Technologies GBI25に関する問題の解決を支援することです。そこにはほとんどの場合、トラブルシューティング、すなわちHearth and Home Technologies GBI25デバイスで最もよく起こりうる故障・不良とそれらの対処法についてのアドバイスを見つけることができるはずです。たとえ問題を解決できなかった場合でも、説明書にはカスタマー・サービスセンター又は最寄りのサービスセンターへの問い合わせ先等、次の対処法についての指示があるはずです。
