Monessen HearthメーカーLX32DVの使用説明書/サービス説明書
ページ先へ移動 of 48
Installation and Operati.
2 51D0528 LX Ser ies Dir ect V ent Gas F ireplace .
51D0528 3 LX Ser ies Dir ect V ent Gas F ireplace 4. Never install the fireplace • in a recreational vehicle • where curtains, furniture, clothing, or other flam- mable objects are less than 42" from the front, top, or sides of the fireplace • in high traffic areas • in windy or drafty areas 5.
4 51D0528 LX Ser ies Dir ect V ent Gas F ireplace 14. Do not use any solid fuels (wood, coal, paper , card- board, etc.) in this fireplace. Use only the gas type indicated on rating plate.
51D0528 5 LX Ser ies Dir ect V ent Gas F ireplace • This appliance has been certified for use with either natural or propane gas. See appropriate data plates. • This appliance is not for use with solid fuels.
6 51D0528 LX Ser ies Dir ect V ent Gas F ireplace Min.
51D0528 7 LX Ser ies Dir ect V ent Gas F ireplace .
8 51D0528 LX Ser ies Dir ect V ent Gas F ireplace Plan for the installation of your appliance.
51D0528 9 LX Ser ies Dir ect V ent Gas F ireplace .
10 51D0528 LX Ser ies Dir ect V ent Gas F ireplace The fireplace must be secured to the floor and/or to framing studs as shown in Figure 6 . Use two (2) wood screws or masonry/ concrete screws to secure fireplace to the floor . Use four (4) screws to attach fireplace to framing.
51D0528 1 1 LX Ser ies Dir ect V ent Gas F ireplace The appliance is shipped as a rear vent unit.
12 51D0528 LX Ser ies Dir ect V ent Gas F ireplace Consult local building codes before beginning the installation. The installer must make sure to select the proper vent system for installation.
51D0528 13 LX Ser ies Dir ect V ent Gas F ireplace .
14 51D0528 LX Ser ies Dir ect V ent Gas F ireplace There are two basic types of direct-vent installation: • Horizontal T ermination • V ertical T ermination It is important to select the proper length of vent pipe for the type of termination you choose.
51D0528 15 LX Ser ies Dir ect V ent Gas F ireplace V V V V V V V X X X D E B B B C B M B A J K F L VENT TERMINA TION AIR SUPPL Y INLET AREA WHERE TERMINAL IS NOT PERMITTED H I Fixed Closed Operable Operable Fixed Closed V B CFM145a DV T ermin Location 5/01/01 Rev .
16 51D0528 LX Ser ies Dir ect V ent Gas F ireplace 40 38 36 34 32 30 28 26 24 22 20 18 16 14 12 10 8 6 4 2 2 4 6 8 10 12 14 16 18 20 eg: A FP2714 sidewall ven t graph .
51D0528 17 LX Ser ies Dir ect V ent Gas F ireplace .
18 51D0528 LX Ser ies Dir ect V ent Gas F ireplace HOT FP2715 horiz cap w shield Figure 17 - Installing Horizontal V ent Cap V ent Cap Ap.
51D0528 19 LX Ser ies Dir ect V ent Gas F ireplace FP1176 max 90 bends Figure 20 - Maximum Three (3) 90° Elbows Per Installation 3 x 90° Elbows 3 x 90° Elbows FP1 176 Max 20" Max 20" 36" (914 mm) Max.
20 51D0528 LX Ser ies Dir ect V ent Gas F ireplace When it is not possible to meet the required vent terminal clearan ces of 12" above grade level, a snorkel kit is recom- mended.
51D0528 21 LX Ser ies Dir ect V ent Gas F ireplace FP1183 max height 10' Maximum 40' Maximum Height 8' Minimum Height Supp.
22 51D0528 LX Ser ies Dir ect V ent Gas F ireplace side. This prevents loose insulation from falling into the required clearance space. Figure 30. Otherwise, install firestop below the framed hole.
51D0528 23 LX Ser ies Dir ect V ent Gas F ireplace Use proper gas type for the fireplace you are installing. If you have conflicting gas type, do not install fireplace.
24 51D0528 LX Ser ies Dir ect V ent Gas F ireplace The gas line connection may be made using 1/2" rigid tubing or an approved flex connector . Since some municipalities have additional local codes it is always best to consult your local authorities and the current edition of the National Fuel Gas Code ANSI.
51D0528 25 LX Ser ies Dir ect V ent Gas F ireplace 1. Check gas type. The gas supply must be the same as stated on the appliance’s rating decal.
26 51D0528 LX Ser ies Dir ect V ent Gas F ireplace A remote wall switch and up to fifteen (15) feet of 18 Ga. wire may be used with this appliance. Attach the wall switch in a junction box at the desired location on the wall.
51D0528 27 LX Ser ies Dir ect V ent Gas F ireplace OFF FP2718 remov e glass frame 1. Release two clamps on bottom of fireplace. Figure 37 2. T ilt glass frame out and lift glass frame up until it clears three tabs on top of fireplace.
28 51D0528 LX Ser ies Dir ect V ent Gas F ireplace 1.
51D0528 29 LX Ser ies Dir ect V ent Gas F ireplace 4. Place rear log (#1) on two pins against back side of firebox. Figure 39 L G804 LX rear log Rear Log #1 LG804 Figure 39 L G803 LX left rear log Bottom Left Log #2 LG803 Figure 40 5.
30 51D0528 LX Ser ies Dir ect V ent Gas F ireplace L G809 LX right mid log L G807 LX top right log Right Mid Log #7 LG809 Figure 42 7. Place right mid log (#7) on two right pins on burner assembly . Figure 42 L G806 LX T op lef t log T op Left Log #4 LG806 Figure 43 8.
51D0528 31 LX Ser ies Dir ect V ent Gas F ireplace L G807 LX top log Center Log #8 LG806 Figure 45 1 0 . Place top center log (#8) across rear log (#1) pin and left mid log ( #6) p in. Fi gure 45 L G810 LX rockwool Rockwool LG810 Figure 46 L G811 LX rockwool Rockwool Air Space Under Rear Log 1 1.
32 51D0528 LX Ser ies Dir ect V ent Gas F ireplace FP2719 Lx air restrictor Bend T abs Up for All V ertical Applications On.
51D0528 33 LX Ser ies Dir ect V ent Gas F ireplace Figure 48 1. Align the four (4) holes on the facing with the four (4) holes on the fireplace.
34 51D0528 LX Ser ies Dir ect V ent Gas F ireplace This appliance is equipped with a pilot which must be lit with built-in ignitor while following these instructions exactly . BEFORE OPERA TING smell all around the appliance area for gas.
51D0528 35 LX Ser ies Dir ect V ent Gas F ireplace .
36 51D0528 LX Ser ies Dir ect V ent Gas F ireplace O F F P I L O T O N PILOT FP1937 control knob on The “ON/OFF/RS” switch for the main burner can be found behind door of the fireplace.
51D0528 37 LX Ser ies Dir ect V ent Gas F ireplace and .
38 51D0528 LX Ser ies Dir ect V ent Gas F ireplace • Never operate fireplace if glass is broken. • Replace any glass that is chipped, cracked, or broken.
51D0528 39 LX Ser ies Dir ect V ent Gas F ireplace .
40 51D0528 LX Ser ies Dir ect V ent Gas F ireplace 19 20 21 22 23 24 25 26 27 28 29 17 18 2 3 1 6 7 4 5 8 9 10 12 13 14 15 16 1 1 510528 LX parts .
51D0528 41 LX Ser ies Dir ect V ent Gas F ireplace 1.
42 51D0528 LX Ser ies Dir ect V ent Gas F ireplace 510528 LX trims .
51D0528 43 LX Ser ies Dir ect V ent Gas F ireplace .
44 51D0528 LX Ser ies Dir ect V ent Gas F ireplace.
51D0528 45 LX Ser ies Dir ect V ent Gas F ireplace.
46 51D0528 LX Ser ies Dir ect V ent Gas F ireplace This product must be installed by a licensed plumber or gas fitter when installed within the Commonwealth of Massachusetts.
51D0528 47 LX Ser ies Dir ect V ent Gas F ireplace The following components are warranted for life to the original owner , subject to proof of pur- chase: Firebox, Combustion Chamber , Heat Exchanger , Grate and Stainless Steel Burners.
149 Cleveland Drive • Paris, Kentucky 40361 www .mhsc.com Based on CSA P .4.1-09 Based on CSA P .4.1-09 Recher chez dans la broc hure les caractéristique de rendement énergétique de f oy er au gaz Énerguide Selon CSA P .
デバイスMonessen Hearth LX32DVの購入後に（又は購入する前であっても）重要なポイントは、説明書をよく読むことです。その単純な理由はいくつかあります：
Monessen Hearth LX32DVをまだ購入していないなら、この製品の基本情報を理解する良い機会です。まずは上にある説明書の最初のページをご覧ください。そこにはMonessen Hearth LX32DVの技術情報の概要が記載されているはずです。デバイスがあなたのニーズを満たすかどうかは、ここで確認しましょう。Monessen Hearth LX32DVの取扱説明書の次のページをよく読むことにより、製品の全機能やその取り扱いに関する情報を知ることができます。Monessen Hearth LX32DVで得られた情報は、きっとあなたの購入の決断を手助けしてくれることでしょう。
Monessen Hearth LX32DVを既にお持ちだが、まだ読んでいない場合は、上記の理由によりそれを行うべきです。そうすることにより機能を適切に使用しているか、又はMonessen Hearth LX32DVの不適切な取り扱いによりその寿命を短くする危険を犯していないかどうかを知ることができます。
ですが、ユーザガイドが果たす重要な役割の一つは、Monessen Hearth LX32DVに関する問題の解決を支援することです。そこにはほとんどの場合、トラブルシューティング、すなわちMonessen Hearth LX32DVデバイスで最もよく起こりうる故障・不良とそれらの対処法についてのアドバイスを見つけることができるはずです。たとえ問題を解決できなかった場合でも、説明書にはカスタマー・サービスセンター又は最寄りのサービスセンターへの問い合わせ先等、次の対処法についての指示があるはずです。
