HoshizakiメーカーF-330BAH(-C)の使用説明書/サービス説明書
ページ先へ移動 of 17
® Hoshizaki “A Superior Degree of Reliability” www .hoshizaki.com Model F-330BAH(-C) Self-Contained Flaker Hoshizaki America, Inc. Issued: 5-4-2007 Revised: 9-5-2007 I N S T R U C T I O N M A N U.
IMPORTANT Only qualied service technicians should attempt to install, service, or maintain this icemaker. No installation, service, or maintenance should be undertaken until the technician has thoroughly read this Instruction Manual.
3 CONTENTS I. Specications ..................................................................................................................... 4 A. Nameplate Rating .................................................................................
4 I. Specications A. Nameplate Rating 1. F-330BAH, F-330BAH-C See the nameplate for electrical and refrigeration specications. This nameplate is located on the rear panel. We reserve the right to make changes in specications and design without prior notice.
5 B. Dimensions/Connections 1. F-330BAH, F-330BAH-C Unit = inches (mm).
6 II. Installation and Operating Instructions A. Checks Before Installation IMPORTANT 1. Install in accordance with all applicable national, state, and local regulations. . Remove shipping carton, tape, and packing. If any are left in the icemaker, it will not work properly.
7 C. Location CAUTION This icemaker is not intended for outdoor use. Normal operating ambient temperature should be within +45°F to +100°F (+7°C to +38°C); Normal operating water temperature should be within +45°F to +90°F (+7°C to +3°C).
8 • Drain line should not be piped directly to the sewer system. An air gap of a minimum of vertical inches (5 cm) should be between the end of the drain pipe from the unit and the oor drain. • This icemaker must be installed in accordance with applicable national, state, and local regulations.
9 G. Final Checklist 1) Is the icemaker level? ) Is the icemaker in a site where the ambient temperature is within +45°F to +100°F (+7°C to +38°C) and the water temperature within +45°F to +90.
10 H. Startup CAUTION 1. All parts are factory-adjusted. Improper adjustments may result in failure. . If the unit is turned off, wait for at least 3 minutes before restarting the icemaker to prevent damage to the compressor. 1) Clean the storage bin.
11 III. Cleaning and Maintenance A. Cleaning and Sanitizing Instructions IMPORTANT Ensure all components, fasteners, and thumbscrews are securely in place after any maintenance or cleaning is done to the equipment. WARNING 1. HOSHIZAKI recommends cleaning this unit at least twice a year.
1 6) Lift up the top insulation and unsnap the bin control assembly. Lift the assembly up through the insulation and set it aside. See Fig. 4. 7) Remove the top insulation. 8) Remove the thumbscrews attaching spout (B) to the bin, then remove spout (B).
13 19) When the gear motor starts, remove the front panel and move the ush switch to the "FLUSH" position to drain out the water from the icemaker. 0) After the water has drained, move the power switch to the "OFF" position and unplug the unit.
14 4) Remove the top panel. 5) Remove the bin control assembly from the top insulation and set it aside. Remove the top insulation. 6) Remove the thumbscrews attaching spout (B) to the bin, then remove spout (B).
15 B. Maintenance IMPORTANT 1. This icemaker must be maintained individually, referring to the instruction manual and labels provided with the icemaker.
16 C. Preparing the Icemaker for Long Storage CAUTION When the icemaker is not used for two or three days under normal conditions, it is sufcient to only move the power switch to the "OFF" position.
17 HOSHIZAKI AMERICA, INC. 618 Hwy . 74 S., Peachtree City , GA 30269 USA TEL (770) 487-2331 F AX (770) 487-3360 www .hoshizaki.com 91A2SA10B.
デバイスHoshizaki F-330BAH(-C)の購入後に（又は購入する前であっても）重要なポイントは、説明書をよく読むことです。その単純な理由はいくつかあります：
Hoshizaki F-330BAH(-C)をまだ購入していないなら、この製品の基本情報を理解する良い機会です。まずは上にある説明書の最初のページをご覧ください。そこにはHoshizaki F-330BAH(-C)の技術情報の概要が記載されているはずです。デバイスがあなたのニーズを満たすかどうかは、ここで確認しましょう。Hoshizaki F-330BAH(-C)の取扱説明書の次のページをよく読むことにより、製品の全機能やその取り扱いに関する情報を知ることができます。Hoshizaki F-330BAH(-C)で得られた情報は、きっとあなたの購入の決断を手助けしてくれることでしょう。
Hoshizaki F-330BAH(-C)を既にお持ちだが、まだ読んでいない場合は、上記の理由によりそれを行うべきです。そうすることにより機能を適切に使用しているか、又はHoshizaki F-330BAH(-C)の不適切な取り扱いによりその寿命を短くする危険を犯していないかどうかを知ることができます。
ですが、ユーザガイドが果たす重要な役割の一つは、Hoshizaki F-330BAH(-C)に関する問題の解決を支援することです。そこにはほとんどの場合、トラブルシューティング、すなわちHoshizaki F-330BAH(-C)デバイスで最もよく起こりうる故障・不良とそれらの対処法についてのアドバイスを見つけることができるはずです。たとえ問題を解決できなかった場合でも、説明書にはカスタマー・サービスセンター又は最寄りのサービスセンターへの問い合わせ先等、次の対処法についての指示があるはずです。
