HoshizakiメーカーB-1300SSの使用説明書/サービス説明書
ページ先へ移動 of 17
1 Hoshizaki “A Superior Degree of Reliability” www .hoshizaki.com Model B-1150SS B-1300SS B-1500SS B-1650SS Ice Bin Hoshizaki America, Inc. Issued: 2-15-2005 Revised: 8-28-200 6 I N S T R U C T I .
2 FOREW ORD IMPOR T ANT Only qualified ser vice technicians should attempt to install, ser vice or maintain this ice bin. No such installation, ser vice or maintenance should be under taken until the technician has thoroughly read this Instruction Manual.
3 • Please re vie w this manual. It should be read carefully bef ore the ice bin is installed and used. Only qualified ser vice technicians should install, ser vice and maintain the ice bin. This manual should be made a vailab le to the technician prior to installation, maintenance or ser vice.
4 I. Specifications A. Dimensions 1. B-1150SS units: mm [in.].
5 2. B-1300SS units: mm [in.].
6 3. B-1500SS units: mm [in.].
7 4. B-1650SS units: mm [in.].
8 II. Installation Instructions A. Checks Bef ore Installation IMPOR T ANT 1. This ice bin is designed and intended to be used in combination with a Hoshizaki Modular Icemaker .
9 C. Setup CA UTION It is especially impor tant that the ice bin is lev eled in both left-to-r ight and front- to-rear directions. If it is not le v el, the result could be the production of smaller or irregular shaped cubes or of ov erflow into the ice bin.
10 Single Icemaker Unit Dual Icemaker Units 2. Installing the Icemaker 1) Unpack the icemak er , and remov e all shipping car tons, tape(s) and pac kaging. 2) Ref er to the char ts below and also to the "SET UP" instructions on the icemaker when installing the icemaker .
11 Fig. 3 D . Drain Connections See Fig. 3 • A drain outlet, 1" f emale thread, is located on the bottom of the ice bin. • The drain must ha ve a 1/4" f all per foot on horizontal runs to get a good flow . • The ice bin drain connection must be made separ ately from the icemak er drains .
12 E. Final Check List 1) Is the icemaker/ice bin le v el? 2) Is the icemaker/ice bin in a site where the ambient temper ature is within +45°F to +100°F all year around? (A void sites with direct sunlight.
13 III. Operating Instructions See Fig. 4 A. Baffle The baffle pre v ents ice in the bin from flo wing out onto the floor while the bin door is open. 1. Remov al 1) Rotate the back edge of the baffle up about 6 inches (15 cm). 2) Pull the baffle f orw ard.
14 C. Probe (Optional Accessory) The probe is used to break apar t ice when it has br idged inside the bin and will not flow into the snout. T o break apar t ice, f ollow the steps below . 1) Open the bin door . 2) Inser t the probe through the hole in the snout (just abov e the baffle).
15 IV . Cleaning and Maintenance Instructions IMPOR T ANT Ensure all components, f asteners and thumbscrews are securely in place after any maintenance or cleaning is done to the equipment. A. Cleaning Instructions W ARNING 1. HOSHIZAKI recommends cleaning this unit at least once a year .
16 2. Sanitizing Procedure - Follo wing Cleaning Procedure 1) W ash all par ts cleaned in the cleaning procedure using the f ollowing sanitizing solution: 1/2 fl. oz. of a 5.25% sodium hypochlorite solution (chlorine bleach) diluted in 1 gallon of water .
17 HOSHIZAKI AMERICA, INC. 618 Hwy . 74 S., Peachtree City , GA 30269 USA TEL (770) 487-2331 F AX (770) 487-3360 www .hoshizaki.com 91A4LA10D.
デバイスHoshizaki B-1300SSの購入後に（又は購入する前であっても）重要なポイントは、説明書をよく読むことです。その単純な理由はいくつかあります：
Hoshizaki B-1300SSをまだ購入していないなら、この製品の基本情報を理解する良い機会です。まずは上にある説明書の最初のページをご覧ください。そこにはHoshizaki B-1300SSの技術情報の概要が記載されているはずです。デバイスがあなたのニーズを満たすかどうかは、ここで確認しましょう。Hoshizaki B-1300SSの取扱説明書の次のページをよく読むことにより、製品の全機能やその取り扱いに関する情報を知ることができます。Hoshizaki B-1300SSで得られた情報は、きっとあなたの購入の決断を手助けしてくれることでしょう。
Hoshizaki B-1300SSを既にお持ちだが、まだ読んでいない場合は、上記の理由によりそれを行うべきです。そうすることにより機能を適切に使用しているか、又はHoshizaki B-1300SSの不適切な取り扱いによりその寿命を短くする危険を犯していないかどうかを知ることができます。
ですが、ユーザガイドが果たす重要な役割の一つは、Hoshizaki B-1300SSに関する問題の解決を支援することです。そこにはほとんどの場合、トラブルシューティング、すなわちHoshizaki B-1300SSデバイスで最もよく起こりうる故障・不良とそれらの対処法についてのアドバイスを見つけることができるはずです。たとえ問題を解決できなかった場合でも、説明書にはカスタマー・サービスセンター又は最寄りのサービスセンターへの問い合わせ先等、次の対処法についての指示があるはずです。
